You are on page 1of 53

LCD TV

SERVICE MANUAL
CHASSIS : LP7BB

MODEL : 42LB9RT

42LB9RT-MD

CAUTION
BEFORE SERVICING THE CHASSIS,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.

CONTENTS

CONTENTS .............................................................................................. 2
SAFETY PRECAUTIONS ..........................................................................3
SPECIFICATION ........................................................................................6
ADJUSTMENT INSTRUCTION ...............................................................10
TROUBLE SHOOTING ............................................................................14
BLOCK DIAGRAM...................................................................................25
EXPLODED VIEW .................................................................................. 26
EXPLODED VIEW PARTS LIST ..............................................................27
REPLACEMENT PARTS LIST ............................................................... 28
SVC. SHEET ...............................................................................................

SAFETY PRECAUTIONS
IMPORTANT SAFETY NOTICE
Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by
in the
Schematic Diagram and Replacement Parts List.
It is essential that these special safety parts should be replaced with the same components as recommended in this manual to prevent
Shock, Fire, or other Hazards.
Do not modify the original design without permission of manufacturer.

General Guidance
An isolation Transformer should always be used during the
servicing of a receiver whose chassis is not isolated from the AC
power line. Use a transformer of adequate power rating as this
protects the technician from accidents resulting in personal injury
from electrical shocks.
It will also protect the receiver and it's components from being
damaged by accidental shorts of the circuitry that may be
inadvertently introduced during the service operation.
If any fuse (or Fusible Resistor) in this TV receiver is blown,
replace it with the specified.
When replacing a high wattage resistor (Oxide Metal Film Resistor,
over 1W), keep the resistor 10mm away from PCB.

Leakage Current Hot Check (See below Figure)


Plug the AC cord directly into the AC outlet.
Do not use a line Isolation Transformer during this check.
Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor
between a known good earth ground (Water Pipe, Conduit, etc.)
and the exposed metallic parts.
Measure the AC voltage across the resistor using AC voltmeter
with 1000 ohms/volt or more sensitivity.
Reverse plug the AC cord into the AC outlet and repeat AC voltage
measurements for each exposed metallic part. Any voltage
measured must not exceed 0.75 volt RMS which is corresponds to
0.5mA.
In case any measurement is out of the limits specified, there is
possibility of shock hazard and the set must be checked and
repaired before it is returned to the customer.

Leakage Current Hot Check circuit


Keep wires away from high voltage or high temperature parts.

AC Volt-meter

Before returning the receiver to the customer,


always perform an AC leakage current check on the exposed
metallic parts of the cabinet, such as antennas, terminals, etc., to
be sure the set is safe to operate without damage of electrical
shock.

Leakage Current Cold Check(Antenna Cold Check)


With the instrument AC plug removed from AC source, connect an
electrical jumper across the two AC plug prongs. Place the AC
switch in the on position, connect one lead of ohm-meter to the AC
plug prongs tied together and touch other ohm-meter lead in turn to
each exposed metallic parts such as antenna terminals, phone
jacks, etc.
If the exposed metallic part has a return path to the chassis, the
measured resistance should be between 1M and 5.2M.
When the exposed metal has no return path to the chassis the
reading must be infinite.
An other abnormality exists that must be corrected before the
receiver is returned to the customer.

To Instruments
exposed
METALLIC PARTS

0.15uF

Good Earth Ground


such as WATER PIPE,
CONDUIT etc.

1.5 Kohm/10W
Replaceable batteries

CAUTION
RISK OF EXPLOSION IF BATTERY
IS REPLACED BY AN INCORRECT
TYPE. DISPOSE OF USED
BATTERIES ACCORDING TO THE
INSTRUCTIONS

ADVARSEL
Lithiumbatteri - Eksplosionsfare ved
fejlagtig hndtening. Udskiftning m
kun ske med batteri at samme
fabrikat og type. Levr det brugte
batteri tilbage til leverandoren

SERVICING PRECAUTIONS
CAUTION: Before servicing receivers covered by this service
manual and its supplements and addenda, read and follow the
SAFETY PRECAUTIONS on page 3 of this publication.
NOTE: If unforeseen circumstances create conflict between the
following servicing precautions and any of the safety precautions on
page 3 of this publication, always follow the safety precautions.
Remember: Safety First.
General Servicing Precautions
1. Always unplug the receiver AC power cord from the AC power
source before;
a. Removing or reinstalling any component, circuit board
module or any other receiver assembly.
b. Disconnecting or reconnecting any receiver electrical plug or
other electrical connection.
c. Connecting a test substitute in parallel with an electrolytic
capacitor in the receiver.
CAUTION: A wrong part substitution or incorrect polarity
installation of electrolytic capacitors may result in an
explosion hazard.
2. Test high voltage only by measuring it with an appropriate high
voltage meter or other voltage measuring device (DVM,
FETVOM, etc) equipped with a suitable high voltage probe.
Do not test high voltage by "drawing an arc".
3. Do not spray chemicals on or near this receiver or any of its
assemblies.
4. Unless specified otherwise in this service manual, clean
electrical contacts only by applying the following mixture to the
contacts with a pipe cleaner, cotton-tipped stick or comparable
non-abrasive applicator; 10% (by volume) Acetone and 90% (by
volume) isopropyl alcohol (90%-99% strength)
CAUTION: This is a flammable mixture.
Unless specified otherwise in this service manual, lubrication of
contacts in not required.
5. Do not defeat any plug/socket B+ voltage interlocks with which
receivers covered by this service manual might be equipped.
6. Do not apply AC power to this instrument and/or any of its
electrical assemblies unless all solid-state device heat sinks are
correctly installed.
7. Always connect the test receiver ground lead to the receiver
chassis ground before connecting the test receiver positive
lead.
Always remove the test receiver ground lead last.
8. Use with this receiver only the test fixtures specified in this
service manual.
CAUTION: Do not connect the test fixture ground strap to any
heat sink in this receiver.
Electrostatically Sensitive (ES) Devices
Some semiconductor (solid-state) devices can be damaged easily
by static electricity. Such components commonly are called
Electrostatically Sensitive (ES) Devices. Examples of typical ES
devices are integrated circuits and some field-effect transistors and
semiconductor "chip" components. The following techniques
should be used to help reduce the incidence of component
damage caused by static by static electricity.
1. Immediately before handling any semiconductor component or
semiconductor-equipped assembly, drain off any electrostatic
charge on your body by touching a known earth ground.
Alternatively, obtain and wear a commercially available
discharging wrist strap device, which should be removed to
prevent potential shock reasons prior to applying power to the

unit under test.


2. After removing an electrical assembly equipped with ES
devices, place the assembly on a conductive surface such as
aluminum foil, to prevent electrostatic charge buildup or
exposure of the assembly.
3. Use only a grounded-tip soldering iron to solder or unsolder ES
devices.
4. Use only an anti-static type solder removal device. Some solder
removal devices not classified as "anti-static" can generate
electrical charges sufficient to damage ES devices.
5. Do not use freon-propelled chemicals. These can generate
electrical charges sufficient to damage ES devices.
6. Do not remove a replacement ES device from its protective
package until immediately before you are ready to install it.
(Most replacement ES devices are packaged with leads
electrically shorted together by conductive foam, aluminum foil
or comparable conductive material).
7. Immediately before removing the protective material from the
leads of a replacement ES device, touch the protective material
to the chassis or circuit assembly into which the device will be
installed.
CAUTION: Be sure no power is applied to the chassis or circuit,
and observe all other safety precautions.
8. Minimize bodily motions when handling unpackaged
replacement ES devices. (Otherwise harmless motion such as
the brushing together of your clothes fabric or the lifting of your
foot from a carpeted floor can generate static electricity
sufficient to damage an ES device.)
General Soldering Guidelines
1. Use a grounded-tip, low-wattage soldering iron and appropriate
tip size and shape that will maintain tip temperature within the
range or 500F to 600F.
2. Use an appropriate gauge of RMA resin-core solder composed
of 60 parts tin/40 parts lead.
3. Keep the soldering iron tip clean and well tinned.
4. Thoroughly clean the surfaces to be soldered. Use a mall wirebristle (0.5 inch, or 1.25cm) brush with a metal handle.
Do not use freon-propelled spray-on cleaners.
5. Use the following unsoldering technique
a. Allow the soldering iron tip to reach normal temperature.
(500F to 600F)
b. Heat the component lead until the solder melts.
c. Quickly draw the melted solder with an anti-static, suctiontype solder removal device or with solder braid.
CAUTION: Work quickly to avoid overheating the circuit
board printed foil.
6. Use the following soldering technique.
a. Allow the soldering iron tip to reach a normal temperature
(500F to 600F)
b. First, hold the soldering iron tip and solder the strand against
the component lead until the solder melts.
c. Quickly move the soldering iron tip to the junction of the
component lead and the printed circuit foil, and hold it there
only until the solder flows onto and around both the
component lead and the foil.
CAUTION: Work quickly to avoid overheating the circuit
board printed foil.
d. Closely inspect the solder area and remove any excess or
splashed solder with a small wire-bristle brush.

IC Remove/Replacement
Some chassis circuit boards have slotted holes (oblong) through
which the IC leads are inserted and then bent flat against the
circuit foil. When holes are the slotted type, the following technique
should be used to remove and replace the IC. When working with
boards using the familiar round hole, use the standard technique
as outlined in paragraphs 5 and 6 above.
Removal
1. Desolder and straighten each IC lead in one operation by gently
prying up on the lead with the soldering iron tip as the solder
melts.
2. Draw away the melted solder with an anti-static suction-type
solder removal device (or with solder braid) before removing the
IC.
Replacement
1. Carefully insert the replacement IC in the circuit board.
2. Carefully bend each IC lead against the circuit foil pad and
solder it.
3. Clean the soldered areas with a small wire-bristle brush.
(It is not necessary to reapply acrylic coating to the areas).
"Small-Signal" Discrete Transistor
Removal/Replacement
1. Remove the defective transistor by clipping its leads as close as
possible to the component body.
2. Bend into a "U" shape the end of each of three leads remaining
on the circuit board.
3. Bend into a "U" shape the replacement transistor leads.
4. Connect the replacement transistor leads to the corresponding
leads extending from the circuit board and crimp the "U" with
long nose pliers to insure metal to metal contact then solder
each connection.
Power Output, Transistor Device
Removal/Replacement
1. Heat and remove all solder from around the transistor leads.
2. Remove the heat sink mounting screw (if so equipped).
3. Carefully remove the transistor from the heat sink of the circuit
board.
4. Insert new transistor in the circuit board.
5. Solder each transistor lead, and clip off excess lead.
6. Replace heat sink.
Diode Removal/Replacement
1. Remove defective diode by clipping its leads as close as
possible to diode body.
2. Bend the two remaining leads perpendicular y to the circuit
board.
3. Observing diode polarity, wrap each lead of the new diode
around the corresponding lead on the circuit board.
4. Securely crimp each connection and solder it.
5. Inspect (on the circuit board copper side) the solder joints of
the two "original" leads. If they are not shiny, reheat them and if
necessary, apply additional solder.
Fuse and Conventional Resistor
Removal/Replacement
1. Clip each fuse or resistor lead at top of the circuit board hollow
stake.
2. Securely crimp the leads of replacement component around
notch at stake top.
3. Solder the connections.
CAUTION: Maintain original spacing between the replaced
component and adjacent components and the circuit board to
prevent excessive component temperatures.

Circuit Board Foil Repair


Excessive heat applied to the copper foil of any printed circuit
board will weaken the adhesive that bonds the foil to the circuit
board causing the foil to separate from or "lift-off" the board. The
following guidelines and procedures should be followed whenever
this condition is encountered.
At IC Connections
To repair a defective copper pattern at IC connections use the
following procedure to install a jumper wire on the copper pattern
side of the circuit board. (Use this technique only on IC
connections).
1. Carefully remove the damaged copper pattern with a sharp
knife. (Remove only as much copper as absolutely necessary).
2. carefully scratch away the solder resist and acrylic coating (if
used) from the end of the remaining copper pattern.
3. Bend a small "U" in one end of a small gauge jumper wire and
carefully crimp it around the IC pin. Solder the IC connection.
4. Route the jumper wire along the path of the out-away copper
pattern and let it overlap the previously scraped end of the good
copper pattern. Solder the overlapped area and clip off any
excess jumper wire.
At Other Connections
Use the following technique to repair the defective copper pattern
at connections other than IC Pins. This technique involves the
installation of a jumper wire on the component side of the circuit
board.
1. Remove the defective copper pattern with a sharp knife.
Remove at least 1/4 inch of copper, to ensure that a hazardous
condition will not exist if the jumper wire opens.
2. Trace along the copper pattern from both sides of the pattern
break and locate the nearest component that is directly
connected to the affected copper pattern.
3. Connect insulated 20-gauge jumper wire from the lead of the
nearest component on one side of the pattern break to the lead
of the nearest component on the other side.
Carefully crimp and solder the connections.
CAUTION: Be sure the insulated jumper wire is dressed so the
it does not touch components or sharp edges.

SPECIFICATION
NOTE : Specifications and others are subject to change without notice for improvement.

1. Application range

(4) Specification and performance of each parts are followed


each drawing and specification by part number in
accordance with BOM.
(5) The receiver must be operated for about 20 minutes prior
to the adjustment.

This spec sheet is applied to the LCD TV used LP7BB


chassis

2. Specification
Each part is tested as below without special appointment.

3. Test method
(1) Performance : LGE TV test method followed
(2) Demanded other specification
Safety
: CE, IEC Specification
EMC
: CE, IEC

(1) Temperature : 25 5C(77 9F), CST : 40 5C


(2) Relative Humidity : 65% 10%
(3) Power Voltage : Standard input voltage (100-240V~,
50/60Hz)
*Standard Voltage of each products is marked by models

4. General TV Specification
No

Item

Specification

1.

Video input applicable system

NTSC-M, PAL M/N

2.

Receivable Broadcasting System

1) NTSC

Remark

2) PAL M
3) PAL N
3.

RF Input Channel

BAND

NTSC

VHF

2 ~ 13

UHF

14 ~ 69

CATV

1 ~ 125

4.

Input Voltage

100-240V~ / 50Hz, 60Hz

5.

Market

Central & South America

6.

Operating Environment

1) Temp : 0 ~ 40 deg
2) Humidity : 10 ~ 90 %RH

7.

Storage Environment

1) Temp : -20 ~ 50 deg

8.

Power Consumption

Power on

260(42)

(Green)

220(32)

9.

Stand by

Cool

1W(32, 42)

Warm

40W(32, 42)

10.

Frequency range

H : 31 ~ 61 khz

11.

Video Input (2EA)

NTSC, PAL M/N

2) Humidity : 10 ~ 90 %RH

When recordign the manual recording


PC Input

V : 56 ~ 75 Hz
12.

S-Video Input (1EA)

NTSC, PAL M/N

13.

Component Input (2EA)

Y/Cb/Cr, Y/Pb/Pr

14.

RGB Input (1EA)

RGB-PC

15.

HDMI Input (2EA)

Side only

HDMI-PC
HDMI-DTV

16.

Audio Input (5EA)

17.

Audio variable out (1EA)

18.

USB Input (1EA)

19.

AV out (1EA)

PC Audio, Component (2EA), AV(2EA)


DivX, MP3, JPEG

L/R Input

5. General Module Specification


No
1.

Item

Specification

Panel

Remark

42" TFT WXGA LCD


32" TFT WXGA LCD

2.

LCD Module

Outline

42"

983 x 576 x 47.3

Dimension

32"

760.0 x 450.0 x 48.0

(H)mm x (V)mm x (D)mm

Pixel Pitch

42"

0.227 x 0.681 x RGB

32"

0.17025 x 0.51075 x RGB

mm

Pixel Format

1366 x 768 Pixels RGB strip arrangement

Coating

Hard coating(3H), Anti-glare treatment


of the front polarizer,

Back Light

42"

18CCFL

32"

18CCFL

6. Set Optical Feature (LCD Module)


No

Item

Min

Typ

1.

Luminance

400

500

2.

View angle (R/L, U/D)

3.

White

Max

Unit

Maker
LPL(0RT)
32",42"

White

coordinate

Green
Blue

5.

-0.03

Y
Red

4.

