You are on page 1of 3

1.

Rectifier employing op-amp to eliminate diode drop______


Passive Circuit
Active Circuit
Saturation Circuit
Non Saturation Circuit
2. Fourier Transform imposes _______ parity for Fourier cosine
Even
Odd
Negative
Zero
3. In cathode ray oscilloscope, vertical section in volt/division and horizontal
section is calibrated in
Current/division
Resistance/Division
Time/Division
Frequency/Division
4. By reducing the impedance between stations, adoption of quick response
excitation system and series capacitors to make X=(3R) 1/2, what we can
improve in overhead transmission lines.
Reduction in line transients
Reduction in line losses
Steady State Stability
Smooth
Distribution up to house hold
5. The sampling rate must be at least _______ bandwidth of the signal or else
there will be distortion.
Equal
Twice
Thrice
Four
Five
6. The output voltage of op-amp is defined as Vout=_____
7. The probability during a given time interval, the system wide power resource
with fall short of demand is _______
Expected unserved energy
Outage Frequency and outage
duration
Loss of load expectation
Loss of Load Probability
None
8. Real Power
Measure of Sinewave Amplitude
Power Oscillation
Mathematically average instantaneous
Geometric Sum of amp
9. In close loop control system
Feedback Strategy
Input Dependent
Fail Sage
Error Driven
A&B
10.As a result of discrete Fourier transform, we achieve discrete Fourier
transform for discrete time signal
Discrete Fourier Spectrum for discrete time signal
Discrete Fourier spectrum for continuous time signal
Continuous Fourier spectrum for discrete time signal
Continuous Fourier spectrum for continuous time signal
11.Pi Method
Capacitance and Reactance can be localized at receiving end.
Capacitor is at receiving while reactance be lumped at sending end.
Whole line capacitance is assumed to be at middle point of line and half line
resistance and reactance are lumped at its either side.
Line to neutral capacitance is divided into two halves
12.In addition to applying Kirchhoffs laws and scaling circuits up or down, a third
analysis tool is based on superposition theorem. This principal applies to
circuits with _______
Single Voltage Source
More than one voltage source
More than one voltage or current source
One current source

13.When induction motor is switched on, rotation is caused by


Rotating magnetic field
Excitation Voltage applied to
rotor
Rate of change of voltage in stator
Differential current
14.Coal fired 1000MW over 3 million tons, nuclear 1000MW(UO2) full range of
30-35 tons only.
15.Impedance through which only negative sequence current flow is called
as____
Negative sequence impedance
Positive sequence impedance
Zero sequence impedance
Inverse sequence impedance
Converse sequence impedance
16.In power system with multiple turbine generator if a big load is suddenly lost,
all the generator______
Speed increases, frequency increases
Speed decreases, frequency
decreases
Suddenly have to add large additional load Some load must be dropped
17.The stability of dynamic system having no input is described with _______
PID controller
Harold S block mode
Lyapunov Stability
Power formula
18.In closed loop system, input is _______ output
19.The asymptotic stability of a system is defined by its
Eigen values
Poles and Zeroes
Response to impulse input
None
20.In case of pseudo noise sequence, their auto correlation properties are similar
to that of ______
Random atmospheric Interference
White Noise
Ground Emitter
Audio Distortion
21.Wavelength of EM waves after reflection at an angle on surface
Increases in actual direction
Decreases in actual direction
Remain same
Remain same in free space
22.RC snubber circuit is used to limit the rate of ______ in its off state.
Rise of current in SCR
Rise of voltage across SCR
Conduction period
All
23.Two types of overload protection instantaneous over current and ________
Variable over current
Time over current
Constant over current
Delay feed current
24.Due to velocity saturation, MOSFET enters saturation region. (b)
At pinch off
Before pinch off
After pinch off
at Q
Before Q
25.Parameters hfe corresponds to
Bdc Bac re
rc
26.In 8085 _____ is part of control unit.
ROM
Instruction Register
RAM
OP Code
27.Content of instruction register split into ______ nibbles
4
3
2
5

28.Any constant of time domain is an impulse in frequency domain with


Infinite height, infinite width, infinite area
Infinite height, infinite width, unit area
Infinite height, zero width, infinite area
Infinite height, zero width, unit area
29.Channel of JFET between
Gate and Drain
Drain and Source
Gate and Source
Input and Output
30.Drawback of JFET
Noise distortion
Having small gain bandwidth
product
31.Difference between DMOSFET and JFET
P-N Junction
Drain
Gate
Source
32.The DC-operating point of an amplifier specified by voltage and current value
is called
Gain
Q
Loadline
none
33.Common mode rejection ratio
Common to diff
diff to common
Input to output
output to input
34.One of the property of FIR filter is that _____ is not required for FIR filters.
Input
Transfer Function Feedback
Output
35.FIR can be designed to achieve _______
Linear Phase Inverting Phase
Non-inverting
A&B
36.Null detector in wheat stone bridge
Voltmeter
37.Least reliable power source
Solar Wind Tidal Geothermal Biogas

You might also like