ASIAPHIL
Robie MVSG switchgear is available in one or more vertical section assemblies to provide
safe, low-cost switching and circuit protection where occasional or infrequent
disconnecting means is desired. The three-pole switch, with the quick-make, quick-break
mechanism, will interrupt its rated load current. Optional fuses can assure short-circuit
protection atall times.
Contact Us:
ASIAPHIL Head Office
1150 Pres. Quirino Ave
Extension, Paco, Manila
Philippines 1007
Tel, Nos. +63 2 5638338 to 42
Fax No. +63 2 5632529
Email: write@asiaphil.com
Website : www.asiaphil.comROBIE MVSG metal-onciosed switchgear provides economical and reliable circuit switching and fault protection for medium-voltage circuits of 5k
‘15kV and 36kV, ROBIE is ideal for applications where load interrupter switches should not be applied, such as ground fault protection, high duty cyc
applications, or high speed automatic transfers.
Itis also a better engineering alternative than load interrupter switches for applications involving shunt tripping, single phase progection, capaci
‘switching, and ground protection
ROBIE MVSG switchgear can also be an economic benefit in single enced substations since it may allow the customer to eliminate the seconda
main protection and switching device.
Robie MVSG Switchgear can be applied for many switching duties whether manual, motor operated or automatic
operation is specified:
1, Transformer Primary Switching 3. Power Distribution Switching
2. Transformer Secondary Switching 4. Switching at Unit Distribution
1. AUXILLIARY AND AC/DC PANELS ECTION - comprises of cable compartment, busbarring and wiring
assembly, and AC/DC Panel withvAC/DC Voltmeter and Ammeter.
2, FEEDER BREAKER SECTION - includes circuit breaker control switch, pilot lights, post insulators, mets, GT, and VOB (2
feeder per vertical section)
3. CONTROL & PROTECTION PANEL SECTION - includes meters, protection relayswanfilifelator, pilot lights buzzer, lock out
relay, check back switch, position indicator, trip counter, control relays, CT/PIET fest blocks and MCB control protection:
4. Automatic Battery Charger - input voltage is 220Vac, single tial output voltage is 125Vde, Normal capacity of 10Amps
5. Distribution Transformer, 10kVA, conventionabpoléltype, 7620/13200Y volls primary, 120/240 volts secondary, single phase,
2-HV bushing, 3-LV terminals sporeelai Bushing, with 2-2.5% taps below and above normal operating voltage, 95kV BIL
primary, 30k\BilsseeBridery.
6: Battery, 12Vdc per cell maintenance free 65Amp / hr lead acid
7. UNAMVA Outdoor Kiosk - 2500mmHx20 Footer x 2400mmD Outdoor NEM 3R Container Van enclosure.36 kV MVSG MERALCO DESIGN
TRANSPORT
Robie MVSG
115kV ~ 34.5k
115kV ~ 34.5k
45kV MVSG, |
15kV MVSG, (
Technical Spe
Standards: IE¢
Cubicle Type:
Voltage Rating
Busbar Curren
Degree of Prot
af]
!
1
1
1 1 t
!
|
1ALCO DESIGN
or Substation
joor Substation
‘pplication
“Application
ions:
1-200
CLAD-LSC2B-PM
/34.5kV
A
IP45
36 kV MVSG MERALCO DESIGN (COMPLETE PACKAGE)1. All Switchgear are Versa Modular System (VMS) design structures. BI sheet
Ga#14 for frames and Ga#16 for the enclosure element base on the non-welded
framework construction for free-standing panel.
2. Enclosure are clean with advance metal treatment process (Degreasing,
Derusting, Metal Conditioning and Zinc Phosphating). Powder coated oven baked fi
outdoor/indoor use.
3. Uses 99.99% copper busbar of strength E-CuF30, silver plated bolted @ joint wit
heat shrinkable-tube rigidly supported by track resistance Polyester Glass Resin bu
support.
4. SCADA ready with new rigid and distribution code complaint.
5. Current Transformer is toroidal type, relaying and metering class 50-400Hz, 10k
BIL full wave.
6. Voltage Transformer has a voltage class of 110kV BIL 0.3WXMYZ.
7.Control Voltage for the VCB and SF6 Circuit Breaker is 125Vdc.
MEDIUM VOLTAGE SWITCHGEAR RATED 36kV
‘APPLICABLE FOR EITHER INDOOR OR OUTDOOR ENCLOSURE
ee RATING ENCLOSURE
DRAW-OUT FIXED
630 | 1250 | INDOOR | OUTDOOR
CB v 7 v v v v
SF6 v Fa v v ZA v
LBs =i | enya | v x | ¥
MEDIUM VOLTAGE SWITCHGEAR RATED SkV/15kV/24kV
[APPLICABLE FOR EITHER INDOOR OR OUTDOOR ENCLOSURE
7
onorecion re
1 MaIn |FEEDER| TIE |SINGLEHIGH TWOHIGH | DRAw-ouT| FIXED |
620 | 1250 f2000rs
(vce es Zz ¥ Lz z Z Z a 73
iste v v z aja a v ze i
tes vs =7r ee a | cee | OE x tx)
NOTES:
1. SF6 or VCB are either Fixed or Drawout Type
2. SF6 or VCB (5 or 15KV) can either be Single high or two high configurations
3. SF6 or VCB (5/15KV) can either be used as either MTS
(Using Kirk Key mechaincal interiock) or ATS (Using an inteligent circuit)ASIAPHIL ELECTRIC
GROUP
focuses in the manufacturing andlor
assembly of electrical distribution
equipment.
‘AE capabilty was established in 1973
carrying over 40 year ~ expertise of its
founding company Asiaphil Manufacturing
Industries, Inc, (AMII) from which the
flagship product was its Panel boards.
‘AE has advanced its potential by not only
producing panel boards but an extensive
Tine of electrical equipment up to 36KV
applications. Engineering and production
processes were eystematized in sucha way
that itcan be adaptable to adhere to either
IECorANS! standards,
‘AE has sold its products not only in the
Philippines but also in Hong Kong,
Indonesia, Thailand, Guam, Germany, and
the United States. It ‘supplies the
requirements of top corporations, including
those in vital industries that demand the
highest quality and strictest specifications.
1, ROBIE Medium Voltage Switchgear
2. BEA IEC Type-Tested
Low Voltage Switchgear
3. BEA IEC Type-Tested
Motor Control Center
4, ALDO Capacitor Banks
5. ASIAPHIL Control
and Protection Panel
6. ASIAPHIL Auto/Manual
Transfer Switch
7. ASIAPHIL Distribution Boards
8. ASIAPHIL Synchronizing Panel
9. ASIAPHIL Loose Controllers
10. ASIAPHIL Busducts
ASTAPHIL
ASIAPHIL
Lot 10 & 12 Block 3 Angeles, Industrial Park,
Calibutbut, Bacolor, Pampanga, Philippines
Tel: (045) 598-0017 | Fax: (045) 636-6517
Lot 2582 San Antor
Sto. Tomas, Batangas, Philippi
Telefax: (043) 430-11