178/178

Contrast ratio
Luminance Variation

- Full White Pattern

LPL 32, 42

- CR > 10

0.279/0.279/0.279 +0.03
0.292/0.292/0.292

0.635/0.636/0.635

0.339/0.343/0.344

0.282/0.284/0.286

0.606/0.615/0.614

0.145/0.144/0.146

0.064/0.063/0.061

CR

degree

Remark
- 50cm from the surface

600

800

32"

LPL(0-RT)

800

1000

42"

LPL(0-RT)

1.3

7. Component Video Input (Y, PB, PR)


No
1.

Resolution

H-freq(kHz)

V-freq.(kHz)

Pixel clock(MHz)

Remarks

720*480

15.73

59.94

13.500

SDTV, DVD 480I(525I)

720*480

15.75

60.00

13.514

SDTV, DVD 480I(525I)

2.

720*576

15.625

50.00

13.500

SDTV, DVD 576I(625I)

3.

720*480

31.47

59.94

27.000

SDTV 480P

720*480

31.50

60.00

27.027

SDTV 480P

4.

720*576

31.25

50.00

27.000

SDTV 576P

5.

1280*720

44.96

59.94

74.176

HDTV 720P

1280*720

45.00

60.00

74.250

HDTV 720P

6.

1280*720

37.50

50.00

74.25

HDTV 720P 50Hz

7.

1920*1080

33.72

59.94

74.176

HDTV 1080I

1920*1080

33.75

60.00

74.250

HDTV 1080I

8.

1920*1080

28.125

50.00

74.250

HDTV 1080I 50Hz,

9.

1920*1080

67.5

60.00

148.5

HDTV 1080P

10.

1920*1080

56.25

50

148.5

HDTV 1080P 50Hz

H-freq(kHz)

V-freq.(kHz)

Pixel clock(MHz)

31.469

70.08

28.32

8. RGB Input ( PC )
No
1

Resolution
720*400

Remarks
DOS

2.

640*480

31.469

59.94

25.17

VESA(VGA)

640*480

37.500

75.00

31.50

VESA(VGA)

800*600

37.879

60.31

40.00

VESA(SVGA)

800*600

46.875

75.00

49.50

VESA(SVGA)

1024*768

48.363

60.00

65.00

VESA(XGA)

1024*768

56.476

70.06

78.75

VESA(XGA)

1024*768

60.023

75.02

79.50

VESA(XGA)

1280*768

47.776

59.87

80.125

WXGA(42XGA,50",60")

10

1360*768

47.712

60.01

85.50

WXGA(42XGA,50",60")

11

1366*768

47.700

60.00

84.62

WXGA(42XGA,50",60")

H-freq(kHz)

V-freq.(kHz)

Pixel clock(MHz)

31.469

70.08

28.32

9. HDMI Input ( PC )
No
1

Resolution
720*400

Remarks
DOS

640*480

31.469

59.94

25.17

VESA(VGA)

640*480

37.500

75.00

31.50

VESA(VGA)

800*600

37.879

60.31

40.00

VESA(SVGA)

800*600

46.875

75.00

49.50

VESA(SVGA)

1024*768

48.363

60.00

65.00

VESA(XGA)

1024*768

56.476

70.06

75.00

VESA(XGA)

1024*768

60.023

75.02

78.75

VESA(XGA)

1280*768

47.776

59.87

79.50

WXGA(42XGA,50",60")

10

1360*768

47.712

60.01

85.50

WXGA(42XGA,50",60")

11

1366*768

47.700

60.00

84.62

WXGA(42XGA,50",60")

10. HDMI input ( DTV )


No
1.

Resolution
720*480

H-freq(kHz)

V-freq.(kHz)

Pixel clock(MHz)

31.47

59.94

27.000

Remarks
SDTV 480P

2.

720*480

31.50

60.00

27.027

SDTV 480P

3.

720*576

31.25

50.00

27.000

SDTV 576P

4.

1280*720

44.96

59.94

74.176

HDTV 720P

5.

1280*720

45.00

60.00

74.250

HDTV 720P

6.

1280*720

37.50

50.00

74.25

HDTV 720P 50H

7.

1920*1080

33.72

59.94

74.176

HDTV 1080I

8.

1920*1080

33.75

60.00

74.250

HDTV 1080I

9.

1920*1080

28.125

50.00

74.250

HDTV 1080I 50Hz

10.

1920*1080

67.5

60.00

148.5

HDTV 1080P

11.

1920*1080

56.25

50

148.5

HDTV 1080P 50Hz

ADJUSTMENT INSTRUCTION
1. Application Range
This spec. sheet is applied to all of the LP7BB chassis
(Saturn Analog DVR) manufactured at LG TV Plant all over
the world.

2. Specification
2.1 Because this is not a hot chassis, it is not necessary to
use an isolation transformer.
However, the use of isolation transformer will help to
protect test instruments.
2.2 Adjustment must be done in the correct sequence.
2.3 The adjustment must be performed at 255C
temperature and 6510% relative humidity if there is no
specified designation.
2.4 The input voltage of the receiver must be kept between
100-220V, 50/60Hz.
2.5 Before adjustment, execute Heat-Run for 30 minutes at
Full White mode.(Power on key)

3. PCB assembly adjustment items

5. HDD Assembly Adjustment method


5.1. HDD FORMAT
1) Assemble MAIN , DVR Board.
2) HDD Format in progress words will create automatically.
3) Please, wait for 30~40 seconds.
5.1.1. HDD Format in progress

5.1.2. HDD Format completed

* Channel memory
- Download the channel data from BOM to EEPROM by
using LGIDS.
* Option adjustment following BOM
- Tool Option1
- Tool Option2
- Area Option
LP7BA LPL
S/W Version
DVR Version
UTT
Tool Option1
Tool Option2
Area Option

42 Normal
X.XX
X.XX
XX hr
7
161
16
:

(Fig.1)
1) Push the ADJ key in the Adjust Remocon.
2) Input the Option Number that was specified in the BOM,
into the Shipping area.
3) Select "Tool Option1/ Tool Option2/ Area Option" by using
(CH+/-) key , and press the number key(0~9)
consecutively
ex) If the value of Tool Option1 is 7, input the data using
number key "7" (Fig. 1)

4. SET assembly adjustment items


Auto AV Color Balance
Adjustment of White Balance
Auto Component Color Balance adjustment
- Standard equipment : MSPG925FA
Auto RGB Color Balance adjustment
- Standard equipment : MSPG925FA
(At DVR model Case, Please check DVR function like
following list )
Checking DVR Function and HDD
Check DVR Function as follow on 4.2 and find HDD failure
under malfunction.

5.2. Sub Program Download for "DVR" by using USB


memory stick
1) connect USB memory stick to SET
2) Set power off -> ON
- DVR s/w will be installed automatically

6. EDID

7. ADC Calibration

Caution
* Use the proper signal cable for EDID Download
- Analog EDID : Pin3 exists
- Digital EDID : Pin3 exists

ADC
MSPG925FA

=> Caution : - Never connect HDMI & DVI-D & DVI-A Cable
at the same time.
- Use the proper cables below for EDID Writing
6.1. Data
6.1.1 ANALOG(256 Bytes )
BLOCK1 (128BYTE)

RF/AV/S-VIDEO
PAL

NTSC

INPUT AV3-ZF

VIDEO1 -MA

SELECT AV1-TB
Model: 202

Model:201

(PAL-BGDHI)

(NTSC)

Pattern: 65

Pattern: 65

Component

RGB

Model:217 720P

Model: 60

Pattern:65

1024*768 60Hz

* 100% Color Bar

Pattern: 65
* 100% Color Bar

* 100% Color Bar * 100% Color Bar

=> Caution : - System control RS-232 Host should be "PC"


for adjustment.
Press the FRONT-AV KEY on R/C for converting input
mode.
(change RS-232 Host : pc, Band Rate : 115200bps)
7.1 Adjustment of RF/AV/S-VIDEO
* Required Equipments
- Remote controller for adjustment
- 802F Pattern Generator, Master (MSPG-925FA), etc.
- MSPG-925FA Pattern Generator
(Which has Video Signal: 100% Color Bar Pattern
shown in Fig. 2)
=> Model: 202 / Pattern : 65

6.1.2 HDMI(256 Bytes )


BLOCK1 (128BYTE)

BLOCK2 (128BYTE)
(Fig. 2)
7.1.1 Method of Auto RF/AV/S-VIDEO Color Balance.
1) Press the FRONT-AV KEY on R/C for converting input
mode.
2) Input the Video Signal: 100% Color Bar signal into AV
3) Set the PSM to Dynamic mode in the Picture menu.
4) Press INSTART key on R/C for adjustment.
5) Press the (Vol. +) key to operate the set, then it
becomes automatically
6) Auto-RGB OK means the adjustment is completed
7.1.2 Requirement
- This AV color balance adjustment should be performed
before White Balance Adjustment.
- After AV color balance adjustment, Change the mode
from AV to RF.
(Cancel Heat-run mode.)

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

- 11 -

LGE Internal Use Only

ADJUSTMENT INSTRUCTION
1. Application Range
This spec. sheet is applied to all of the LP7BB chassis
(Saturn Analog DVR) manufactured at LG TV Plant all over
the world.

2. Specification
2.1 Because this is not a hot chassis, it is not necessary to
use an isolation transformer.
However, the use of isolation transformer will help to
protect test instruments.
2.2 Adjustment must be done in the correct sequence.
2.3 The adjustment must be performed at 255C
temperature and 6510% relative humidity if there is no
specified designation.
2.4 The input voltage of the receiver must be kept between
100-220V, 50/60Hz.
2.5 Before adjustment, execute Heat-Run for 30 minutes at
Full White mode.(Power on key)

3. PCB assembly adjustment items

5. HDD Assembly Adjustment method


5.1. HDD FORMAT
1) Assemble MAIN , DVR Board.
2) HDD Format in progress words will create automatically.
3) Please, wait for 30~40 seconds.
5.1.1. HDD Format in progress

5.1.2. HDD Format completed

* Channel memory
- Download the channel data from BOM to EEPROM by
using LGIDS.
* Option adjustment following BOM
- Tool Option1
- Tool Option2
- Area Option
LP7BA LPL
S/W Version
DVR Version
UTT
Tool Option1
Tool Option2
Area Option

42 Normal
X.XX
X.XX
XX hr
7
161
16
:

(Fig.1)
1) Push the ADJ key in the Adjust Remocon.
2) Input the Option Number that was specified in the BOM,
into the Shipping area.
3) Select "Tool Option1/ Tool Option2/ Area Option" by using
(CH+/-) key , and press the number key(0~9)
consecutively
ex) If the value of Tool Option1 is 7, input the data using
number key "7" (Fig. 1)

4. SET assembly adjustment items


Auto AV Color Balance
Adjustment of White Balance
Auto Component Color Balance adjustment
- Standard equipment : MSPG925FA
Auto RGB Color Balance adjustment
- Standard equipment : MSPG925FA
(At DVR model Case, Please check DVR function like
following list )
Checking DVR Function and HDD
Check DVR Function as follow on 4.2 and find HDD failure
under malfunction.

5.2. Sub Program Download for "DVR" by using USB


memory stick
1) connect USB memory stick to SET
2) Set power off -> ON
- DVR s/w will be installed automatically

8. White Balance
* Caution : Before White-balance, the AV ADC should be done.
=> Notice
- Do the white balance adjustment under the 10LUX
- Before white balance, press the In-start key 2times and do
the reset like Fig.5
- Use the Torino inner pattern(216 gray pattern)
- To enter White-balance mode,press the IN-START key
2times.
* Caution : - System control RS-232 Host should be "PC" for
adjustment.
White Balance(Hex)
Color Temp.
Red Gain.
Green Gain.
Blue Gain.
Red Offset
Green Offset
Blue Offset
Reset

Cool
80
80
80
80
80
80
_ To set

(Fig. 4)
* Test Equipment
LCD : Color Analyzer ( CA-110), PDP : Color Analyzer (CA100)
CA-210 : The both of LCD and PDP are available.
PC (for communication through RS-232C) -> UART Baud
rate : 115200
Pattern Generator (MSPG-925FA etc. )
* Color Temperature & Color Coordinates Setting
When adjusting the Color Temperature of LCD, Color
AnalyzerCA-210(Matrix should be corrected through CH9 of
CS-1000) should be used.
When adjusting the Color Temperature of PDP, Color
AnalyzerCA-210(Matrix should be corrected through CH10
of CS-1000) should be used.
Adjust the Color Temperature based below adjustment color
coordinates.
Even if CH9 of CA-210 is corrected with Matrix, there may
be many character of Module and Filter.
Therefore Refer to the below Color Coordinates Target.
But, in case of WCG module, use the CH12 of CA-210.

NO

NO

NO

After re mo ve all cab les con nec ted to


PSU (except the C N101) , author izes the AC
vo ltage marking on manual.
W hen ST -b y 5V doesnt operate , replace PSU

YE S

Is it connected tha t
PSU and 13 pin cable
in VSC board ?

YE S

Is normal the fuse of


PSU? Plasma (F101),
LCD(F111 )

YE S

Is connected the Line


Filter and PSU?

YE S

Is inserted a pl ug
in power cord?

Start check

NO

discharg e doesnt occur at module.

2) Front LED does nt come into ac tion.

1) Minute

Symptom

1. No power

Connect the 13pin cable.

Replace the fuse

Connect a cable.
Plasma (EL1 1), LC D(SC100 )

Plug in a power cord

TROUBLESHOOTING

it doesnt discharge minutely from module.

Is t he X- Board
no rmal ?

YE S

Is the Z - Board
no rmal ?

YE S

Is t he Y- Board
no rmal ?

YE S

Is the each
connector norma l?

YE S

Is the PSU
no rmal?

Start check

NO

NO

NO

NO

NO

Is normal the output vo ltage


after re move P100,110,200, 210
connector of X- B/D?

YE S

Is no rmal the fuse


(FS1 ,FS2 ) on Z-B/D?

YE S

Is no rmal the fuse


(FS2 ,FS3 ) on Y-B/D?

After connecting we ll each


connector the normality it operates?

Is output the no rmality Lo w/High


Voltage except Stand-by 5V?

3) It is converted w ith the c o lor where the front LED is red fro m gr een .

2) The relay fall s. ( The sound is audible "Click ")

1) After once shining,

Symptom

2. Protection mode

Is no rmal the output voltage after


remove P1 connector of Y-B/D?

Is no rmal the output vo ltage after


remove P1 connector of Z-B/D?

Replace Z -B/D

Replace Y-B/D

After remove P100,110 output voltage normality:


Re place Ri ght X-B/ D
Afte r re mo ve P200,210 output voltage normality:
Replace Left X- B/D

Replace the fuse

NO

Replace the fuse

NO

Replace the power board

Replace the power board

Is the IC700s
output normal?

YE S

Is the link cable


normal?

YE S

Does minute
discharge at
Module?

Start check

2) It maintains the condition where

NO

NO

NO

Replace the VSC

Reconnect the link cable


in P600

Check the PDP/LCD Module

YE S

Is the
inverter/ VaV s
on?

the front LED is green

1) No OSD and image occur at screen.

Sy mptom

3. No Raster

NO

Is output the normality Lo w/High


Voltage except Stand-by 5V?

Replace
the power board

NO

Change the IC(IC700)

YE S

Is the LVDS Cable


connected well?

YE S

NO

Is normal video
NO
output of CXA2069Q?
(Check R324, In case of S-Video
check R324, R328)

YE S

Is normal video output


of the Tuner?
(Check TU200_Pin14)

Cable inserts well

Check the power


( Check L1004)

NO

Is normal the Input voltage ?


(Check L308)

Cable inserts well.

NO

Is the Tuner Cable


connected well?

YE S

YE S

4. In case of becomes unusual display from RF mode(Main)

Change the IC(IC300)

NO

Is normal the
I2C communication ?
(Check R309, R310)

Check the power

NO

Is normal the Input voltage ?


(Check Pin8, Pin6)

YES

Change the Tuner

NO

Is normal the I2C communication ?


(Check Pin5, Pin4)

NO
Check the input source

NO
Check the input source

Same as Block A

YES

Is normal video input


of the A/V jack?

NO
Check the input source

7. In the case of becomes unusual display from side AV mode(main)

Same as Block A

YES

Is normal video input


of the A/V jack?

6. In the case of becomes unusual display from rear S-Video mode(main)

Same as Block A

YES

Is normal video input


of the A/V jack?

5. In the case of becomes unusual display from rear AV mode(main)

Same as Block A

YES

Is normal video input


of the A/V jack?
(Check R339, R341, L310)

NO
Check the input source

8. In the case of becomes unusual display from side S-Video mode(main)

NO

NO
Cable inserts well

Check the power


( Check L1004)

NO

Is normal the Input voltage ?


