Nautilus

The Termite and the Architect

In 1991, the multinational Old Mutual investment group approached the Zimbabwean architect Mick Pearce with an audacious assignment. The group wished to construct a retail and office complex called the Eastgate Centre in Zimbabwe’s capital city of Harare that, at 55,000 square meters, would be the country’s largest commercial building. What Old Mutual didn’t wish to do was pay the high cost of air-conditioning such a massive space. Could Pearce, working with the Arup construction firm, devise a design that relied solely on passive, natural climate control?

Pondering the problem, Pearce found inspiration in the termite mounds that dotted the savannas across his country. The largest mounds could reach several meters in height, dwarfing the legions of termites who built them just as a modern skyscraper towers over an individual construction worker. Each funneled air underground through networks of channels into a spherical nest that housed termites by the millions, and even larger numbers of fungi and bacteria. In all, a typical nest contained about a small cow’s worth of hot, breathing biomass. Based on the ideas of the Swiss entomologist Martin Lüscher, many researchers believed the mounds acted as air conditioners, maintaining a nest’s pleasant temperature, humidity, and oxygenation by continuously exchanging hot air rising from deep inside a colony with cooler drafts diffusing down from the surface. According to Lüscher, the mounds’ towering height allowed the “hot breath” of the colony’s biomass to drive this convective exchange. Lüscher’s theory came to prominence in 1961, reaching a wide audience through an article in Scientific American.

Imagining the mounds as air conditioners, Pearce drew up plans for a masonry-insulated building of large, open spaces shot through

You’re reading a preview, subscribe to read more.

More from Nautilus

Nautilus5 min read
The Bad Trip Detective
Jules Evans was 17 years old when he had his first unpleasant run-in with psychedelic drugs. Caught up in the heady rave culture that gripped ’90s London, he took some acid at a club one night and followed a herd of unknown faces to an afterparty. Th
Nautilus7 min read
Lithium, the Elemental Rebel
Inside every rechargeable battery—in electric cars and phones and robot vacuums—lurks a cosmic mystery. The lithium that we use to power much of our lives these days is so common as to seem almost prosaic. But this element turns out to be a wild card
Nautilus8 min read
The Bacteria That Revolutionized the World
There were no eyes to see it, but the sun shone more dimly in the sky, casting its languid rays on the ground below. A thick methane atmosphere enshrouded the planet. The sea gleamed a metallic green, and where barren rock touched the water, minerals

Related Books & Audiobooks