Professional Documents
Culture Documents
Sent:
To:
Subject:
One of the tanks' (the digester) was cut out to match the smaller gas holder tank.
A hot metal pipe is used to make the inlet and outlet holes (on opposite sides)
Inlet (left, also acts as drain for emptying digester) and outlet (right) pipes are pre assembled
Time to rest inside the digester (from top, showing inlet pipe)
Bricks used to support the gas holder as it falls back (replaced by sand filled bottles below).
Plastic bottles were used to support the inlet pipe, instead of clay burnt bricks!
Dr GW loved the job (here you ca see the inlet (right) and outlet (left). Gasholder not visible
prior to filling.
Sketch of supports for Inlet and Outlet pipes, held by a strap (use your imagination here!).
Time to have a photo! It was a great job. I will test the gas after 14 days
Share with a friend,
"The more people are self sufficient in cooking fuel, the
Cheers
more personal and financial freedom they have." -Emma Casson
Vianney Tumwesige
Kampala-Uganda
You can make a difference donate www.hopeforfutureangels.org
http://trustvianney.blogspot.com/