(Check L308)

Cable inserts well.

NO

Is the Tuner Cable


connected well?

YES

YES

Same as the case of main exc ept block A should be change to B

14. In case PIP doesnt display from other modes(Sub)

Change the IC(IC700)

YES

Is the LVDS Cable


connected well?

YES

Is normal video
output of CXA2069Q?
YES
(Check R312, In case of S-Video
check R312, R314)

YES

Is normal video output


of the Tuner?
(Check TU201_Pin14)

13. In case of becomes unusual display from RF mode(Sub)

Change the IC(IC300)

NO

Is normal the
I2C communication ?
(Check R309, R310)

Check the power


( L1103)

NO

Is normal the Input voltage ?


(Check Pin8, Pin6)

Change the Tuner

NO

(Check Pin5, Pin4)

YES Is normal the I2C communication ?

NO
Check the input source

NO
Check the input source

Change IC(IC700)

YES

Is normal R, G, B input
and H,V sync of the JK500?
(Check R509, R511, R512
R513, R515)

NO
Check the input source

17. In case of becomes unusual display from RGB mode(main/sub)

Change IC(IC700)

YES

Is normal video
input of the JK103?
(Check L129, L130, L131)

16. In case of becomes unusual display from component 2 mode(main/sub)

Change IC(IC700)

YES

Is normal video
input of the JK102?
(Check L126, L127, L128)

15. In case of becomes unusual display from component1 mode(main/sub)

Only RF is
no Sound?

YES

Only AV input is
no Sound?

YES

Only HDMI is
no Sound?

YES

All input (mode)


is no sound?

Ch eck f ollow

NO

NO

NO

Check the Tuner In/Out

Check the signal


after IC300
refer to circuit diagram

YES

Is the output
of IC300(pin52,53)
normal?

Download the EDID data

Sc reen i s ex istent, but sound isnt

LED is Green

Symptom

18. No Sound

NO

NO

Replace IC300

Replace VSC B/D

YES

IC402 operate
normally?

YES

IC401 operate
normally?

YES

IC400 operate
normally?

YES

Is the speaker
cable normal?

YES

Is the speaker
on in menu?

NO

NO

NO

NO

NO

Replace IC402

Replace IC401

Replace IC400

Check the
Speaker cable

Set on speaker
in menu

No

Is normal on ly audio?

No

Is normal on ly video ?

Yes

Yes

No

Reset TMDS power down /on register .


- 0x60, of fse t 0x 3f : 0xf 7 => 0xff

2. Check HDCP reg iste r. (0 x60, offset 0x32 )


- Enabl e bit 6: HDCP key loaded
- Enable bit 5: HDCP decryption active
- Enable bit 4: HDCP authen. attempted

1. Check H DMI rece ivers status register. ( 0x60, offset 0x06)


- If the value is 0xf or 0x 8, it is normal.

Yes

Is wave continuous?

Check TMDS line wave.


(R1215 ~ R1222/ R1226 ~ R1233)

19. HDMI mode

Normal video ,
Normal aud io?

No

Replace IC1200

Check HDMI source . Change another so urce or cab le.

1. Check TV input mode.


(HDMI1 port support HDMI and DVI.
So if you inpu t D VI signal and PC audio from phone jac k,
You can hear PC audio. )
2. Unplug and plug HDMI ca ble.
(sometimes ESD surge occurred at HDMI port.)
3. Check HDMI Mute re gister. (0x 68, offset 0x 37)
4. Check Audio- ou t channe l mute reg ister (0x68 , offse t 0x32)
is appropriately enabled .

Down load EDID data each port.

Start check

Is operated
IC1500, IC1501
normally?

YE S

Is operated
IC 1300,IC1302
normally?

YE S

Is connected cable?
(P1300, P1302 )

YE S

Is Timeshift Mode "On"


in Menu?

Ch eck f ollow

YE S

Cant record AV/RF/Component

Cant enter to recorded list

Doesnt work timeshift m ode.

L ED is Green

Sympto m

20.1 DVR

NO

NO

NO

NO

Change HDD

Replace the IC1500, IC1501

Replace the IC1300, IC1302

Connect a cable.
P1300, P1302

Change Timeshift Mode


from off to "On"

BLOCK DIAGRAM

120

121

300

120

802

200

809

805

803

806

807

801 520 808

LV1

610

510

600

500

804

800

540

530

900

910

400

EXPLODED VIEW

EXPLODED VIEW PARTS LIST


No.
120

PART NO.
EAB37526301

DESCRIPTION
Speaker,Full Range, C103A02K1400 ND 7W 8OHM 81DB 160HZ 122

121

EAB39506401

Speaker Assembly, 42LB9RT-MD.KWZZLJZ LGEAZ ASSEMBLE PHANTOM TWEETER

200

EAJ38817501

LCD,Module-TFT, LC420WX8-SLA1 WXGA 42INCH 1366X768 500CD COLOR 72% 16/9 1000:1(basic) 5ms(GTG) Zero RT Pol. 10000K Vitiaz 2 LG PHILIPS LCD

300

ABJ32993205

Cabinet Assembly, 42LB9RT-MD LP7BA 42" H4_ANALOG_DVR CABINET ASSEMBLY_FULL_CKD

400

ACQ33924404

Cover Assembly,Rear, 42LB9RT-MD lP7BA 42" 42"_H4_ANALOG_DVR_BACK COVER ASSEMBLY_FULL_CKD

500

EBR39358301

PCB Assembly, SUB T.T LP7BB 42LB9RT-MD KWZZLJZ PREAMP CKD BOM FOR LGEAZ

510

EBR39358901

PCB Assembly, CONTROL T.T LP7BB 42LB9RT-MD KWZZLJZ LOCAL KEY CKD BOM FOR LGEAZ

520

EAM35501401

Filter,AC Line, IF3-N06CEWL1 5.3mH 250VAC 6A 0.22uF 1000pF UL/CSA/VDE/K HOUSING/RING BK DONG IL TECHNOLOGY LTD.

530

EBR39358101

PCB Assembly, SUB T.T LP7BB 42LB9RT-MD KWZZLJZ SIDE A/V TOTAL CKD ASSY FOR LGEAZ

540

EBT39358001

Chassis Assembly, SUB LP7BA 42LB9RT-MD CKD HDD ASSY For LGEAZ

600

EBR38805302

PCB Assembly,Power, POWER T.T LP78A 42LC4R-MD KWZYLJZ Vitiaz2 PPB POWER CKD_NS 42LC4R-MD

610

EBU39334801

Main Total Assembly, 42LB9RT-MD BRAND LP7BB CKD BOM for LGEAZ

800

MJH37063702

Supporter, PRESS EGI 1t Supporter EGI LGEAZ_FULL_CKD_METAL TOP BAR

801

MGJ32902414

Plate, PRESS EGI 1.6 FRAME SBHG-A 42LB9_METAL BAR BOTTOM FULL_CKD FOR LPL MODULE (FULL_CKD OF P/NO 13)

802

MJH34248206

Supporter, PRESS EGI 1.2 GUIDE EGI METAL BAR LEFT FOR TORNADO MODULE, FULL CKD , WITHOUT PEMNUT LGEAZ

803

MGJ32902715

Plate, PRESS EGI 1.2 FRAME SBHG-A 42LB9RT-MD_LGEAZ_FULL_CKD_ METAL BAR CENTER 13-FULL_CKD

804

MGJ32902507

Plate, PRESS, EGI 1.2 FRAME SBHG-A 42LY3 METAL BAR RIGHT for AZ CKD W/O PAM_NUT

805

MGJ32902812

Plate, PRESS, EGI 1.2 FRAME SBHG-A 42LB9RT-MD_LGEAZ METAL BAR SIDE TOP(FULL_CKD OF P/N 01)

806

MGJ32902910

Plate, PRESS, EGI 1.2 FRAME SBHG-A 42LB9RT-MD LGEAZ METAL BAR SIDE BOTTOM FULL_CKD OF P/NO "01"

807

MGJ38974302

Plate,Metal, PRESS SBHG 1.2T SUPPORTER EGI 42LB9 SUB TOP PIECE PRESS

808

MJH34000506

Supporter, PRESS EGI 1.6 GUIDE EGI 42LB9RT-MD METAL STAND SUPPORTER FULL_CKD OF P/NO "03"

809

MGJ38733402

Plate,Metal, PRESS EGI 1.0 SUPPORTER SECC 47LB9 STAND GUIDE PRESS

900

AAN32993604

Base Assembly, STAND 42LB9RT-MD LP7BA STAND BASE ASSY FOR NOBLE BLACK DECO RING FULLCKD_PHNATOM

910

ABA32985002

Bracket Assembly, STAND 32LB9D-UA LA73A 32LB9 CABLE MANEGEMENT CKD

REPLACEMENT PARTS LIST


DATE: 2007. 08. 20.
LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

ACCESSORY
C1226

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

A1

MFL36546203

"Manual,Owners" PRINTING USER LP7BA LG

C1244

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

A2

MKJ39170811

Remote Controller COMPLEX PP7BA 50PB4RTH

C1307

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

A3

6410TMW004A

Power Cord "UC,LP-45 & H05VV-F 0.7"

C1308

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

A4

341-746B

Holder MOLD ABS CABLE Holder

C1315

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

A5

MES36332302

Indicator MOLD ABS LED&PRE AMP 3

C1366

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C200

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C207

0CE227WF6DC

"Capacitor,AL,Chip" MVK8.0TP16VC220M 220uF

C210

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

C211

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C212

0CE475SK6DC

"Capacitor,AL,Chip" VMV475M050S0ANB010 4.7

C214

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C220

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C222

0CE227WF6DC

"Capacitor,AL,Chip" MVK8.0TP16VC220M 220uF

C2304

0CE106SF6DC

"Capacitor,AL,Chip" VMV106M016S0ANB010 10u

C2306

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C2309

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C301

0CE107SF6DC

"Capacitor,AL,Chip" VMV107M016S0ANE010 100

C301

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C308

0CE107SF6DC

"Capacitor,AL,Chip" VMV107M016S0ANE010 100

C308

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C310

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C311

0CE476SF6DC

"Capacitor,AL,Chip" VMV476M016S0ANC010 47u

C400

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C403

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C405

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C412

0CE335WK6D8

"Capacitor,AL,Chip" MVK4.0TP50VC3.3M 3.3uF

C415

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

CAPACITORs
C1001

0CE477WF6DC

"Capacitor,AL,Chip" MVK10TP16VC470M 470uF

C1007

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1009

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1014

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1017

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C102

0CE107SF6DC

"Capacitor,AL,Chip" VMV107M016S0ANE010 100

C1020

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1021

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1024

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1026

0CE477WF6DC

"Capacitor,AL,Chip" MVK10TP16VC470M 470uF

C1029

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C104

0CE107SF6DC

"Capacitor,AL,Chip" VMV107M016S0ANE010 100

C1101

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1107

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1108

0CE477WF6DC

"Capacitor,AL,Chip" MVK10TP16VC470M 470uF

C1109

0CE337WJ6D8

"Capacitor,AL,Chip" MVK12.5TP35VC330M 330u

C1111

0CE227WF6DC

"Capacitor,AL,Chip" MVK8.0TP16VC220M 220uF

C1115

0CE477WF6DC

"Capacitor,AL,Chip" MVK10TP16VC470M 470uF

C1117

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1119

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1121

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1122

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1126

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1128

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1132

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1133

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1148

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C1150

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C1153

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C1162

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C117

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C1171

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C118

0CE227SF6DC

"Capacitor,AL,Chip" MVG6.3TP16VC220M 220uF

C1182

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1184

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C1187

0CE227WF6DC

"Capacitor,AL,Chip" MVK8.0TP16VC220M 220uF

C1201

0CE476SF6DC

"Capacitor,AL,Chip" VMV476M016S0ANC010 47u

C1207

0CE476SF6DC

"Capacitor,AL,Chip" VMV476M016S0ANC010 47u

C121

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

C122

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

C1222

0CE106SH6DC

"Capacitor,AL,Chip" VMV106M025S0ANB010 10u

C431

0CE335WK6D8

"Capacitor,AL,Chip" MVK4.0TP50VC3.3M 3.3uF

C432

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C433

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C438

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C439

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C440

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C441

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C446

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C447

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C455

0CE335WK6D8

"Capacitor,AL,Chip" MVK4.0TP50VC3.3M 3.3uF

C458

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C470

0CE335WK6D8

"Capacitor,AL,Chip" MVK4.0TP50VC3.3M 3.3uF

C471

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C472

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C475

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C476

0CE475WJ6DC

"Capacitor,AL,Chip" MVK4.0TP35VC4.7M 4.7uF

C477

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C479

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C486

0CE106WFKDC

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C489

0CE337WJ6D8

"Capacitor,AL,Chip" MVK12.5TP35VC330M 330u

C513

0CE476SF6DC

"Capacitor,AL,Chip" VMV476M016S0ANC010 47u

C515

0CE107SF6DC

"Capacitor,AL,Chip" VMV107M016S0ANE010 100

- 28 -

LOC. NO.

PART NO.

C537

0CE106WFKDC

C540

0CE476WF6DC

C609

0CE226WF6DC

C612
C614

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C1010

0CK104CK56A

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1013

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1016

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

0CE107WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC100M 100uF

C1018

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

0CH8106F691

"Capacitor,AL,Chip" MVK4.0TP16VC10M 10uF 2

C1019

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C724

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1022

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C725

0CE476WF6DC

"Capacitor,AL,Chip" MVK6.3TP16VC47M 47uF 2

C1023

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C732

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1025

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C733

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1027

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C734

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1028

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C735

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C103

0CC330CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H330JT 33pF 5

C736

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1030

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C737

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C105

0CH5101K416

"Capacitor,Ceramic,Chip" C2012C0G1H101JT 100pF

C738

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C105

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C739

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C106

0CH5101K416

"Capacitor,Ceramic,Chip" C2012C0G1H101JT 100pF

C740

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C106

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C741

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C108

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C757

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C109

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C758

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C110

0CH5331K416

"Capacitor,Ceramic,Chip" 0805N331J500LT 330pF 5

C759

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1100

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C788

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1102

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C900

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1103

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C903

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1104

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C904

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1105

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C905

0CE226WF6DC

"Capacitor,AL,Chip" MVK5.0TP16VC22M 22uF 2

C1106

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C107

0CE337DD618

"Capacitor,AL,Radial" SMS5.0TP10VB330M 330uF

C111

0CK225DH94A

"Capacitor,Ceramic,Chip" C2012Y5V225ZFT 2.2uF -

C113

EAE38262201

"Capacitor,AL,Radial" KMG5.0TP50VB22M 22uF 2

C1110

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C202

0CZZTAB003X

"Capacitor,AL,Radial" WB1A228M12020PL28P 220

C1112

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C206

0CZZTAB003X

"Capacitor,AL,Radial" WB1A228M12020PL28P 220

C1113

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C208

EAE38259501

"Capacitor,AL,Radial" KMG4.0MC10VB2200M 2200

C1114

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C210

0CZZTAB003V

"Capacitor,AL,Radial" WB1V158M16025PA28P 150

C1116

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C215

EAE38262601

"Capacitor,AL,Radial" KMG5.0TP10VB470M 470uF

C1118

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C217

0CZZTAB003X

"Capacitor,AL,Radial" WB1A228M12020PL28P 220

C112

0CK222DK56A

"Capacitor,Ceramic,Chip" CS2012X7R222K500NR 2.2

C218

EAE38259501

"Capacitor,AL,Radial" KMG4.0MC10VB2200M 2200

C1120

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C221

0CZZTAB003X

"Capacitor,AL,Radial" WB1A228M12020PL28P 220

C1125

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C222

EAE38261701

"Capacitor,AL,Radial" KMG5.0TP25VB470M 470uF

C1127

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C226

EAE38259801

"Capacitor,AL,Radial" KMG5.0MC35VB470M 470uF

C1129

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C307

EAE38262501

"Capacitor,AL,Radial" KMG5.0TP50VB47M 47uF 2

C1130

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C325

EAE38261801

"Capacitor,AL,Radial" KMG5.0TP50VB1M 1uF 20%

C1131

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C506

EAE38261901

"Capacitor,AL,Radial" KMG5.0TP50VB10M 10uF 2

C1134

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C507

EAE38262501

"Capacitor,AL,Radial" KMG5.0TP50VB47M 47uF 2

C1135

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C508

EAE38262101

"Capacitor,AL,Radial" KMG5.0TP50VB100M 100uF

C1144

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C510

EAE38262401

"Capacitor,AL,Radial" KMG5.0TP25VB47M 47uF 2

C1145

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C511

EAE38261801

"Capacitor,AL,Radial" KMG5.0TP50VB1M 1uF 20%

C1147

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C607

EAE36688101

"Capacitor,AL,Radial" LP2W157M35030HB 150uF

C1149

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C608

EAE36688101

"Capacitor,AL,Radial" LP2W157M35030HB 150uF

C1152

0CK105CD56A

"Capacitor,Ceramic,Chip" C1608X7R1A105KT 1uF 10

C702

EAE36687701

"Capacitor,AL,Radial" RB1H227M10025PA200 220

C116

0CH5221K416

"Capacitor,Ceramic,Chip" 0805N221J500LT 220pF 5

C1000

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1161

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1002

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1170

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1003

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1172

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1004

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1174

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1005

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C1176

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1006

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1178

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1008

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C118

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C101

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1180

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

- 29 -

LOC. NO.

