Rev. 4 10/06 DTM Enterprises Technical Training Division Page 1 of 1
281-330-9542 www.DTM-Enterprises.org Class Quiz # 30 1. If a welder qualified on a NPS 6 inch pipe coupon the range of diameter qualifications in production with the WPS he tested to will be _________. 2. If tested with a NPS 2 inch coupon what is his minimum and maximum diameter range is ________. 3. How can we qualify a welder for unlimited thickness with both F-No.3 and 4 in a single coupon?
Class Quiz # 31 1. How can we qualify a welder for unlimited thickness with both F-No.3 and 4 in a single coupon? * Hint See Note 1 of table QW-452.1(b) If he welds a coupon that is at least ___ thick and deposits at least___ of E-6010 and at least ___ of E-7018 using a minimum of ____ layers of each filler metal.
Class Quiz # 32 1. A welder performs a test on a NPS 4 (4.5) pipe coupon in the 6G position. The coupon is Schedule 160 and has a wall T of 0.531. The welder will use SMAW with E-6010 for the root pass for a total weld deposit t of .125 (1/8). The balance of the weld deposit t (.406) will be performed using 3 weld layers of E-7018 filler metal. All welding will be uphill during the test. His qualifications as listed in table QW-353 are?
The test qualifies ___ positions with a minimum diameter of ______ and a maximum of _______. The test also qualifies the welder to deposit ___ inches of F- No. 3 and ____inches of F-No.4. The welder will also be qualified to weld _____or _______backing. The thickest weld he can make using this combination in production is__________. The welders production welds must made using _______ progression.