Professional Documents
Culture Documents
1. Ensure that minicom/hyperterminal window is connected to the router that needs to be configured.
Linux> sudo minicom ttyS0 or Linux> sudo minicom ttyS1
2. Unplug the power cord from the power strip outside the router rack. (Starting from the LED switch end, routers are connected in sequential order.) 3. Plug in the power cord for a router. 4. When you see
System Bootstrap, Version 12.1(3r)T2, RELEASE SOFTWARE (fc1) Copyright (c) 2000 by cisco Systems, Inc. C2600 platform with 32768 Kbytes of main memory program load complete, entry point: 0x80008000, size: 0x761444 Self decompressing the image : ################
Send the break signal. For hyperterminal, it may be achieved by the key sequence ctrlbreak, function-break, or something else. For minicom, you may use ctrl-a followed by z followed by f (without the quotes). 5. You will see the following prompt.
... monitor: command "boot" aborted due to user interrupt rommon 1 >
6. Type
rommon 1 > confreg 0x2142 You must reset or power cycle for new config to take effect rommon 2 > reset
Page 1/4
Bridging software. X.25 software, Version 3.0.0. 2 FastEthernet/IEEE 802.3 interface(s) 1 Serial network interface(s) 32K bytes of non-volatile configuration memory. 16384K bytes of processor board System flash (Read/Write) --- System Configuration Dialog --Would you like to enter the initial configuration dialog? [yes/no]: 8. Enter no for the last question.
Page 2/4
{Enter}
11. After rebooting, press enter. You will be asked for a password. Use the console password to login. Type enable and provide the secret password when prompted. You will enter the privileged mode. Use sh conf command to see the current configuration. The output should be similar to the text given below.
Using 672 out of 29688 bytes ! version 12.3 service timestamps debug datetime msec service timestamps log datetime msec no service password-encryption ! hostname Router2 ! boot-start-marker boot-end-marker ! enable secret 5 $1$R7i1$M3/GawERxPx7YnaRPfj2F/ ! no aaa new-model ip subnet-zero ip cef ! ! no ip domain lookup ! ! ! ! ! ! interface FastEthernet0/0 no ip address shutdown duplex auto speed auto ! interface Serial0/0 no ip address shutdown ! interface FastEthernet0/1 no ip address shutdown duplex auto speed auto ! no ip http server
Page 3/4
ip classless ! ! ! ! ! line con 0 exec-timeout 0 0 password cisco logging synchronous login line aux 0 line vty 0 4 password cisco login ! ! end
Page 4/4