PART NO.

C1181

0CK103CK56A

C1183

0CK103CK56A

C1185

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1319

0CK103BH56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C132

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1320

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C1186

0CK272CK46A

"Capacitor,Ceramic,Chip" 0603B272J500CT 2.7nF 1

C1321

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C1188

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1322

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1189

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1323

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C119

0CK224DK56A

"Capacitor,Ceramic,Chip" CS2012X7R224K500NR 220

C1324

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1190

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1325

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1200

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1326

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1205

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1327

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1212

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1328

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1213

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1329

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1214

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C133

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1215

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1330

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1216

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1331

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1217

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1332

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1218

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1333

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1219

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1334

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1220

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1335

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1221

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1336

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1223

0CC180BKFAA

"Capacitor,Ceramic,Chip" C1005C0G1H180JT 18pF 5

C1337

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C1224

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C1338

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1225

0CC180BKFAA

"Capacitor,Ceramic,Chip" C1005C0G1H180JT 18pF 5

C1339

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1227

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1340

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1228

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C1341

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1229

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1342

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1230

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1343

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1231

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1344

0CH5220K618

"Capacitor,Ceramic,Chip" 0402N220M500LT 22pF 5%

C1235

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1345

0CH5220K618

"Capacitor,Ceramic,Chip" 0402N220M500LT 22pF 5%

C1236

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1346

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C1237

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1346

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1238

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1347

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1239

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1348

0CC120CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H120JT 12pF 5

C1240

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1349

0CC120CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H120JT 12pF 5

C1241

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1350

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C1242

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1351

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1243

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1352

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1245

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1353

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1246

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1354

0CH5220K618

"Capacitor,Ceramic,Chip" 0402N220M500LT 22pF 5%

C1247

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1355

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1248

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1356

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1253

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1357

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1300

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1358

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1301

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C1359

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1302

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C136

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1303

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C1360

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1309

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C1361

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C131

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1362

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1310

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C1363

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1311

EAE32166101

"Capacitor,Ceramic,Chip" CS1005XR473K250CR 0.04

C1364

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1313

0CH5470K618

"Capacitor,Ceramic,Chip" 0402N470M500LT 47pF 5%

C1365

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1314

0CH5470K618

"Capacitor,Ceramic,Chip" 0402N470M500LT 47pF 5%

C1367

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1316

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1368

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1317

0CC100BKF1A

"Capacitor,Ceramic,Chip" 0402N100J500LT 10pF 5%

C1369

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1318

0CC100BKF1A

"Capacitor,Ceramic,Chip" 0402N100J500LT 10pF 5%

C137

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

- 30 -

DESCRIPTION / SPECIFICATION
"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

C1370

0CK104CK56A

C1371

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1421

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C143

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1372

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C144

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1373

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1500

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1374

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1501

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1375

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1502

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1376

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1503

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1377

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1504

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1378

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1505

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1379

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1506

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C138

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1507

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1380

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1508

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1381

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1509

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1382

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1510

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1383

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1511

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1384

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1512

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1385

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1513

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1386

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1514

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1387

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C1515

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1388

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1516

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1389

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1517

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C139

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1518

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1390

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1519

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1391

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1520

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1392

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1521

0CK822CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H822KT 8.2nF

C1393

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1522

0CK823CF56A

"Capacitor,Ceramic,Chip" 0603B823K160CT 82nF 10

C1394

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1523

0CK106CC67A

"Capacitor,Ceramic,Chip" C1608X5R0J106MT 10uF 2

C1395

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1524

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C1396

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1525

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C1397

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1526

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1398

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1527

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C140

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C1528

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1400

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1529

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C1401

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C1530

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C1402

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1531

0CK473CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H473KT 47nF 1

C1403

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1532

0CC180CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H180JT 18pF 5

C1404

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C1533

0CC180CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H180JT 18pF 5

C1405

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C201

0CC270CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H270JT 27pF 5

C1406

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C202

0CC271CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H271JT 270pF

C1407

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C203

0CC270CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H270JT 27pF 5

C1408

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C203

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1409

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C204

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C141

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C204

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1410

0CK474EK66A

"Capacitor,Ceramic,Chip" C3216X7R1H474MT 470nF

C205

0CC101CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H101JT 100pF

C1411

0CK474EK66A

"Capacitor,Ceramic,Chip" C3216X7R1H474MT 470nF

C206

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1412

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C208

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1413

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C209

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C1414

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C211

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1415

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C212

0CK224DK56A

"Capacitor,Ceramic,Chip" CS2012X7R224K500NR 220

C1416

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C213

0CH1223K566

"Capacitor,Ceramic,Chip" 0805B223K500CT 22nF 10

C1417

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C213

0CK273CK56A

"Capacitor,Ceramic,Chip" 0603B273K500CT 27nF 10

C1418

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C214

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1419

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C215

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C142

EAE32755801

"Capacitor,Ceramic,Chip" CL31A106K5HNNNE 10uF 1

C216

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C1420

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C216

0CK273CK56A

"Capacitor,Ceramic,Chip" 0603B273K500CT 27nF 10

- 31 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

C217

0CK104CK56A

C218

0CK103CK56A

C219
C219

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C321

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C322

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

0CC271CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H271JT 270pF

C322

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

0CH4471K416

"Capacitor,Ceramic,Chip" C2012C0G1H471JT 470pF

C323

0CK225DD56A

"Capacitor,Ceramic,Chip" C2012X7R1A225KT 2.2uF

C220

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C323

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C221

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C324

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C223

0CK222DK56A

"Capacitor,Ceramic,Chip" CS2012X7R222K500NR 2.2

C326

EAE36711901

"Capacitor,Ceramic,Chip" CS2012X7R103K500NR 100

C224

0CH1223K566

"Capacitor,Ceramic,Chip" 0805B223K500CT 22nF 10

C327

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C224

0CK273CK56A

"Capacitor,Ceramic,Chip" 0603B273K500CT 27nF 10

C327

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C225

0CC101CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H101JT 100pF

C328

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C225

0CH1223K566

"Capacitor,Ceramic,Chip" 0805B223K500CT 22nF 10

C329

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C226

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C329

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C227

0CH1102K566

"Capacitor,Ceramic,Chip" 0805B102K500CT 1nF 10%

C330

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C228

0CC270CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H270JT 27pF 5

C330

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C228

0CH1102K566

"Capacitor,Ceramic,Chip" 0805B102K500CT 1nF 10%

C331

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C229

0CC270CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H270JT 27pF 5

C332

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C229

0CH5221K416

"Capacitor,Ceramic,Chip" 0805N221J500LT 220pF 5

C401

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C230

0CC331CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H331JT 330pF

C402

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C2300

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C402

0CK472DK56A

"Capacitor,Ceramic,Chip" C2012X7R1H472KT 4.7nF

C2301

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C404

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C2302

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C406

0CH6010K116

"Capacitor,Ceramic,Chip" C2012C0G1H010DT 1pF 0.

C2303

0CK105CD56A

"Capacitor,Ceramic,Chip" C1608X7R1A105KT 1uF 10

C407

0CH6010K116

"Capacitor,Ceramic,Chip" C2012C0G1H010DT 1pF 0.

C2307

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C407

0CK472DK56A

"Capacitor,Ceramic,Chip" C2012X7R1H472KT 4.7nF

C2308

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C408

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C231

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C409

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C232

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C410

0CC560BK41A

"Capacitor,Ceramic,Chip" C1005C0G1H560JT 56pF 5

C300

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C411

0CC560BK41A

"Capacitor,Ceramic,Chip" C1005C0G1H560JT 56pF 5

C301

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C413

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C302

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C414

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C303

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C416

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C303

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C417

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C304

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C418

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C304

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C419

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C305

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C420

0CK101BK4EA

"Capacitor,Ceramic,Chip" C1005C0G1H101JT 100pF

C305

EAE36711901

"Capacitor,Ceramic,Chip" CS2012X7R103K500NR 100

C421

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C306

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C422

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C306

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C423

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C307

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C424

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C308

0CK225DD56A

"Capacitor,Ceramic,Chip" C2012X7R1A225KT 2.2uF

C425

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C309

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C426

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C310

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C427

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C311

0CK333DK56A

"Capacitor,Ceramic,Chip" C2012X7R1H333KT 33nF 1

C428

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C312

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C429

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C312

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C430

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C313

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C434

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C314

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C435

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C315

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C436

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C315

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C437

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C316

0CK225DFK4A

"Capacitor,Ceramic,Chip" C2012Y5V1C225MT 2.2uF

C442

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C316

EAE36711901

"Capacitor,Ceramic,Chip" CS2012X7R103K500NR 100

C443

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C317

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C444

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C318

0CK222DK4DA

"Capacitor,Ceramic,Chip" UMK212CG222JG-T 2.2nF

C445

0CK102CK56A

"Capacitor,Ceramic,Chip" 0603B102K500CT 1nF 10%

C319

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C448

0CH6010K116

"Capacitor,Ceramic,Chip" C2012C0G1H010DT 1pF 0.

C319

EAE36882801

"Capacitor,Ceramic,Chip" C2012C0G1H103JT 10nF 5

C449

0CH6010K116

"Capacitor,Ceramic,Chip" C2012C0G1H010DT 1pF 0.

C320

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C450

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

- 32 -

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

C451

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C536

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C452

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C541

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C453

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C542

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C454

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C542

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C456

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C543

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C457

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C543

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C459

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C600

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C460

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C601

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C461

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C602

0CK222DK56A

"Capacitor,Ceramic,Chip" CS2012X7R222K500NR 2.2

C462

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C603

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C463

0CK101BK4EA

"Capacitor,Ceramic,Chip" C1005C0G1H101JT 100pF

C603

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C464

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C604

0CK224DK56A

"Capacitor,Ceramic,Chip" CS2012X7R224K500NR 220

C465

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C604

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C466

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C605

0CH5102K416

"Capacitor,Ceramic,Chip" 0805N102J500LT 1nF 5%

C467

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C605

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C468

0CK471BK56A

"Capacitor,Ceramic,Chip" C1005X7R1H471KT 470pF

C606

0CH5102K416

"Capacitor,Ceramic,Chip" 0805N102J500LT 1nF 5%

C469

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C606

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C473

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C607

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C474

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C610

0CC470CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H470JT 47pF 5

C478

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C610

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C480

0CK101BK4EA

"Capacitor,Ceramic,Chip" C1005C0G1H101JT 100pF

C611

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C481

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C613

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C482

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C615

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C483

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C700

EAE33970001

"Capacitor,Ceramic,Chip" CS1005X5R105K6R3NR 1uF

C484

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C701

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C485

0CK105CD56A

"Capacitor,Ceramic,Chip" C1608X7R1A105KT 1uF 10

C701

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C487

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C702

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C488

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C703

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C490

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C704

EAE33970001

"Capacitor,Ceramic,Chip" CS1005X5R105K6R3NR 1uF

C491

0CK333CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H333KT 33nF 1

C705

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C492

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C706

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C493

0CK105CF94A

"Capacitor,Ceramic,Chip" 0603F105Z160CT 1uF -20

C707

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C494

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C708

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C495

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C709

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C496

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C709

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C497

0CK105CF94A

"Capacitor,Ceramic,Chip" 0603F105Z160CT 1uF -20

C710

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C498

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C711

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C499

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C712

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C502

0CK474DK56A

"Capacitor,Ceramic,Chip" UMK212BJ474KG-T 470nF

C713

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C503

0CK474DK56A

"Capacitor,Ceramic,Chip" UMK212BJ474KG-T 470nF

C714

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C505

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C715

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C507

0CC120CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H120JT 12pF 5

C716

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C509

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C717

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C509

EAE36711901

"Capacitor,Ceramic,Chip" CS2012X7R103K500NR 100

C718

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C510

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C719

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C511

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C720

0CC300CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H300JT 30pF 5

C512

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C721

0CC300CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H300JT 30pF 5

C514

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C723

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C516

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C728

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C521

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C729

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C522

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C730

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C523

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C731

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C524

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C742

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C534

0CC150BK4AA

"Capacitor,Ceramic,Chip" C1005C0G1H150JT 15pF 5

C743

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C535

0CC150BK4AA

"Capacitor,Ceramic,Chip" C1005C0G1H150JT 15pF 5

C744

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

- 33 -

LGE Internal Use Only

LOC. NO.

PART NO.

