Professional Documents
Culture Documents
What can be broadcast over the wireless network to help a user connect to the network and use
wireless services?
SSID
WEP keys
VLAN parameters
WPA encryption keys
VPN authentication information
A company has help desk staff that is not highly trained in VPNs. What two features or
technologies must the network designer identify as training needs in order for the help desk to
support secure remote access for teleworkers? (Choose two.)
QoS operation
VLAN configuration
tunneling protocols
IPv6 and IPv4 dual stack
encryption algorithms
Frame Relay configuration
Which statement best describes the VPN feature called split tunneling?
It creates separate pathways for different VLANs
. It creates two tunnels, one for user traffic and one for management traffic such
as CDP and SNMP.
It allows user traffic that is destined for the corporate network to travel across
the VPN tunnel, while traffic destined for the Internet travels through the local LAN
of the VPN client.
It allows separate tunnels so that high priority traffic, such as voice and video,
uses the higher bandwidth tunnel, while all other user traffic travels on the lower
bandwidth tunnel.
The network infrastructure at the headquarters of an organization consists of Cisco network
devices that are running RIPv1. As part of an upgrade project, a portion of the company
backbone will be increased to 10 Gb/s and needs to support unequal cost load balancing between
routers. The IP addressing scheme is also changing and needs to support VLSM and CIDR.
Which routing protocol should be selected for the network?
BGP
EIGRP
OSPF
RIPv2
Refer to the exhibit. What can be concluded from the output that is shown?
MDF_R1 has a MAC address of 2294:300F:0000.
MDF_R1 is connected through FastEthernet0/1 to C2960-24TT-L_IDF1.
Device C2960-24TT-L_IDF1 is running Cisco IOS Software Release 12.2(25)SEE2.
MDF_R1 is installed in the main distribution facility on floor 24 of building L.
Refer to the exhibit. In the Cisco IOS filename that is shown, what is signified by the underlined
portion?
version
platform
file format
feature set
A network administrator has removed a router from the network for maintenance. A new Cisco
IOS software image has been successfully downloaded to a server and copied into the flash of
the router. What should the administrator do before placing the router back into service?
Delete the previous version of the Cisco IOS software from flash.
Copy the new IOS into NVRAM to create a backup copy.
Restart the router and verify that the new image starts successfully.
Verify the free space available on the router to store the new IOS image.
A network technician needs to install a four-port switch module in an operational Cisco 1841
router that has an available HWIC slot. What should the technician do first?
Turn off the power to the router before installing the new module.
Install the hot-swappable four-port switch module directly into slot 1 of the 1841.
Move the existing WIC-2T module to slot 1 and install the four-port module in slot 0.
Shut down all Fast Ethernet ports on the router until the switch module installation is
complete.
Refer to the exhibit. An administrator installs a WIC-2T module into a Cisco 1841
router. Attempts to configure the S0/0/0 interface are unsuccessful. As a first step in
troubleshooting the failure, the administrator issues the show version command.
What is a possible reason for the failure?
The WIC was not physically installed properly.
The WIC was installed into slot 1 instead of slot 0. The interface type and
number are invalid on an 1841. The configuration register is the wrong value for
adding new modules.
Refer to the exhibit. Which type of application communication model best describes
this network?
client-client client-server farm client-enterprise edge client-enterprise
server
If traditional phones are used when introducing VoIP to a network, what component would be
required to convert the analog voice from traditional telephone signals into IP packets?
Multipoint control unit
Power over Ethernet switches
a router that acts as a voice gateway
Cisco Unified Communications Manager
Which feature relies on prioritization of network traffic and is used to ensure successful delivery
of real-time services?
security
reliability
redundancy
quality of service
192.168.12.0/24
192.168.13.0/24
192.168.14.0/24
192.168.15.0/24
A wireless survey has been conducted before the deployment of a wireless network. What would
be the benefit of the survey?
provides initial configuration of the access points
determines the channel settings of the access points
determines the security settings on the access points
finds the optimal number and placement of access points
Refer to the exhibit. What does the TOR router do with traffic that is destined for a
web server with an IP address of 172.18.10.24?
