ENGINE 307
MOVABLE DRIVE FACE
DISASSEMBLY
+ Remove the spacer (.
+ Remove the movable drive face cover (2).
* Detach the movable drive face plate 3).
* Pull out the eight rollers @. OF ®
'* Remove the oil seals (6) and 6).
INSPECTION
ROLLER
Check that there is no abnormal wear or damage on the roller. If
any defects are found, replace the rollers as a set.MOVABLE AND FIXED DRIVE FACE
‘Check the drive face for any abnormal condition such as stepped
wear or discoloration caused by burning,
If any defects are found, replace them with a new one.
Check if any damage exists on the lip of oil seal
If any defects are found, replace the oil seal with a new one.
Measure the clearance between a ruler and the surface of drive
face using the thickness guage.
If the clearance exceeds the service limit, replace it with a new
one.
Face abrasion: Service limit: 0.4 mm
09900-20803:Thickness guage
<
REASSEMBLY
+ Carry out the assembly procedure in the reverse fom
assembly while observing the following instruc
+ Apply a small amount of grease to the bore ant
A@H 99000-25010: SUZUKI SUPER. anette
A CAUTION
* Wipe off excess grease thorough
* Take care not to apply grease t surface of the
Vbelt.
Position the eight rollers @ ble drive face.
+ Mount the damper @) on the nisvgble drive face plate
* Position the movable drive plate on the movable drive face.
* Install the movable drive face cover @).
* Install the spacer.
NOTE:
Press down the movable drive face plate so as not fo cause the
roller to come out of the position when inserting the spacer.MOVABLE DRIVEN FACE ASSEMBLY/
CLUTCH SHOE
DISASSEMBLY
+ Hold the clutch shoe with the special tool and loosen the clutch
shoe nut.
4 CAUTION
Do not remove the clutch shoe nut before attachi
clutch spring compressor.
09940-92440: Wrench set (1)
(09930-40113; Roter holder 2)
* Attach the special tool to the movable driven face assembly
and compress the movable driven face assembly by turning in
the special tool handle.
+ Remove the clutch shoe nut
®_ 09922-31420: Clutch s5
ing compressor
A CAUTION
Since a high spring force applies to the aed
sembly, care must be used so as not to causé(the dutch
shoe assembly and movable driven face to off
abruptly.
* Loosen the special tool handle slowly ar the clutch
shoe assembly. RS
‘A CAUTION QO
Do not attempt to sane eglutch shoe assem-
bly.