C745

0CK104CK56A

C746

0CK104CK56A

C747

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C804

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C805

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C806

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C748

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C807

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C749

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C808

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C750

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C809

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C751

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C810

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C752

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C811

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C753

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C812

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C754

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C901

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C755

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C902

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C756

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C906

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C760

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C907

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C761

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C908

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C762

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C909

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C763

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C910

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C764

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C911

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C765

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C912

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C766

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C913

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C767

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C914

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C768

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C915

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C769

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C916

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C770

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C917

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C771

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C918

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C772

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C919

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C773

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C920

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C774

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C921

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C775

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C922

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C776

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C923

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C777

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C924

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C778

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C925

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C779

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C926

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C780

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C927

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C781

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C928

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C782

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C929

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C783

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C930

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C784

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C931

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C785

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C932

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C786

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C933

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C787

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C934

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C789

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C935

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C790

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C936

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C791

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C937

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C792

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C938

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C793

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C939

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C794

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C940

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C795

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C941

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C796

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C942

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C797

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C943

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C798

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C945

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C799

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C946

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C800

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C947

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C801

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C948

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C802

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C949

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C803

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C950

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

- 34 -

DESCRIPTION / SPECIFICATION

LGE Internal Use Only

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

C451

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C536

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C452

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C541

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C453

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C542

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C454

0CC560CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H560JT 56pF 5

C542

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C456

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C543

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C457

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C543

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C459

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C600

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C460

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C601

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C461

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C602

0CK222DK56A

"Capacitor,Ceramic,Chip" CS2012X7R222K500NR 2.2

C462

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C603

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C463

0CK101BK4EA

"Capacitor,Ceramic,Chip" C1005C0G1H101JT 100pF

C603

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C464

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C604

0CK224DK56A

"Capacitor,Ceramic,Chip" CS2012X7R224K500NR 220

C465

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C604

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C466

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C605

0CH5102K416

"Capacitor,Ceramic,Chip" 0805N102J500LT 1nF 5%

C467

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C605

0CK471CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H471KT 470pF

C468

0CK471BK56A

"Capacitor,Ceramic,Chip" C1005X7R1H471KT 470pF

C606

0CH5102K416

"Capacitor,Ceramic,Chip" 0805N102J500LT 1nF 5%

C469

0CK474CH94A

"Capacitor,Ceramic,Chip" 0603F474Z250CT 470nF -

C606

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C473

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C607

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C474

0CK682CK51A

"Capacitor,Ceramic,Chip" C1608Y5P1H682KT 6.8nF

C610

0CC470CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H470JT 47pF 5

C478

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C610

0CK104DK56A

"Capacitor,Ceramic,Chip" 0805B104K500CT 100nF 1

C480

0CK101BK4EA

"Capacitor,Ceramic,Chip" C1005C0G1H101JT 100pF

C611

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C481

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C613

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C482

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C615

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C483

0CK102BK56A

"Capacitor,Ceramic,Chip" 0402B102K500CT 1nF 10%

C700

EAE33970001

"Capacitor,Ceramic,Chip" CS1005X5R105K6R3NR 1uF

C484

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C701

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C485

0CK105CD56A

"Capacitor,Ceramic,Chip" C1608X7R1A105KT 1uF 10

C701

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C487

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C702

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C488

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C703

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C490

0CK103CK56A

"Capacitor,Ceramic,Chip" 0603B103K500CT 10nF 10

C704

EAE33970001

"Capacitor,Ceramic,Chip" CS1005X5R105K6R3NR 1uF

C491

0CK333CK56A

"Capacitor,Ceramic,Chip" C1608X7R1H333KT 33nF 1

C705

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C492

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C706

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C493

0CK105CF94A

"Capacitor,Ceramic,Chip" 0603F105Z160CT 1uF -20

C707

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C494

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C708

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C495

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C709

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C496

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C709

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C497

0CK105CF94A

"Capacitor,Ceramic,Chip" 0603F105Z160CT 1uF -20

C710

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C498

0CK223CK56A

"Capacitor,Ceramic,Chip" UMK107JB223KA-T 22nF 1

C711

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C499

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C712

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C502

0CK474DK56A

"Capacitor,Ceramic,Chip" UMK212BJ474KG-T 470nF

C713

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C503

0CK474DK56A

"Capacitor,Ceramic,Chip" UMK212BJ474KG-T 470nF

C714

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C505

0CK105DH56A

"Capacitor,Ceramic,Chip" C2012X7R105KFT 1uF 10%

C715

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C507

0CC120CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H120JT 12pF 5

C716

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C509

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C717

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C509

EAE36711901

"Capacitor,Ceramic,Chip" CS2012X7R103K500NR 100

C718

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C510

0CK103BH56A

"Capacitor,Ceramic,Chip" C1005X7R1E103KT- 10nF

C719

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C511

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C720

0CC300CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H300JT 30pF 5

C512

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C721

0CC300CK41A

"Capacitor,Ceramic,Chip" C1608C0G1H300JT 30pF 5

C514

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C723

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C516

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C728

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C521

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C729

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C522

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C730

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C523

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C731

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C524

0CK104BF56A

"Capacitor,Ceramic,Chip" C1005X7R104KET 100nF 1

C742

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C534

0CC150BK4AA

"Capacitor,Ceramic,Chip" C1005C0G1H150JT 15pF 5

C743

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

C535

0CC150BK4AA

"Capacitor,Ceramic,Chip" C1005C0G1H150JT 15pF 5

C744

0CK104CK56A

"Capacitor,Ceramic,Chip" 0603B104K500CT 100nF 1

- 33 -

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

D514

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

IC1001

0IPMG78341A

"IC,LDO Voltage Regulator" "AZ1085S-3.3TR/E1,LF 12"

ZD100

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC1003

0IPRPML001A

"IC,LDO Voltage Regulator" MIC39100 2.3TO26V 0 0W

ZD101

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC1004

EAN34140401

"IC,LDO Voltage Regulator" AZ1085S-1.8TRE1 1.238V

ZD102

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

IC1102

0IPMGKE030A

"IC,LDO Voltage Regulator" KIA78R05F 6TO12V 5V 8W

ZD110

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC1104

0IPMG00107A

"IC,LDO Voltage Regulator" AZ1117H-2.5TR/E1 15V 2

ZD111

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC1105

0IPMG00027A

"IC,LDO Voltage Regulator" SC156515M-1.8TR 2.2TO5

ZD112

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC1110

0IPMG00027A

"IC,LDO Voltage Regulator" SC156515M-1.8TR 2.2TO5

ZD113

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

U502

0IPMG00047B

"IC,LDO Voltage Regulator" ICE3B1565J MAX12V 3.3V

ZD114

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

U600

0IMCRFE001A

"IC,PMIC" FA5501AN-TE1 10TO28V 8

ZD115

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

U101

EAN36316301

"IC,PWM Controller" LAF0001MX 20V 5V 0W SO

ZD116

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

U202

EAN36498101

"IC,PWM Controller" APU3037M 5TO12V 1.275V

ZD117

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC400

0IMCRMN028F

"IC,Sound/Audio Processor" MSP4450K-VK-E8-500 7.6

ZD118

EAH33946001

"Diode,TVS" CDS3C05GTA 5.6V 6.4V 1

IC401

0IMCRMN028F

"IC,Sound/Audio Processor" MSP4450K-VK-E8-500 7.6

ZD119

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

IC505

0IPRPSG023A

"IC,Timer" M41T81M6 2.0VTO5.5V 30

ZD120

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

IC502

EAN39038801

"IC,Tx/Rx" ADM3232EARNZ 3VTO5.5V

ZD121

EAH33945901

"Diode,TVS" CDS3C30GTH 30V 50V 120

IC1300

EAN35947401

"IC,Video Encode" "MT8158ADE 300MVTO3.6V,"

ZD605

0DR050008AA

"Diode,TVS" SD05.TC - 6V 14.5V 24A

IC1500

EAN38294101

"IC,Video Processors" "LGDT1300 3VTO3.6V,2.3V"

ZD100

0DZPT36009A

"Diode,Zener" UZ-3.6BSB 3.6V 3.62TO3

IC700

0IPRP00692E

"IC,Video Processors" FLI30436-LF-AC(XD30436

ZD101

0DZ560009DA

"Diode,Zener" UDZS5.6B 5.6V 5.49TO5.

IC1305

0IKE702900G

"IC,Voltage Detector" KIA7029AF -0.3TO15V 2.

ZD101

0DZ560009DA

"Diode,Zener" UDZS5.6B 5.6V 5.49TO5.

IC702

0IKE702900G

"IC,Voltage Detector" KIA7029AF -0.3TO15V 2.

ZD102

0DZ560009DA

"Diode,Zener" UDZS5.6B 5.6V 5.49TO5.

IC1005

0IPMG78391A

"IC,Voltage Regulator" SC2595STR 2.3TO5V 0 0W

ZD102

0DZ560009DA

"Diode,Zener" UDZS5.6B 5.6V 5.49TO5.

IC1101

EAN32662801

"IC,Voltage Regulator" KA7809ERTM 35V to 40V

ZD240

EAH36634701

"Diode,Zener" UZ- 6.8BSB 6.8V +-2% 2

IC1107

0IPMG78391A

"IC,Voltage Regulator" SC2595STR 2.3TO5V 0 0W

ZD400

0DZRM00248A

"Diode,Zener" RLZ8.2B 8.2V 7.78TO8.1

U102

EAN36841801

"IC,Voltage Regulator" KA431SAMF2TF 37 2.5 35

ZD401

0DZRM00248A

"Diode,Zener" RLZ8.2B 8.2V 7.78TO8.1

U201

EAN36841801

"IC,Voltage Regulator" KA431SAMF2TF 37 2.5 35

ZD500

EAH36633801

"Diode,Zener" UZ- 15BSB 15V +-2% 25O

U203

EAN36841801

"IC,Voltage Regulator" KA431SAMF2TF 37 2.5 35

ZD501

0DZPT36009A

"Diode,Zener" UZ-3.6BSB 3.6V 3.62TO3

U303

0IKE780500C

"IC,Voltage Regulator" KIA78L05F 7TO20V 5V 50

ZD502

EAH36664401

"Diode,Zener" KDZ20V 20V 18.8TO21.2V

U500

EAN36841801

"IC,Voltage Regulator" KA431SAMF2TF 37 2.5 35

ZD701

EAH36663601

"Diode,Zener" KDZ18V 18V 16.8TO19.1V

U501

EAN36675201

"IC,Voltage Regulator" KIA78L15BP 16.7VTO35V

ZD702

EAH36663601

"Diode,Zener" KDZ18V 18V 16.8TO19.1V

FILTERs & INDUCTORs

ICs
L1101

6140VB0004B

"Coil,Choke" LN-15A1(26UH) 26uH AC5

IC1501

EAN38294301

"IC,A/D Converter" AD80180KCPZ-80 1.7TO3.

L200

EAP36784402

"Coil,Choke" 2130KK0079A-F 0.6uH 5V

IC300

0ISO206900A

"IC,Analog Switch" CXA2069Q 8.5TO9.5V - -

L201

EAP36784401

"Coil,Choke" 2130KK0080A 3uH 5V 5A

IC600

EAN38911401

"IC,Analog Switch" BD2041AFJ-E2 2.7TO5.5V

L202

EAP36784402

"Coil,Choke" 2130KK0079A-F 0.6uH 5V

IC402

EAN32404601

"IC,Audio Amplifier" NTP3000 7TO30V 5.5V 0.

L203

EAP36784402

"Coil,Choke" 2130KK0079A-F 0.6uH 5V

IC1302

EAN33402201

"IC,Bus Controller" BU9580KVT-E2 3.0TO3.6V

L600

EAP36780501

"Coil,Horizontal" 2130KP0173A-F 220uH 50

IC501

0IPH741400E

"IC,CMOS" 74HC14D 2TO6V 0.002mA

AL1200

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

IC507

0IMCRFA018A

"IC,CMOS" NC7SB3157P6X_NL 1.65TO

AL1201

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

IC508

0IMCRFA018A

"IC,CMOS" NC7SB3157P6X_NL 1.65TO

AL1202

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

U304

0IKE393800A

"IC,Comparator" KIA393F +-18 36V +-18V

AL1203

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

IC1200

0IPRPS5006C

"IC,Data Controller" SIL9025CTU 3.0TO3.6V 2

AL1204

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

IC1111

EAN35520901

"IC,DC,DC Converter" MP2355DN-LF-Z 4.75V ~

AL1205

6210TCE002B

"Filter,Bead" HB-4M3216-121JT 120OHM

IC1301

EAN31729201

"IC,DDR SDRAM" HY5DU561622ETP-4 256MB

FB101

6210TCE003N

"Filter,Bead" BRD3565T0 145TO215OHM

IC901

EAN32205201

"IC,DDR SDRAM" HY5DU281622FTP-5 128MB

FB102

EAM37542501

"Filter,Bead" HB-1M3216-301JT 300OHM

IC902

EAN32205201

"IC,DDR SDRAM" HY5DU281622FTP-5 128MB

FB201

6210TCE003N

"Filter,Bead" BRD3565T0 145TO215OHM

U301

EAN36498501

"IC,Display Driver" LX1691AIPW 2.8TO5.5V 3

FB202

6210TCE003N

"Filter,Bead" BRD3565T0 145TO215OHM

U701

EAN36495702

"IC,Display Driver" FAN7382N 0.3TO25V 25.3

FB500

EAM37542501

"Filter,Bead" HB-1M3216-301JT 300OHM

IC1201

0IMMRAL014D

"IC,EEPROM" AT24C02BN-SH-T 2KBIT 2

FB600

EAM37542501

"Filter,Bead" HB-1M3216-301JT 300OHM

IC1202

0IMMRAL014D

"IC,EEPROM" AT24C02BN-SH-T 2KBIT 2

FB601

6210TCE003N

"Filter,Bead" BRD3565T0 145TO215OHM

IC1303

0IMP242560A

"IC,EEPROM" 24LC256T-I/SM 256KBIT

FB602

EAM37542501

"Filter,Bead" HB-1M3216-301JT 300OHM

IC500

0IMMRAL014D

"IC,EEPROM" AT24C02BN-SH-T 2KBIT 2

FB603

6210TCE003K

"Filter,Bead" BAS3550T0 65TO100OHM 3

IC701

0IMP242560A

"IC,EEPROM" 24LC256T-I/SM 256KBIT

FB604

6210TCE003K

"Filter,Bead" BAS3550T0 65TO100OHM 3

IC1000

0IPMG78341A

"IC,LDO Voltage Regulator" "AZ1085S-3.3TR/E1,LF 12"

FB701

6210TCE003K

"Filter,Bead" BAS3550T0 65TO100OHM 3

IC1000

0IPMG78341A

"IC,LDO Voltage Regulator" "AZ1085S-3.3TR/E1,LF 12"

L1001

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

- 36 -

LOC. NO.

PART NO.

L1002

6210TCE001G

L1003

6210TCE001G

L1005

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Filter,Bead" HH-1M3216-501JT 500OHM

L1142

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

"Filter,Bead" HH-1M3216-501JT 500OHM

L1143

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L1144

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1006

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L1145

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1007

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1146

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1008

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1148

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L1009

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1200

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L101

6200J00005E

"Filter,Bead" HH-1M2012-601JT 600OHM

L1201

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1010

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1202

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1011

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1203

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1012

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1300

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1013

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L200

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1014

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L201

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1015

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L202

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1016

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L300

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1017

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L301

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1018

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L400

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1019

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L401

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L102

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L402

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1020

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L405

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1100

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L406

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1102

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L407

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1103

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L409

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1104

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L410

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1105

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L419

6210TCE001P

"Filter,Bead" HB-1S2012-121JT(H:1mm)

L1106

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L420

6210TCE001P

"Filter,Bead" HB-1S2012-121JT(H:1mm)

L1107

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L421

6210TCE001P

"Filter,Bead" HB-1S2012-121JT(H:1mm)

L1109

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L422

6210TCE001P

"Filter,Bead" HB-1S2012-121JT(H:1mm)

L1110

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L500

EAM30764201

"Filter,Bead" BG2012B102TF 1000ohm 2

L1111

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L501

EAM30764201

"Filter,Bead" BG2012B102TF 1000ohm 2

L1112

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L502

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1113

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L503

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1114

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L504

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1115

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L600

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1116

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L601

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1117

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L602

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1118

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L603

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1119

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L604

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1120

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L605

EAM30764101

"Filter,Bead" MBW3216-501TF 500ohm 3

L1121

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L613

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L1125

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L614

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L1126

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L615

6210TCE0013

"Filter,Bead" HB-1M1608-121JT 120OHM

L1127

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L619

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L1128

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L608

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1129

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L609

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1130

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L610

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1131

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L611

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1132

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L612

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1134

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L616

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1135

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L617

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1137

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L618

EAM33010401

"Filter,LCR" MEM2012P25R0 EMI 25MHZ

L1138

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

LF101

EAM00101303

"Filter,Line Noise" 2130KK0083A-F 13.5MH 3

L1139

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

LF102

EAM00101303

"Filter,Line Noise" 2130KK0083A-F 13.5MH 3

L1140

6210TCE001G

"Filter,Bead" HH-1M3216-501JT 500OHM

L203

0LCML00020G

"Inductor,Multilayer,Chip" MLI-201209-3R3K 3.3UH

L1141

6200J00005N

"Filter,Bead" HH-1M2012-121JT(H:1mm)

L204

0LCML00020G

"Inductor,Multilayer,Chip" MLI-201209-3R3K 3.3UH

- 37 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

L403

0LCML00020C

L404

0LCML00020C

L1147

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Inductor,Multilayer,Chip" MLI-201212-100K 10UH 1

