You are on page 1of 1

Total Hardness Water Based Mud Testing

The total hardness test gives an indication of the level of soluble Calcium and Magnesium ions present in the mud.
Such ions are considered detrimental since, under conditions of high pH (>11.5), they may render polymer, treatments for viscosity and fluid loss less
effective.
High levels of hardness will also flocculate Bentonite.
The total hardness should be controlled below 400 mg/L and must not be allowed to rise above 600 mg/L.
Reporting
Total Hardness is usually expressed in mg/l CaCo3.
Sources of Error
Can be difficult to see the end point of the test.
Total hardness is reported as mg/L CaCO3. Multiply this value by 2.5 to get the required value.
Magnesium hardness can be calculated by subtracting the Calcium hardness value from the total hardness. This is common practice but ignores the fact
that Magnesium has a higher atomic weight than Calcium. However, errors are small.

You might also like