You are on page 1of 1
ta Pea ei, tof P.C. Gajbhiye Rail Nilayam er aifhes oP Rravevrare Chief Mechanical Engineer a Secunderabad D.O No.M.237/WS/MtrlRejections-Vendor Performance/378 Dt. 20" April, 2011 My dear Amitabh, Sub: Markings on constant contact PU side bearer pads. Ref: Railway Board letter no. 2007/M (L)/466/5(402) dated 04.11.2010. Railway Board advised vide reference above that feed back on performance of RDSO controlled items is to be fed in RDSO web Portal, for which details of manufacturers’ initials and date of manufacture etc. are essentially required. During my inspection of Rayanapadu Workshops recently, it was informed that details like initials of manufacturer and date of manufacture are not available for the subject item and in the absence of these details, it is not possible to feed the information in web portal. Also, in absence of these details, difficulties are experienced while raising warranty claims. It is brought out that as per the drawings AAL-021101-Alt-8 & AAL- 024104N Ait (approved by RDSO), initials of manufacturer and date of manufacture are to be marked/printed on PU rings & spacer plate, whereas these details are getting damaged during service 3. Hence, it is suggested to emboss the details of manufacturers’ initials and date of manufacture etc. on the material, so that these details are not damaged iri service and the same could be fed in the web portal as well as raise warranty claims if warranted 4. RDSO may please revise the approved drawing for constant contact, PU side bearer pads and advise the manufacturers “accordingly. With best wishes Yours Sincerely, Shri, Amitabh Sinha Executive Director t \ Wagon Directorate, age \ RDSO, Lucknow /C/- EDME/FreightRly. Bd Tele No's. 070 - 86749 (Rly): 040 - 2782 2582 Fax No: 040 - 2782 2272, email:eme @scr.aiinet.gouin

You might also like