Q117

0TRIY80001A

"Inductor,Multilayer,Chip" MLI-201212-100K 10UH 1

Q118

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

EAP32842805

"Inductor,Wire Wound,Chip" NR8040T150M 15UH 20% 0

Q1200

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

L412

EAP38319001

"Inductor,Wire Wound,Chip" DA-8580 22UH 20% 0V 3A

Q1201

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

L413

EAP38319001

"Inductor,Wire Wound,Chip" DA-8580 22UH 20% 0V 3A

Q1300

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q1301

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q200

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q201

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q201

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q202

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q202

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

Q203

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q203

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q204

0TR126609AA

"TR,Bipolar" KTA1266-Y(KTA1015) PNP

TRANSISTORs & FETs


IC1203

0TFTH80001A

FET SSM6N15FU N-CHANNEL MO

IC1204

0TFTH80001A

FET SSM6N15FU N-CHANNEL MO

IC1205

0TFTH80001A

FET SSM6N15FU N-CHANNEL MO

IC200

0TFTH80001A

FET SSM6N15FU N-CHANNEL MO

Q103

0TFFN10005A

FET SPA04N60C3 N-CHANNEL M

Q205

0TFFC10028A

FET FQPF27P06 P-CHANNEL MO

Q208

EBK36497901

FET AP62T03GH N-CHANNEL MO

Q209

EBK36497901

FET AP62T03GH N-CHANNEL MO

Q301

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q314

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q315

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q316

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q319

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q321

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q322

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q323

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q324

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q325

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q326

EBK36722001

FET 2N7002A N-CHANNEL MOSF

Q606

0TFFN10010A

FET SD20N60 N-CHANNEL MOSF

Q607

0TFFN10010A

FET SD20N60 N-CHANNEL MOSF

Q706

0TFFN10010A

FET SD20N60 N-CHANNEL MOSF

Q707

0TFFN10010A

FET SD20N60 N-CHANNEL MOSF

IC1109

0TF492509AA

"FET,Array" SI4925DY P-CHANNEL -30

Q100

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q1000

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q1001

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q1002

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q1003

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q101

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q101

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q101

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

Q102

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q102

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

Q104

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q106

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q107

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q108

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q109

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q110

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q1100

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q111

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q112

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q113

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q114

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q115

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q116

0TRIY80001A

"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

DESCRIPTION / SPECIFICATION
"TR,Bipolar" 2SC3052 NPN 6V 50V 50V

Q204

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q205

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q206

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q206

0TR320000AB

"TR,Bipolar" KTC3200-BL(KTC2240) NP

Q207

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q207

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q208

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q209

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q210

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q211

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q300

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q301

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q302

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q303

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q304

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q305

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q306

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q317

EBK36673501

"TR,Bipolar" KRA224S PNP -30V 0V -5

Q318

0TR102009AJ

"TR,Bipolar" KRC102S NPN 30V 0V 50V

Q320

0TR102009AJ

"TR,Bipolar" KRC102S NPN 30V 0V 50V

Q400

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q401

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q402

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q403

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q404

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q405

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q406

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q407

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q408

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q409

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q410

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q411

0TR387500AA

"TR,Bipolar" 2SC3875S(ALY) NPN 5V 6

Q501

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q502

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

Q600

0TR102009AJ

"TR,Bipolar" KRC102S NPN 30V 0V 50V

Q601

0TR102009AJ

"TR,Bipolar" KRC102S NPN 30V 0V 50V

Q602

0TR150400BA

"TR,Bipolar" 2SA1504S(ASY) PNP -5V

Q608

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

Q609

0TRKE80078A

"TR,Bipolar" KTA1552T PNP -6V -50V

Q620

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

Q701

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

- 38 -

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

Q702

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

AR909

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

Q703

0TR222209AB

"TR,Bipolar" KTN2222AS NPN 6V 75V 4

AR910

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

Q704

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

JR1

0RJ0000G676

"Resistor,Chip" MCR18EZHJ00 0OHM 5% 1/

Q705

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

JR4

0RJ0000G676

"Resistor,Chip" MCR18EZHJ00 0OHM 5% 1/

Q708

EBK36645601

"TR,Bipolar" KTN2907AS PNP -5V -60V

JR5

0RJ0000G676

"Resistor,Chip" MCR18EZHJ00 0OHM 5% 1/

JR8

0RJ0000G676

"Resistor,Chip" MCR18EZHJ00 0OHM 5% 1/

R1001

0RJ2000C678

"Resistor,Chip" MCR01MZPJ201 200OHM 5%

R1003

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R1004

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1005

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R1007

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1008

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R1009

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R101

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R101

0RH2702D622

"Resistor,Chip" MCR10EZHJ273 27KOHM 5%

R101

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

RESISTORs
AR1300

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1301

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1302

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1303

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1304

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1305

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1306

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1307

0RJ0752C687

"Resistor,Array" RCA86TRJ75R0 75OHM 5%

AR1308

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1309

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1310

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1311

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1312

EBC32260401

"Resistor,Array" MNR04M0APJ103 10KOHM 5

AR1313

EBC32260401

"Resistor,Array" MNR04M0APJ103 10KOHM 5

AR1314

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1315

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1316

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1317

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1318

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1319

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1320

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1321

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1322

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1323

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR1501

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR1502

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR1503

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR1504

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR1505

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR1506

0RJ0222C687

"Resistor,Array" RCA86TRJ22R0 22OHM 5%

AR701

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR702

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR703

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR704

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR705

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR706

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR707

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR708

0RZZH033273

"Resistor,Array" MNR04M0ABJ330 33OHM 5%

AR900

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR901

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR902

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR903

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR904

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR905

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR906

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR907

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

AR908

EBC32260405

"Resistor,Array" MNR04M0APJ680 68OHM 5%

R101

0RJ1200D677

"Resistor,Chip" MCR03EZPJ121 120OHM 5%

R1010

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1011

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R1012

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1013

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1014

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1015

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R1016

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1019

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R102

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R102

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R102

0RH8201D622

"Resistor,Chip" MCR10EZHJ822 8.2KOHM 5

R102

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R102

0RJ1200D677

"Resistor,Chip" MCR03EZPJ121 120OHM 5%

R1020

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1020

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1023

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1026

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1029

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R103

0RH2201D622

"Resistor,Chip" MCR10EZHJ222 2.2KOHM 5

R103

0RH2701D622

"Resistor,Chip" MCR10EZHJ272 2.7KOHM 5

R103

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1030

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1031

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1032

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1033

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1034

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R104

0RH7503D622

"Resistor,Chip" MCR10EZHJ754 750KOHM 5

R104

0RH9100D622

"Resistor,Chip" MCR10EZHJ911 910OHM 5%

R105

0RH2702D622

"Resistor,Chip" MCR10EZHJ273 27KOHM 5%

R105

0RH7503D622

"Resistor,Chip" MCR10EZHJ754 750KOHM 5

R105

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R105

0RJ5602D477

"Resistor,Chip" MCR03EZPF563 56KOHM 1%

R106

0RH7503D622

"Resistor,Chip" MCR10EZHJ754 750KOHM 5

R106

0RH8201D622

"Resistor,Chip" MCR10EZHJ822 8.2KOHM 5

R106

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R106

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R107

0RH2002D622

"Resistor,Chip" MCR10EZHJ203 20KOHM 5%

R107

0RH2701D622

"Resistor,Chip" MCR10EZHJ272 2.7KOHM 5

- 39 -

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

R107

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1215

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R108

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1216

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R108

0RH9100D622

"Resistor,Chip" MCR10EZHJ911 910OHM 5%

R1217

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R108

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R1218

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R108

0RJ1003E672

"Resistor,Chip" MCR10EZHJ104 100KOHM 5

R1219

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R109

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R122

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R109

0RH1203D622

"Resistor,Chip" MCR10EZHJ124 120KOHM 5

R1220

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R109

0RH4700D622

"Resistor,Chip" MCR10EZHJ471 470OHM 5%

R1221

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R109

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1222

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R109

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1223

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R110

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1224

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R110

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1226

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R110

0RH1502D622

"Resistor,Chip" MCR10EZHJ153 15KOHM 5%

R1227

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R110

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1228

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1100

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1229

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1101

0RJ1201C678

"Resistor,Chip" MCR01MZPJ122 1.2KOHM 5

R123

0RH1203D622

"Resistor,Chip" MCR10EZHJ124 120KOHM 5

R1102

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1230

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1103

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1231

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1104

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1232

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1104

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R1233

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1105

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1234

0RJ6801C678

"Resistor,Chip" MCR01MZPJ682 6.8KOHM 5

R1107

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1235

0RJ6801D677

"Resistor,Chip" MCR03EZPJ682 6.8KOHM 5

R1108

0RJ2002D677

"Resistor,Chip" MCR03EZPJ203. 20KOHM 5

R1236

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1109

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R1237

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R111

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1238

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R1113

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R124

0RH6802D622

"Resistor,Chip" MCR10EZHJ683 68KOHM 5%

R1114

0RJ2002D677

"Resistor,Chip" MCR03EZPJ203. 20KOHM 5

R1240

0RJ6801D677

"Resistor,Chip" MCR03EZPJ682 6.8KOHM 5

R1115

0RJ6802D677

"Resistor,Chip" MCR03EZPJ683 68KOHM 5%

R1241

0RJ6801D677

"Resistor,Chip" MCR03EZPJ682 6.8KOHM 5

R1116

0RJ2202D677

"Resistor,Chip" MCR03EZPJ223 22KOHM 5%

R1246

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R1117

0RJ7501D677

"Resistor,Chip" MCR03EZPJ752 7.5KOHM 5

R1247

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R112

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1248

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R112

0RH1004D622

"Resistor,Chip" MCR10EZHJ105 1MOHM 5%

R1249

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R112

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R125

0RH4702D622

"Resistor,Chip" MCR10EZHJ473 47KOHM 5%

R113

0RH1004D622

"Resistor,Chip" MCR10EZHJ105 1MOHM 5%

R1250

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R113

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R1251

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R114

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R1252

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R114

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R1253

0RJ4702D677

"Resistor,Chip" MCR03EZPJ473 47KOHM 5%

R115

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1254

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R115

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R1255

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R117

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R1257

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R117

0RH4700D622

"Resistor,Chip" MCR10EZHJ471 470OHM 5%

R1258

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R117

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1260

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R118

0RH5600D622

"Resistor,Chip" MCR10EZHJ561 560OHM 5%

R1261

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R119

0RH2201D622

"Resistor,Chip" MCR10EZHJ222 2.2KOHM 5

R1262

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R119

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1263

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R120

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1264

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1200

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1265

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1201

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1266

0RJ1004C678

"Resistor,Chip" MCR01MZPJ105 1MOHM 5%

R1206

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R1267

0RJ1820D477

"Resistor,Chip" MCR03EZPF1820 182OHM 1

R1207

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R1268

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1208

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R1269

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1209

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R127

0RH2202D622

"Resistor,Chip" MCR10EZHJ223 22KOHM 5%

R121

0RH7503D622

"Resistor,Chip" MCR10EZHJ754 750KOHM 5

R1272

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R1210

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1273

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1214

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1274

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

- 40 -

LOC. NO.

PART NO.

