Professional Documents
Culture Documents
FEATURES
DIP-16-300-2.54
* Wide operating voltage range (VCC=2.2 ~ 12V) * Few external components are needed * Typical oscillator frequency 76KHz * RX-3 built-in Zener 3V * 2 functions remote controller including forward/backward
ORDERING INFORMATION
Part No. RX-3 RX-3S Package DIP-16-300-2.54 SOP-16-225-1.27
BLOCK DIAGRAM
REV:1.1
2005.12.29 Page 1 of 6
RX-3
ELECTRICAL CHARACTERISTICS (VDD=6.0V,Fosc=76KHz, Tamb=25C, unless otherwise specified.)
Parameter Operating Voltage Operating Current O/P Driving Current Effect Decoding Frequency Variation Symbol VDD IDD Idrive Ftolerance Min 2.2 ---20% Typ 6 9 5 -Max 12 --20% Unit V mA mA --
PIN CONFIGURATION
PIN DESCRIPTION
Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Symbol VO2 NC GND SI OSCI NC OSCO BACKWARD NC NC FORWARD VDD NC VI1 VO1 VI2 No connection Negative power supply Input pin of the encoding signal Oscillator input pin No connection Oscillator output pin Backward output pin No connection No connection Forward output pin Positive power supply No connection Inverter 1 input pin for signal amplify Inverter 1 output pin for signal amplify Inverter 2 input pin for signal amplify Description Inverter 2 output pin for signal amplify
REV:1.1
2005.12.29 Page 2 of 6
RX-3
Data Format Forward Signal: F1=1 kHz Backward Signal: F2=250Hz F1=4F2 or F1=2F2 (Mask option)
220 F
9V 10PF 47PF 3.3K L1 Q1 0.002 F 15PF 5.6K 3.3K 1.2K 3.3 F 0.01 F 3.9K
VO2 NC GND
0.1 F 330
Q9
M
Q11 Q10
Q8
0.01 F
16
VI2
15
VO1
14
VI1
13
NC
12
11
10
9
NC
RX-3
SI
330 0V
1
3.3K
6
500K VR1
8
1K 91K
0.002 F
REV:1.1
2005.12.29 Page 3 of 6
RX-3
PACKAGE OUTLINE
DIP-16-300-2.54 UNIT: mm
SOP-16-225-1.27
UNIT: mm
REV:1.1
2005.12.29 Page 4 of 6
RX-3
Handling MOS devices: Electrostatic charges can exist in many things. All of our MOS devices are internally protected against electrostatic discharge but they can be damaged if the following precautions are not taken: Persons at a work bench should be earthed via a wrist strap. Equipment cases should be earthed. All tools used during assembly, including soldering tools and solder baths, must be earthed. MOS devices should be packed for dispatch in antistatic/conductive containers. Note: IC oscillator input mustn't be on the outside layer, thus to avoid the abnormal working when human body touches the remote controller without crust in testing.
REV:1.1
2005.12.29 Page 5 of 6
RX-3
REV:1.1
2005.12.29 Page 6 of 6