Professional Documents
Culture Documents
MIXING
The liquid product must be stirred before use to ensure thorough dispersion of the pigment. The product must not be continuously recirculated in high shear pumps as this will cause the emulsion to break down. Do not add thinners or water.
CLEANING
Flush with clean water immediately after use. Blocked spray nozzles may be easily cleared with white spirits.
USES
Used for efficient curing of concrete in one easy spray application. Used for curing of large concrete surface areas, such as airport aprons, concrete roads and bridge structures as well as all general applications.
COVERAGE
The recommended coverage rate is approximately 6 m/litre. Coverage rates outside this recommended range might be used if necessary to meet specific requirements. Contact abe's technical department for advice in such cases.
PROTECTION ON COMPLETION
No further treatment of water or other material is required after application. The applied film must not be disturbed or broken. The concrete surface must be kept free from loads or traffic until it has gained sufficient strength.
APPLICATION
Do not apply when the substrate temperature is below +5 C. Apply immediately after the exposed surface has sufficiently hardened to prevent marring by the application. This is especially important in warm or hot climates. Do not apply if any surface or bleed water is present. Apply uniformly and thinly by spray, brush or roller. Use a garden-type pressure sprayer or a wide short-nap roller to achieve a thin uniform application. This is important as uneven application results in a mottled appearance as the concrete ages. Initially, application has a temporary mirror-like sheen, which visually helps the applier obtain uniform coverage of all areas, and eliminates wasteful double application. In the case of formed surfaces, apply as soon as forms are stripped. The spray nozzle is held approximately 450 mm from the surface whilst moving the spray head back and forth. An even pressure must be maintained to produce a continuous fine spray, to ensure complete wetting and coverage
MODEL SPECIFICATION
Wax emulsion based curing membrane for curing concrete elements after stripping formwork. For curing durarep repair mortars. Clear finish. The curing compound will be duracure WBC, a clear wax emulsion based curing membrane applied in accordance with the recommendations of abe Construction Chemicals.
SURFACE PREPARATION
If any part of the surface has dried out, it should be wetted down immediately preceding the application, but do not apply while freestanding water remains on the surface. Surface should be saturated but free of surface water
T E C H N I C A L D ATA S H E E T
duracure WBW Wax emulsion based curing membrane for curing concrete elements after stripping formwork. For curing durarep repair mortars. White heat reflective finish. The curing compound will be duracure WBW, a white wax emulsion based curing membrane applied in accordance with the recommendations of abe Construction Chemicals.
abe Construction Chemicals has a wealth of technical and practical experience built up over years in the companys pursuit of excellence in building and construction technology.
PACKAGING
duracure WBC & WBW is supplied in 20 litre and 200 litre metal containers.
IMPORTANT NOTE
This data sheet is issued as a guide to the use of the product(s) concerned. Whilst abe Construction Chemicals endeavors to ensure that any advice, recommendation, specification or information is accurate and correct, the company cannot because abe has no direct or continuous control over where and how abe products are applied accept any liability either directly or indirectly arising from the use of abe products, whether or not in accordance with any advise, specification, recommendation, or information given by the company.
FURTHER INFORMATION
Where other products are to be used in conjunction with this material, the relevant technical data sheets should be consulted to determine total requirements.