R1275

0RJ0222C678

R1276

0RJ0512C678

R1278

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R1357

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

"Resistor,Chip" MCR01MZPJ510 51OHM 5%

R1358

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1361

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1279

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R1362

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1280

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R1363

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1283

0RJ2702D677

"Resistor,Chip" MCR03EZPJ273 27KOHM 5%

R1366

0RJ1004C678

"Resistor,Chip" MCR01MZPJ105 1MOHM 5%

R1284

0RJ9101D677

"Resistor,Chip" MCR03EZPJ912 9.1KOHM 5

R1367

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R1300

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1369

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R1301

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R137

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1302

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1370

0RJ0822C678

"Resistor,Chip" MCR01MZPJ820 82OHM 5%

R1303

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1371

0RJ1202C678

"Resistor,Chip" MCR01MZPJ123 12KOHM 5%

R1304

0RJ7502D677

"Resistor,Chip" MCR03EZPJ753 75KOHM 5%

R1372

0RJ0822C678

"Resistor,Chip" MCR01MZPJ820 82OHM 5%

R1305

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1373

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1306

0RJ0471D677

"Resistor,Chip" MCR03EZPJ4R7 4.7OHM 5%

R1374

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1307

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1375

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1308

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1376

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R1310

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1377

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1311

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1378

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1312

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R138

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1313

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1380

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1315

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1381

0RJ3300C678

"Resistor,Chip" MCR01MZPJ331 330OHM 5%

R1316

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1382

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R1317

0RJ1004C678

"Resistor,Chip" MCR01MZPJ105 1MOHM 5%

R1383

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1318

0RJ0471D677

"Resistor,Chip" MCR03EZPJ4R7 4.7OHM 5%

R1384

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1319

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1385

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1320

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1386

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1323

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1387

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1324

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1388

0RJ3300C678

"Resistor,Chip" MCR01MZPJ331 330OHM 5%

R1325

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1389

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1326

0RJ5601D677

"Resistor,Chip" MCR03EZPJ562 5.6KOHM 5

R139

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1327

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1393

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1328

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1395

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1329

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R1396

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R1330

0RJ0512C678

"Resistor,Chip" MCR01MZPJ510 51OHM 5%

R1397

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R1331

0RJ0471C678

"Resistor,Chip" MCR01MZPJ4R7 4.7OHM 5%

R1398

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R1332

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1399

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R1333

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R140

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R1334

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1400

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1335

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1401

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1336

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1402

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1339

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1403

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1340

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1404

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R1341

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R142

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1342

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R145

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1343

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R147

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1344

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1500

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1345

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1501

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1346

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R1502

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1347

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1503

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1348

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1505

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R1349

0RJ2000D677

"Resistor,Chip" MCR03EZPJ201 200OHM 5%

R1506

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1350

0RJ2000D677

"Resistor,Chip" MCR03EZPJ201 200OHM 5%

R1507

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1351

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1508

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1352

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R1509

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R1356

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R151

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

- 41 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R1510

0RJ0332C678

R1511

0RJ0332C678

R1512

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R201

0RJ1000G683

"Resistor,Chip" CR32-1000J 100OHM 5% 1

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R202

0RJ1000G683

"Resistor,Chip" CR32-1000J 100OHM 5% 1

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R202

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1513

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R203

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R1514

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R203

0RJ0822D677

"Resistor,Chip" MCR03EZPJ820 82OHM 5%

R1515

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R204

0RH4701D422

"Resistor,Chip" MCR10EZHF472 4.7KOHM 1

R1518

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R204

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R1519

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R205

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R1520

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R205

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R1521

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R206

0RH4702D622

"Resistor,Chip" MCR10EZHJ473 47KOHM 5%

R1522

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R206

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R1523

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R207

0RH4701D422

"Resistor,Chip" MCR10EZHF472 4.7KOHM 1

R153

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

R207

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R1536

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R208

0RH4700D622

"Resistor,Chip" MCR10EZHJ471 470OHM 5%

R1537

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R208

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R1539

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R209

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1540

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R209

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R1541

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R210

0RH0221D622

"Resistor,Chip" MCR10EZHJ2R2 2.2OHM 5%

R1542

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R210

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R1543

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R2100

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1545

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R2101

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1546

0RJ1501C678

"Resistor,Chip" MCR01MZPJ152 1.5KOHM 5

R2102

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1547

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R2103

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R1549

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R2104

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1550

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R2105

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1551

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R2106

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1552

0RJ1004D677

"Resistor,Chip" MCR03EZPJ105 1MOHM 5%

R2107

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1555

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R2108

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1556

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R2109

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R1557

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R211

0RH2002D622

"Resistor,Chip" MCR10EZHJ203 20KOHM 5%

R1557

0RJ9101D677

"Resistor,Chip" MCR03EZPJ912 9.1KOHM 5

R211

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R156

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2110

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R158

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2111

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R159

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R2112

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R160

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R2113

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R176

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R2114

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R177

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R2115

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R178

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R2116

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R179

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R2117

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R180

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R2118

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R181

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R2119

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R182

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R212

0RH0221D622

"Resistor,Chip" MCR10EZHJ2R2 2.2OHM 5%

R183

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R212

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R184

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2120

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R188

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R2121

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R189

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R2122

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R190

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R2123

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R191

0RJ2203D677

"Resistor,Chip" MCR03EZPJ224 220KOHM 5

R2124

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R192

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R2125

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R193

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R2126

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R194

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R2127

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R195

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2128

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R196

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2129

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R200

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R213

0RH0471D622

"Resistor,Chip" MCR10EZHJ4R7 4.7OHM 5%

R201

0RJ0822D677

"Resistor,Chip" MCR03EZPJ820 82OHM 5%

R213

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

- 42 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R2130

0RJ1502D677

R2131

0RJ1502D677

R2132

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R2328

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R2329

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R233

0RH5602D622

"Resistor,Chip" MCR10EZHJ563 56KOHM 5%

R2133

0RJ1502D677

"Resistor,Chip" MCR03EZPJ153 15KOHM 5%

R233

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R2134

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2331

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R2135

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2333

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R2136

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2335

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R2137

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2337

0RJ3301C678

"Resistor,Chip" MCR01MZPJ332 3.3KOHM 5

R2138

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2338

0RJ2001C678

"Resistor,Chip" MCR01MZPJ202 2KOHM 5%

R2139

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R2339

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R214

0RH1801D422

"Resistor,Chip" MCR10EZHF182 1.8KOHM 1

R234

0RH2702D622

"Resistor,Chip" MCR10EZHJ273 27KOHM 5%

R214

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R234

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R215

0RH1001D422

"Resistor,Chip" MCR10EZHF102 1KOHM 1%

R2340

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R215

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R2341

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R216

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R2342

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R216

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R2343

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R217

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R2344

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R218

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R2345

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R218

0RJ0822D677

"Resistor,Chip" MCR03EZPJ820 82OHM 5%

R235

0RH1202D422

"Resistor,Chip" MCR10EZHF123 12KOHM 1%

R219

0RH2001D622

"Resistor,Chip" MCR10EZHJ202 2KOHM 5%

R235

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R219

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R236

0RH4703D622

"Resistor,Chip" MCR10EZHJ474 470KOHM 5

R220

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R236

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R220

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R237

0RH1501D622

"Resistor,Chip" MCR10EZHJ152 1.5KOHM 5

R221

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R237

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R221

0RJ0102D677

"Resistor,Chip" MCR03EZPJ100 10OHM 5%

R238

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R222

0RJ2000D677

"Resistor,Chip" MCR03EZPJ201 200OHM 5%

R238

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R223

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R239

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R224

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R239

0RJ6801E472

"Resistor,Chip" RC98TRF6K80 6.8KOHM 1%

R225

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R240

0RH2001D622

"Resistor,Chip" MCR10EZHJ202 2KOHM 5%

R226

0RJ2700D677

"Resistor,Chip" MCR03EZPJ271 270OHM 5%

R240

0RJ3900D677

"Resistor,Chip" MCR03EZPJ391 390OHM 5%

R227

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R241

0RH1202D422

"Resistor,Chip" MCR10EZHF123 12KOHM 1%

R228

0RJ1502E472

"Resistor,Chip" MCR10EZHF153 15KOHM 1%

R241

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R228

0RJ2201D677

"Resistor,Chip" MCR03EZPJ222 2.2KOHM 5

R242

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R229

0RH1501D422

"Resistor,Chip" MCR10EZHF152 1.5KOHM 1

R243

0RJ2001E472

"Resistor,Chip" MCR10EZHF202 2KOHM 1%

R229

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

R244

0RJ5600E472

"Resistor,Chip" 0805S8F5600T5E 560OHM

R230

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R245

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R230

0RJ1002E472

"Resistor,Chip" MCR10EZHF103 10KOHM 1%

R246

0RH2001D622

"Resistor,Chip" MCR10EZHJ202 2KOHM 5%

R2300

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R247

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R2301

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R248

0RH2200D622

"Resistor,Chip" MCR10EZHJ221 220OHM 5%

R2302

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R249

0RH1502D622

"Resistor,Chip" MCR10EZHJ153 15KOHM 5%

R2303

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R300

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R231

0RH1000D422

"Resistor,Chip" MCR10EZHF101 100OHM 1%

R301

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R231

0RJ1500D677

"Resistor,Chip" MCR03EZPJ151 150OHM 5%

R301

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R2312

0RJ3301D677

"Resistor,Chip" MCR03EZPJ332 3.3KOHM 5

R302

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R2313

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R302

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R2314

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R303

0RJ1800D677

"Resistor,Chip" MCR03EZPJ181 180OHM 5%

R2316

0RJ0182C478

"Resistor,Chip" MCR01MZPF180 18OHM 1%

R304

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R2318

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R305

0RJ1500D677

"Resistor,Chip" MCR03EZPJ151 150OHM 5%

R232

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R306

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R232

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R307

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R2320

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R307

0RJ1203E472

"Resistor,Chip" MCR10EZHF 1203 120KOHM

R2322

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R308

0RJ1203E472

"Resistor,Chip" MCR10EZHF 1203 120KOHM

R2324

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R308

0RJ3300D677

"Resistor,Chip" MCR03EZPJ331 330OHM 5%

R2326

0RJ1600D677

"Resistor,Chip" MCR03EZPJ161 160OHM 5%

R309

0RH9102D622

"Resistor,Chip" MCR10EZHJ913 91KOHM 5%

R2327

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R309

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

- 43 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R310

0RH5102D622

R310

0RJ2200D677

R311
R311

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR10EZHJ513 51KOHM 5%

R346

0RH4702D422

"Resistor,Chip" MCR10EZHF473 47KOHM 1%

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R347

0RJ3002E472

"Resistor,Chip" MCR10EZHF303 30KOHM 1%

0RH4302D422

"Resistor,Chip" MCR10EZHF433 43KOHM 1%

R348

0RH3902D422

"Resistor,Chip" MCR10EZHF393 39KOHM 1%

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R352

0RJ1201C678

"Resistor,Chip" MCR01MZPJ122 1.2KOHM 5

R312

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R354

0RJ1201C678

"Resistor,Chip" MCR01MZPJ122 1.2KOHM 5

R312

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R355

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R313

0RH3902D422

"Resistor,Chip" MCR10EZHF393 39KOHM 1%

R367

0RH4704D622

"Resistor,Chip" MCR10EZHJ475 4.7MOHM 5

R313

0RJ2200C678

"Resistor,Chip" MCR01MZPJ221 220OHM 5%

R368

0RH1504D622

"Resistor,Chip" MCR10EZHJ155 1.5MOHM 5

R314

0RJ2200C678

"Resistor,Chip" MCR01MZPJ221 220OHM 5%

R369

0RH4704D622

"Resistor,Chip" MCR10EZHJ475 4.7MOHM 5

R314

EBC00837802

"Resistor,Chip" 0805S8F5100T5E 510OHM

R370

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R315

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R372

0RJ3001E472

"Resistor,Chip" 0805WAF3001T5E 3KOHM 1

R315

0RJ1203E472

"Resistor,Chip" MCR10EZHF 1203 120KOHM

R373

0RH3002D622

"Resistor,Chip" MCR10EZHJ303 30KOHM 5%

R316

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R374

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R316

0RJ7502E472

"Resistor,Chip" 0805S8F7502T5E 75KOHM

R375

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R317

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R378

0RH4702D622

"Resistor,Chip" MCR10EZHJ473 47KOHM 5%

R317

0RJ7502E472

"Resistor,Chip" 0805S8F7502T5E 75KOHM

R379

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R318

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R380

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R318

0RJ2200D677

"Resistor,Chip" MCR03EZPJ221 220OHM 5%

R381

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R319

0RH1502D622

"Resistor,Chip" MCR10EZHJ153 15KOHM 5%

R382

0RH4704D622

"Resistor,Chip" MCR10EZHJ475 4.7MOHM 5

R319

0RJ2200C678

"Resistor,Chip" MCR01MZPJ221 220OHM 5%

R383

0RH4704D622

"Resistor,Chip" MCR10EZHJ475 4.7MOHM 5

R320

0RH1502D622

"Resistor,Chip" MCR10EZHJ153 15KOHM 5%

R384

0RJ1003E672

"Resistor,Chip" MCR10EZHJ104 100KOHM 5

R320

0RJ2200C678

"Resistor,Chip" MCR01MZPJ221 220OHM 5%

R400

0RJ0432D677

"Resistor,Chip" MCR03EZPJ430 43OHM 5%

R321

0RH4700D622

"Resistor,Chip" MCR10EZHJ471 470OHM 5%

R401

0RJ6201D677

"Resistor,Chip" MCR03EZPJ622 6.2KOHM 5

R321

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R402

0RJ0432C678

"Resistor,Chip" MCR01MZPJ 430 43OHM 5%

R322

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R403

0RJ0432C678

"Resistor,Chip" MCR01MZPJ 430 43OHM 5%

R323

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R404

0RH1101D422

"Resistor,Chip" MCR10EZHF112 1.1KOHM 1

R324

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R404

0RJ6201D677

"Resistor,Chip" MCR03EZPJ622 6.2KOHM 5

R324

0RJ1503E472

"Resistor,Chip" MCR10EZHF1503 150KOHM

R405

0RJ2402D677

"Resistor,Chip" MCR03EZPJ243 24KOHM 5%

R325

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R406

0RJ1501D677

"Resistor,Chip" MCR03EZPJ152 1.5KOHM 5

R326

0RH1803D422

"Resistor,Chip" MCR10EZHF184 180KOHM 1

R407

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R326

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R409

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R327

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R410

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R327

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R411

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R328

0RH2204D622

"Resistor,Chip" MCR10EZHJ225 2.2MOHM 5

R412

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R328

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R413

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R329

0RH2202D422

"Resistor,Chip" MCR10EZHF223 22KOHM 1%

R414

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R329

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R415

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R330

0RJ1003C678

"Resistor,Chip" MCR01MZPJ104 100KOHM 5

R416

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R330

0RJ3002E472

"Resistor,Chip" MCR10EZHF303 30KOHM 1%

R417

0RH1101D422

"Resistor,Chip" MCR10EZHF112 1.1KOHM 1

R331

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R417

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R331

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R418

0RH1001D422

"Resistor,Chip" MCR10EZHF102 1KOHM 1%

R332

0RH1000D422

"Resistor,Chip" MCR10EZHF101 100OHM 1%

R419

0RH1101D422

"Resistor,Chip" MCR10EZHF112 1.1KOHM 1

R332

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R419

EBC00811302

"Resistor,Chip" 0805W8F9100T5E 910OHM

R333

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R420

0RH4701D422

"Resistor,Chip" MCR10EZHF472 4.7KOHM 1

R334

0RH1004D422

"Resistor,Chip" MCR10EZHF105 1MOHM 1%

R420

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R334

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R421

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R335

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R422

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R335

0RJ2003E472

"Resistor,Chip" 0805S8F2003T5E 200KOHM

R423

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R339

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R424

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R341

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R425

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R342

0RJ1201C678

"Resistor,Chip" MCR01MZPJ122 1.2KOHM 5

R426

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R343

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R427

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R344

0RJ1201C678

"Resistor,Chip" MCR01MZPJ122 1.2KOHM 5

R428

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R345

0RH1003D422

"Resistor,Chip" MCR10EZHF104 100KOHM 1

R429

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R345

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R430

0RJ4701C678

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

- 44 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R431

0RJ4701C678

R432

0RJ4701D677

R433

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR01MZPJ472 4.7KOHM 5

R494

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R495

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R496

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R434

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R497

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R435

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R498

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R436

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R499

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R437

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R501

0RJ2203C678

"Resistor,Chip" MCR01MZPJ224 220KOHM 5

R438

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

R501

EBC01875202

"Resistor,Chip" 1206W8J0244T5E 240KOHM

R439

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

R502

0RJ2203C678

"Resistor,Chip" MCR01MZPJ224 220KOHM 5

R440

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

R502

EBC01875202

"Resistor,Chip" 1206W8J0244T5E 240KOHM

R441

0RJ4703D677

"Resistor,Chip" MCR03EZPJ474 470KOHM 5

R503

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R442

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R503

EBC01875202

"Resistor,Chip" 1206W8J0244T5E 240KOHM

R443

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R504

0RH7503D622

"Resistor,Chip" MCR10EZHJ754 750KOHM 5

R444

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R504

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R445

0RJ1501D677

"Resistor,Chip" MCR03EZPJ152 1.5KOHM 5

R505

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R446

0RJ1501D677

"Resistor,Chip" MCR03EZPJ152 1.5KOHM 5

