Professional Documents
Culture Documents
otherwise
Pritesh Kumar1
Vijayendra Kumar2
Department of Electrical & Electronics Engineering
Asia Pacific Institute of Information Technology
(Key words: Tripping, Timer, Transformer, Temporary Fault 555 Timer, Voltage regulator
(LM7805), Relays, Comparator, Transformer (230 V 12V AC))
Abstract
Since power demand is increasing rapidly in
characterize
fault
&
symmetrical
component
Block Diagram
proposed
Relay.
system.
The
output
of
the
Figure 3: Relay
The NC contact of all the relay made parallel
while all the common point are grounded.
The parallel connected point of NC are given
to pin2 through a resistor R5 to a 555 timer
i.e. wired in monostable mode. The output of
the same timer is connected to the reset pin 4
of another 555 timer wired in astable mode.
LEDS are connected at their output to
indicate their status.
Hardware Description
Transformer
conditions.
Op-Amp LM358
transformer
whose
primary
is
Switch
Advantage
The
proposed
system
References
will
Ieee, 3, 6.
smoothly.
Future Scope
International
Conference
on
P. F. Gale, P. A. Crossley, X.
edition.
Conclusion
C37.114TM-2004.
K.
Zimmerman,
D.
Costello,
fault
result
permanently.
in
tripping
the
system