Professional Documents
Culture Documents
of door templates to
fit Woodhavens 5434
Frame & Panel Master
We cannot quarantee that this will work on all brands of templates. You
will need to drill mounting holes where shown on your panel templates. The drilling
dimension of 3 shown for the rail templetes may vary depending on your templates,
the desired overall part width and your straight rail width. For example, our templates
below have a 1-3/4 rise and an overall rail part width of 4, leaving the rail 2-1/4 wide
at the narrowest point. If your templates have a 1-1/2 rise and you drilled your rail
templates using the 3 dimension, youd end up with a rail that measures 2-1/2 wide
at the narrowest point.
If 2-1/2 is wider than desired, the easiest solution would be to rip the rail
narrower after machining the contour. Another solution would be to change the 3
dimension to something less. To get a rail thats 2-1/4 wide at the narrowest point
with 1-1/2 rise templates, you would need to change the 3 dimension to 2-3/4. Then
you would need to be sure that there was not more than 1 of template overhang on
the back to be able to use your template on our 5434 Frame & Panel Master.
3
0.5
1.25
1.25
1.25
6-7 Parts
14-16 Parts
16-18 Parts
7.625
15.625
17.625
5-6 Parts
7-8 Parts
10-11 Parts
12-14 Parts
6.625
8.625
11.625
13.625
8-9 Parts
9-10 Parts
11-12 Parts
9.75
10.625
12.625
1.25
1.25
1.25