R505

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R447

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R506

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R448

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R506

0RJ0752D677

"Resistor,Chip" MCR03EZPJ750 75OHM 5%

R449

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R507

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R450

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R507

0RJ6802E472

"Resistor,Chip" MCR10EZHF6802 68KOHM 1

R451

0RJ2001D677

"Resistor,Chip" MCR03EZPJ202 2KOHM 5%

R508

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R452

0RJ2402D677

"Resistor,Chip" MCR03EZPJ243 24KOHM 5%

R509

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R453

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R509

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R454

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R510

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R455

0RJ0432D677

"Resistor,Chip" MCR03EZPJ430 43OHM 5%

R511

0RH4701D622

"Resistor,Chip" MCR10EZHJ472 4.7KOHM 5

R456

0RJ1501D677

"Resistor,Chip" MCR03EZPJ152 1.5KOHM 5

R511

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R457

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R512

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R461

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R513

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R462

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R513

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R463

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R514

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R464

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R514

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R465

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R515

0RH4701D622

"Resistor,Chip" MCR10EZHJ472 4.7KOHM 5

R466

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R516

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R468

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R517

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R469

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R517

EBC01875202

"Resistor,Chip" 1206W8J0244T5E 240KOHM

R470

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R520

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R474

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R521

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R475

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R522

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R476

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R523

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R477

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R527

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R478

0RJ4703C678

"Resistor,Chip" MCR01MZPJ474 470KOHM 5

R528

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R479

0RJ4703C678

"Resistor,Chip" MCR01MZPJ474 470KOHM 5

R529

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R480

0RJ1501C678

"Resistor,Chip" MCR01MZPJ152 1.5KOHM 5

R530

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R481

0RJ1501C678

"Resistor,Chip" MCR01MZPJ152 1.5KOHM 5

R531

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R482

0RJ3301C678

"Resistor,Chip" MCR01MZPJ332 3.3KOHM 5

R532

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R483

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R533

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R484

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R535

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R485

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R536

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R486

0RJ0331D677

"Resistor,Chip" MCR03EZPJ3R3 3.3OHM 5%

R537

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R488

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R538

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R489

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R539

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R490

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R540

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R491

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R541

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R492

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R542

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

R493

0RJ0561D677

"Resistor,Chip" MCR03EZPJ5R6 5.6OHM 5%

R543

0RJ1000C678

"Resistor,Chip" MCR01MZPJ101 100OHM 5%

- 45 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R552

0RJ1001C678

R553

0RJ0222C678

R554

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R644

0RJ1502C678

"Resistor,Chip" MCR01MZPJ153 15KOHM 5%

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R645

0RJ1502C678

"Resistor,Chip" MCR01MZPJ153 15KOHM 5%

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R646

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R555

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R647

0RJ1001C678

"Resistor,Chip" MCR01MZPJ102 1KOHM 5%

R556

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R648

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R557

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R701

0RH0471D622

"Resistor,Chip" MCR10EZHJ4R7 4.7OHM 5%

R562

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R701

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R563

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R702

0RH2700D622

"Resistor,Chip" MCR10EZHJ271 270OHM 5%

R565

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R703

0RH2201D622

"Resistor,Chip" MCR10EZHJ222 2.2KOHM 5

R600

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R703

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R601

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R704

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R601

0RJ4703G676

"Resistor,Chip" MCR18EZHJ474 470KOHM 5

R705

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R602

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R706

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R602

EBC01890804

"Resistor,Chip" 1206S4J0434T5E 430KOHM

R707

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R603

0RJ4703G676

"Resistor,Chip" MCR18EZHJ474 470KOHM 5

R707

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R604

0RH9101D622

"Resistor,Chip" MCR10EZHJ912 9.1KOHM 5

R708

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R605

0RH6802D622

"Resistor,Chip" MCR10EZHJ683 68KOHM 5%

R709

0RH0332D622

"Resistor,Chip" MCR10EZHJ330 33OHM 5%

R606

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R710

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R607

0RH3302L422

"Resistor,Chip" MCR10EZHF333 33KOHM 1%

R711

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R609

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R712

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R610

0RJ0222E421

"Resistor,Chip" MCR10EZHF22R0 22OHM 1%

R712

0RH0332D622

"Resistor,Chip" MCR10EZHJ330 33OHM 5%

R611

0RH6203D622

"Resistor,Chip" MCR10EZHJ624 620KOHM 5

R713

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R612

0RH6203D622

"Resistor,Chip" MCR10EZHJ624 620KOHM 5

R713

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R613

0RH6203D622

"Resistor,Chip" MCR10EZHJ624 620KOHM 5

R714

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R614

0RH6203D622

"Resistor,Chip" MCR10EZHJ624 620KOHM 5

R714

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R616

0RH0000D622

"Resistor,Chip" MCR10EZHJ000 0OHM 5% 1

R715

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R617

0RH1602D422

"Resistor,Chip" MCR10EZHF163 16KOHM 1%

R715

0RH2700D622

"Resistor,Chip" MCR10EZHJ271 270OHM 5%

R618

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R716

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R618

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R716

0RH2201D622

"Resistor,Chip" MCR10EZHJ222 2.2KOHM 5

R619

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R717

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R619

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R717

0RH1001D622

"Resistor,Chip" MCR10EZHJ102 1KOHM 5%

R620

0RH4702D622

"Resistor,Chip" MCR10EZHJ473 47KOHM 5%

R718

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R620

0RJ4703C678

"Resistor,Chip" MCR01MZPJ474 470KOHM 5

R719

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R621

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R719

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R621

0RJ0752C678

"Resistor,Chip" MCR01MZPJ750 75OHM 5%

R720

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R622

0RH1000D622

"Resistor,Chip" MCR10EZHJ101 100OHM 5%

R722

0RH0202D622

"Resistor,Chip" MCR10EZHJ200 20OHM 5%

R622

0RJ4703C678

"Resistor,Chip" MCR01MZPJ474 470KOHM 5

R723

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R623

0RH0102D622

"Resistor,Chip" MCR10EZHJ100 10OHM 5%

R724

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R623

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R725

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R624

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R726

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R625

0RH4702D622

"Resistor,Chip" MCR10EZHJ473 47KOHM 5%

R727

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R625

0RJ3901D677

"Resistor,Chip" MCR03EZPJ392 3.9KOHM 5

R728

0RJ0562D677

"Resistor,Chip" MCR03EZPJ560 56OHM 5%

R626

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R729

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R627

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R730

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R629

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R731

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R630

0RH2001D622

"Resistor,Chip" MCR10EZHJ202 2KOHM 5%

R732

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R630

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R733

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R631

0RH1002D622

"Resistor,Chip" MCR10EZHJ103 10KOHM 5%

R736

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R631

0RJ1001D677

"Resistor,Chip" MCR03EZPJ102 1KOHM 5%

R737

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R632

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R744

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R639

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R745

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R640

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R746

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R641

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R747

0RJ0512C678

"Resistor,Chip" MCR01MZPJ510 51OHM 5%

R642

0RJ0342D477

"Resistor,Chip" MCR03EZPF34R0 34OHM 1%

R748

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R643

0RJ0342D477

"Resistor,Chip" MCR03EZPF34R0 34OHM 1%

R749

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

- 46 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R750

0RJ4701D677

R751

0RJ4701D677

R752

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R831

0RJ0152D677

"Resistor,Chip" MCR03EZPJ150 15OHM 5%

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R832

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

0RJ4701D677

"Resistor,Chip" MCR03EZPJ472 4.7KOHM 5

R832

0RJ0152D677

"Resistor,Chip" MCR03EZPJ150 15OHM 5%

R753

0RJ4700D677

"Resistor,Chip" MCR03EZPJ471 470OHM 5%

R834

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R754

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R835

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R755

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R836

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R756

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R837

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R757

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R838

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R758

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R839

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R759

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R840

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R767

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R841

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R768

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R842

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R771

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R843

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R773

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R844

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R780

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R845

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R781

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R846

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R782

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R847

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R783

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R848

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R784

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R849

0RJ0332C678

"Resistor,Chip" MCR01MZPJ330 33OHM 5%

R785

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R850

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R786

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R851

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R789

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R852

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R790

0RJ1002D677

"Resistor,Chip" MCR03EZPJ103 10KOHM 5%

R853

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R795

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R854

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R798

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R855

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R799

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

R856

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R800

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R857

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R802

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R859

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R804

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R860

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R805

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R861

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R806

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R862

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R807

0RJ1000D677

"Resistor,Chip" MCR03EZPJ101 100OHM 5%

R863

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R808

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R864

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R809

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R865

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R810

0RJ3301C678

"Resistor,Chip" MCR01MZPJ332 3.3KOHM 5

R866

0RJ0332D677

"Resistor,Chip" MCR03EZPJ330 33OHM 5%

R811

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R867

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R812

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R868

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R813

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

R869

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R814

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

R870

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R815

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

R871

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R816

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R872

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R817

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R873

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R819

0RJ1201D677

"Resistor,Chip" MCR03EZPJ122 1.2KOHM 5

R874

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R820

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R875

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R821

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R876

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R822

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R877

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R823

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R878

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R824

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R879

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R825

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

R880

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R826

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R881

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R827

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R882

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R828

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R900

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R829

0RJ2701D677

"Resistor,Chip" MCR03EZPJ272 2.7KOHM 5

R902

0RJ1002C678

"Resistor,Chip" MCR01MZPJ103 10KOHM 5%

R830

0RJ2701D677

"Resistor,Chip" MCR03EZPJ272 2.7KOHM 5

R904

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

R831

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

R905

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

- 47 -

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

R906

0RJ0000D677

R907

0RJ0000D677

R908

DESCRIPTION / SPECIFICATION

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

X1300

6212AB2872A

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

X1301

6212AB2883A

Crystal HC-49SM 27.00000MHZ 27

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

X1303

EAW39040101

Crystal 9H03200584 32.768KHZ 2

R909

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

X1500

6212AB2883A

Crystal HC-49SM 27.00000MHZ 27

R910

0RJ0222C678

"Resistor,Chip" MCR01MZPJ220 22OHM 5%

X400

6202VDT002H

Crystal SX-1 18.432MHZ 30PPM(1

R911

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

X401

6202VDT002H

Crystal SX-1 18.432MHZ 30PPM(1

R912

0RJ0222D677

"Resistor,Chip" MCR03EZPJ220 22OHM 5%

X501

EAW39040101

Crystal 9H03200584 32.768KHZ 2

R914

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

X700

6212AB2015J

Crystal HC-49SM 19.66080HZ 19.

R915

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

P101

430-858C

Fuse Holder 250V 10A 5x4.5mm T/REE

R916

0RJ0000D677

"Resistor,Chip" MCR03EZPJ000 0OHM 5% 1

P102

430-858C

Fuse Holder 250V 10A 5x4.5mm T/REE

R917

0RJ0000C678

"Resistor,Chip" MCR01MZPJ000 0OHM 5% 1

P701

430-858C

Fuse Holder 250V 10A 5x4.5mm T/REE

R919

0RJ1202D677

"Resistor,Chip" MCR03EZPJ123 12KOHM 5%

P702

430-858C

R920

0RJ1302D677

"Resistor,Chip" MCR03EZPJ133 13KOHM 5%

F100

0FS8001B53B

R923

0RJ2700C678

"Resistor,Chip" MCR01MZPJ271 270OHM 5%

F700

0FZZTTH001B

"Fuse,Time Delay" 0215 005(SEMKO/VDE) CE

R934

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

O1

EAZ39110001

HDD HD081GJ 3.5INCH 80.0GB

R935

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

J101

6612J10033A

"Jack,Complex" PMJ016-13 13P DIN/RCA

R936

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK1200

6612B00015B

"Jack,DIN" DC1R019WDH SOCKET 21P

R937

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK1201

6612B00015B

"Jack,DIN" DC1R019WDH SOCKET 21P

R938

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK501

6612F00099A

"Jack,Phone" PEJ024-01 1P 4P STRAIG

R939

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK102

6612J10031A

"Jack,RCA" PPJ209-02 14.0MM 1RX5C

R940

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK103

6612J10031A

"Jack,RCA" PPJ209-02 14.0MM 1RX5C

R941

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK104

6612J10003Y

"Jack,RCA" PPJ216-01 14.0MM 1RX3C

R942

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK105

6612J10003M

"Jack,RCA" PPJ206-01 14.0MM 1RX3C

R943

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

JK400

6612J10043A

"Jack,RCA" PPJ200-07 15MM 1RX4C A

R944

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

LD1003

0DL233309AC

"LED,Chip" SAM2333 RED/Y-GREEN 2.

R945

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

LD1104

0DL233309AC

"LED,Chip" SAM2333 RED/Y-GREEN 2.

R946

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

LD1301

0DL233309AC

"LED,Chip" SAM2333 RED/Y-GREEN 2.

R947

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

LD1302

0DL233309AC

"LED,Chip" SAM2333 RED/Y-GREEN 2.

R948

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

D101

0DLBE0138AA

"LED,DIP" BL-BUBGE301 ROUND 3MM

R949

0RJ0682C678

"Resistor,Chip" MCR01MZPJ680 68OHM 5%

PC130

EAV32556601

"Photo,Coupler" PS2571L1-1-V-A 6V 40V

Crystal HC49SM 25MHZ 50PPM 20p

Fuse Holder 250V 10A 5x4.5mm T/REE


"Fuse,Time Delay" 215008 CERAMIC 250V 8A

R952

0RJ2700C678

"Resistor,Chip" MCR01MZPJ271 270OHM 5%

PC150

EAV32556601

"Photo,Coupler" PS2571L1-1-V-A 6V 40V

TH301

0RJ1002E472

"Resistor,Chip" MCR10EZHF103 10KOHM 1%

PC200

EAV32556601

"Photo,Coupler" PS2571L1-1-V-A 6V 40V

R100

0RKZVTA001D

"Resistor,Metal Film" RN-92T1J10M0 10MOHM 5%

PC500

EAV32556601

"Photo,Coupler" PS2571L1-1-V-A 6V 40V

R101

0RKZVTA001N

"Resistor,Metal Film" MGR0U2J0754A40 750KOHM

IC1306

SAA31073303

"S/W,Firmware" 3.07 7B70 EUROPE FLASH

R116

EBC01377802

"Resistor,Metal Oxide Film" MOR03SJ0393BMF 39KOHM

IC900

SAA31073109

"S/W,Firmware" 3.05 6318 EUROPE FLASH

R222

0RS0102K619

"Resistor,Metal Oxide Film" SML02R0J10R0 10OHM 5%

IC506

EBD38015101

R223

0RS0102K619

"Resistor,Metal Oxide Film" SML02R0J10R0 10OHM 5%

SW101

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R224

0RS3900K619

"Resistor,Metal Oxide Film" SML02R0J390R 390OHM 5%

SW102

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R225

0RS3900K619

"Resistor,Metal Oxide Film" SML02R0J390R 390OHM 5%

SW103

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R226

0RS2201K607

"Resistor,Metal Oxide Film" RSD02T3J2K20 2.2KOHM 5

SW104

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R227

0RS0102K619

"Resistor,Metal Oxide Film" SML02R0J10R0 10OHM 5%

SW105

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R406

EBC01285802

"Resistor,Metal Oxide Film" MOR02SJ0680A1P 68OHM 5

SW106

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R407

EBC01285802

"Resistor,Metal Oxide Film" MOR02SJ0680A1P 68OHM 5

SW107

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R414

EBC01285802

"Resistor,Metal Oxide Film" MOR02SJ0680A1P 68OHM 5

SW108

140-313B

"Switch,Tact" KPT-1115AM 1C1P 12VDC

R415

EBC01285802

"Resistor,Metal Oxide Film" MOR02SJ0680A1P 68OHM 5

SW1300

6600VR1004A

"Switch,Tact" SKHMPWE010 1C1P 12VDC

R508

0RX0221J609

"Resistor,Metal Oxide Film" RSD01T1J2R20 2.2OHM 5%

SW700

6600VR1004A

"Switch,Tact" SKHMPWE010 1C1P 12VDC

R510

EBC01414102

"Resistor,Metal Oxide Film" MOR0S2J0220A50 22OHM 5

SW900

6600VR1004A

"Switch,Tact" SKHMPWE010 1C1P 12VDC

R516

0RX4702K607

"Resistor,Metal Oxide Film" RSD02T3J47K0 47KOHM 5%

TH600

EBG36689101

"Thermistor,NTC" 15D2-15 15OHM 20% 275V

R120

EBC36677701

"Resistor,Wire Wound" KNP02SJ033KA1P 0.33OHM

TH601

EBG36689101

"Thermistor,NTC" 15D2-15 15OHM 20% 275V

R512

EBC36677501

"Resistor,Wire Wound" KNP01SJ068KA1P 0.68OHM

T701

EBJ39717003

"Transformer,high voltage" 2130KP0179B-F UU3356 4

R615

EBC36681701

"Resistor,Wire Wound" KNP02SJ090LA10 0.11OHM

T702

EBJ36780101

"Transformer,Linear" 2130KK0081A-F UU1116S

R627

EBC36681701

"Resistor,Wire Wound" KNP02SJ090LA10 0.11OHM

T101

EBJ36781401

"Transformer,Switching" 2130KP0171A-F EER3124N

T501

EBJ36781801

"Transformer,Switching" 2130KP0174A-F EE2525W

TU200

EBL35311205

"Tuner,Tuner/Modulator" TAUT-H001F NTSC 55.25M

TU201

EBL35311209

"Tuner,Tuner/Modulator" TAFT-H004P NTSC 55.25M

OTHERs
X1200

6202TST001H

Crystal SX-1 27MHZ 30PPM 27MHZ

- 48 -

"Sensor,Temperature" MM3286CFBE 0.3~3.6 SOP

LOC. NO.

PART NO.

DESCRIPTION / SPECIFICATION

LOC. NO.

VR301

180-F03L

"Variable Resistor,Semifixed" EVNDJAA03B15 100KOHM 1

VR302

180-F03D

"Variable Resistor,Semifixed" EVNDJAA03B13. 1KOHM 30

CONNECTOR
C11

EAD35132605

"Cable,Assembly" SATA CABLE 250MM SATA

C8

68509A0004J

"Cable,Assembly" RCA JACK RCA JACK 0.15

JK500

6630TGA004K

"Connector,DSUB" KCN-DS-1-0089 D-SUB 15

JK502

6630G00001C

"Connector,DSUB" KCN-DS-1-0088 D-SUB 9P

P1000

6602T25008M

"Connector,Wafer" SMW250-13P 13P 2.50MM

P101

6602T20009C

"Connector,Wafer" SMAW200-04P 4P 2.00MM

P101

6602T20009J

"Connector,Wafer" SMAW200-10P 10P 2.00MM

P102

6602T20009C

"Connector,Wafer" SMAW200-04P 4P 2.00MM

P102

6602T20009N

"Connector,Wafer" SMAW200-14P 14P 2.00MM

P104

6602T25009B

"Connector,Wafer" SMAW250-03P 3P 2.50MM

P105

6602T20009D

"Connector,Wafer" SMAW200-05P 5P 2.00MM

P1100

6602T25008J

"Connector,Wafer" SMW250-10P 10P 2.50MM

P1300

6602Q39005A

"Connector,Wafer" 1-1123723-4 4P 3.96MM

P1302

6630U60039A

"Connector,Wafer" 184-0207100-71 7P 1.27

P1305

6602T20008C

"Connector,Wafer" SMW200-04P 4P 2.00MM 1

P1500

6602T20008C

"Connector,Wafer" SMW200-04P 4P 2.00MM 1

P201

6630V90209M

"Connector,Wafer" TJC2508-13A 13P 2.5MM

P202

6630V90209J

"Connector,Wafer" TJC2508-10A 10P 2.5MM

P203

6630V90209L

"Connector,Wafer" TJC2508-12A 12P 2.5MM

P205

6630V90220C

"Connector,Wafer" TJC2004-4A 4P 4.0MM 1R

P400

6602T25008B

"Connector,Wafer" SMW250-03P 3P 2.50MM 1

P401

6602T25008C

"Connector,Wafer" SMW250-04P 4P 2.50MM 1

P401

EAG36440901

"Connector,Wafer" 35002WS_02L 2P 3.50MM

P402

EAG36440901

"Connector,Wafer" 35002WS_02L 2P 3.50MM

P501

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

P502

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

P600

6630V90116A

"Connector,Wafer" FI-X30SSL-HF 30P 1.00M

P601

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

P602

6602T20008J

"Connector,Wafer" SMW200-10P 10P 2.00MM

P602

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

P603

6602T20009N

"Connector,Wafer" SMAW200-14P 14P 2.00MM

P603

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

P604

6602T20008D

"Connector,Wafer" SMW200-05P 5P 2.00MM 1

P604

EAG38502901

"Connector,Wafer" TBD 2.36*11.8 1P NONE

SC100

366-164A

"Connector,Wafer" YW396-03AV 3P 3.96MM 1

C1

6631900012C

"Harness,Single" SMH250 SMH250 200mM 2.

C10

EAD30302101

"Harness,Single" 10P SHIELD DMS CONNECT

C12

EAD35683002

"Harness,Single" LVDS LPL STANDARD FI-X

C13

EAD35908101

"Harness,Single" 35001HS-02L 65002HS-03

C14

EAD35908402

"Harness,Single" High Power cable(UL PV

C15

EAD35983001

"Harness,Single" 12507HS-04L SMH200 500

C16

EAD36175201

"Harness,Single" SMH200 SMH200 800MM 2.

C2

6631900027C

"Harness,Single" SMH250 SMH250 200mM 2.

C3

6631900048E

"Harness,Single" SMH200 SMH200 300mM 2.

C4

6631900050C

"Harness,Single" SMH200 SMH200 1200mM 2

C5

6631900097F

"Harness,Single" YEONHO)SMH250 35097/35

C6

6631900098F

"Harness,Single" SMH250 35097/35098 120

C7

6631T20037B

"Harness,Single" 14P SHIELD WIRE SMH200

C9

6851V00080A

"Harness,Single" 1537740-1 1537113-2 1-

- 49 -

PART NO.

DESCRIPTION / SPECIFICATION

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

LGE Internal Use Only

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

LGE Internal Use Only

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

LGE Internal Use Only

Copyright 2007 LG Electronics. Inc. All right reserved.


Only for training and service purposes

LGE Internal Use Only

You might also like