SERIES 60 SERVICE MANUAL All information subject to change without notice. 2-24 From Bulletin 28-60-98 6SE483 9610 (c) 1996 DETROIT DIESEL CORPORATION.
SERIES 60 SERVICE MANUAL All information subject to change without notice. 2-24 From Bulletin 28-60-98 6SE483 9610 (c) 1996 DETROIT DIESEL CORPORATION.
SERIES 60 SERVICE MANUAL All information subject to change without notice. 2-24 From Bulletin 28-60-98 6SE483 9610 (c) 1996 DETROIT DIESEL CORPORATION.
6SE483 9610 1996 DETROIT DIESEL CORPORATION From Bulletin 28-60-98 2-23 12. Install the EUI terminal wires by positioning the keyhole in the terminal over the screw in the injector solenoid housing. Pull the terminal end down so that the screw rests in the smaller slot in the terminal. Tighten the terminal screws to 1.08-1.13 N m (9.5-10.0 lb in.). Do not bend the terminals down after installation. See Figure 2-12. Figure 2-12 Electronic Unit Injector Terminal Installation 2.2 ELECTRONIC UNIT INJECTOR All information subject to change without notice. 2-24 From Bulletin 28-60-98 6SE483 9610 1996 DETROIT DIESEL CORPORATION 13. Install the rocker arm shafts, with rocker arms in place. Refer to section 1.3.3. NOTE: Front and rear rocker shaft assemblies look identical but are not interchangeable due to different bolt hole center distances. The outboard end of each rocker shaft assembly is marked with the DDC logo for identification. Care should be taken to identify and return assemblies to the proper location if both overhead assemblies were removed. 14. Adjust the intake and exhaust valve clearances and injector height. Refer to section 12.2. 15. Install the inlet and outlet fuel lines to the fittings at the rear of the cylinder head. See Figure 2-6. 16. On DDEC III engines, record the injector calibration code from the load plate with the proper cylinder location. 17. Install the valve rocker cover. Refer to section 1.6.7. 18. For one-piece valve rocker cover, refer to section 1.6.8. For two-piece and three-piece valve rocker cover, refer to section 1.6.9. 19. Verify repair of electronic unit injector, refer to section 11.8.