SENTINEL B-21 AND I-21
LEAK TEST INSTRUMENTS
GENERATION II
Instruction Manual
SENTINEL B-21
INSTRUMENT
SENTINEL I-21
INSTRUMENT
CINCINNATI TEST SYSTEMS, INC.
5555 Dry Fork Road
Cleves, OH 45002
(513) 367-6699
FAX (513) 367-5426 Rev7 9101Information in this document is subject to change without notice and does not represent a
commitment on the part of Cincinnati Test Systems, Inc. No part of the manual and/or
software may be reproduced or transmitted in any form or by any means, electronic or
mechanical, including photocopying, recording, or information storage and retrieval
systems, for any purpose, other than the purchaser’s personal use, without the express
permission of Cincinnati Test Systems, Inc.
No patent liability is assumed with respect to the use of the information contained herein.
While every precaution has been taken in the preparation of this book, Cincinnati Test
Systems, Inc. assumes no responsibility for errors or omissions.
Because of the variety of uses for this equipment and because of the differences between this
solid state equipment and electromechanical equipment, the user of and those responsible for
applying this equipment must satisfy themselves as to the acceptability of each application
and use of the equipment. In no event will Cincinnati Test Systems be responsible or liable
for indirect or consequential damages resulting from the use or application of this
equipment.
The illustrations, charts, and layout examples shown in this manual are intended solely to
illustrate the text of this manual, Because of the many variables and requirements associated
with any particular installation, Cincinnati Test Systems cannot assume responsibility or
liability for actual use based upon the illustrative uses and applications.SENTINEL B-21 and I-21 INSTRUMENTS
Table of Contents
Chapter 1 ..
Introduction
Accessories
Chapter 2
Installation
Chapter 3 ..
Instrument Overview
Chapter 4 ..
Start Up
Summary of Instrument Setup
Chapter 5 ..
Review or Change Test Parameters
LEAK, PRESS, TIMERS
Explanation of Test Parameters
Chapter 6 ..
‘Automatic Calibration (AUTO CAL)
Chapter 7 ..
SELF TEST (Leak Check Test Pneumatics)
Chapter 8
Communic
Chapter 9 ...
COUNTERS Display (COUNT)
Chapter 10
Instrument Configuration (MISC)
Date/Time
Auto Test
Modify Instrument Setup
Calibration and CHG Part Configuration
Test Circuit Version and Test Type Configuration
Machine Control Configuration
RS485 Communication Configuration
Security Configuration
Formats and Units Configuration
‘Transducer Configuration
Chapter 11. os
‘Tooling Control
Example Interface Wiring Diagrams
Internal Instrument Wiring Diagrams
Chapter 12... ose
Preventive Maintenance
Spare Parts
Chapter 13
Error Messages
wee Se
we 12-1