The router sends the traffic out Serial 0/0/0. The router sends the traffic out
all interfaces other than the one it came in on. The router places the packets into
a queue until a better route is discovered via RIP. The router sends a request to
neighboring routers for paths to the 172.18.10.0 network
A user in a large office calls technical support to complain that a PC has suddenly
lost connectivity to the network. The technician asks the caller to talk to nearby
users to see if other machines are affected. The caller reports that several
immediate neighbors in the same department have a similar problem and that they
cannot ping each other. Those who are seated in other departments have
connectivity. What should the technician check as the first step in troubleshooting
the issue?
the power outlet to the PC that is used by the caller. the trunks between
switches in the wiring closet.
the status of the departmental workgroup switch in the wiring closet. the
cable that connects the PC of the caller to the network jack. the cable connection
between a PC and a network outlet that is used by a neighbor.
A company would like to ensure that the failure of a single access switch does not disrupt service
to the mail servers located in the data center. What can be done to ensure maximum connectivity
to the mail servers?
Enable CDP to ensure all neighboring devices are known.
Create a separate RSTP specifically for the mail servers.
Configure a routing protocol so that paths to all Layer 3 devices are cached.
Install redundant access links between the servers and the access layer switches.
Refer to the exhibit. An extended ACL has been created to deny traffic from the
192.168.35.0/24 network to the web server with IP address 209.165.201.15.
According to Cisco best practices, where should the ACL be applied?
RTB Fa0/0 inbound RTC S0/0/1 inbound RTD Fa0/0 outbound RTC
S0/1/0 outbound
--
-------------
A company is concerned with protecting internal e-commerce servers against external attacks.
An application layer firewall is installed at the network edge and a host-based IDS system is
installed on the internal LAN. What should be done to ensure a fast response and minimum
server downtime in the event of an external attack?
Replace the host-based IDS with an IPS.
Place the e-commerce servers in a DMZ.
Install a logging server to monitor all attacks.
Replace the application layer firewall with a stateful one.
Which two security best practices are recommended for a router deployed as a WAN endpoint?
(Choose two.)
Turn off unnecessary services.
Enable HTTP for web administration.
Configure easy to remember passwords.
Apply timeouts on VTY, AUX, and console ports.
Enable Telnet access to allow for remote management.
Company XYZ requires a WAN solution that provides flexible bandwidth options and
supports one physical interface at the head office that would provide simultaneous
connectivity to various remote sites. The distance from each site should not make
the solution more expensive. Which WAN technology meets the requirements of the
company?
DSL cable
Frame Relay T1 leased line
Refer to the exhibit. A pre-sales system engineer receives a diagram of the current
WAN from a customer. EIGRP is the routing protocol used on the WAN. Based on the
default operation of EIGRP, which statement is true about the routing table on
router R1?
There is a single route to the 192.168.16.0/24 LAN using the T1 connection.
There is a single route to the 192.168.16.0/24 LAN using the DSL connection.
There is a single route to the 192.168.16.0/24 LAN using the Metro Ethernet
connection. EIGRP installs all three routes to the 192.168.16.0/24 LAN and load
balances the traffic.
Choosing to disable Telnet and allow only SSH connections for remote access to
the core routers. Choosing not to broadcast the SSID for wireless access points.
Refer to the exhibit. What can the field engineer conclude about the EIGRP
authentication between Router1 and Router2?
Authentication will fail because only one key is configured. Authentication will
succeed and EIGRP updates can be exchanged. Authentication will fail because
the key chain names do not match. Authentication will fail because the key chain
names must match the router names.
Refer to the exhibit. A networking engineer is characterizing an existing network for
a new customer. The engineer issues a show running-config command on the R1
router to gather configuration information. What is the engineer able to determine
as a result of viewing the output of this command?
The R1 router has two specific routes to the main office LANs in the routing
table. The default route for the R1 router points to the Edge1 router. The R1
router will load-balance traffic to the main office LANs by using both DSL and Frame
Relay. A connection through ISP-1 will be used to reach the main office LANs if
the Frame Relay network is unavailable.
Refer to the exhibit. Which username and password combination will correctly
configure PPP authentication on routers RTR_A and RTR_B?
What are two accurate descriptors of a DLCI? (Choose two.)
Frame Relay Layer 2 address
one DLCI allowed per local loop
locally significant circuit endpoint
signaling standard between DTE and DCE
establishes the data transfer rate through a Frame Relay network
Which two values represent valid IPv6 addresses? (Choose two.)
::::1 FF01::1 0:0:0:0:0:0:0:1 2001:DB8::47::2A4 2031:0000:04AC:34
00:FFE3:0