Professional Documents
Culture Documents
for practicce,BSNL technical assistant question papers wit answers and detalied explnations
1. Weins bridge is used for measurement of frequency in the applied voltage waveform is measurement of frequency in the applied voltage waveform is (a) Sinusoidal (Ans) (b) Square (c) rectangular (d) triangular 2. (a) (b) (c) (d) 3. (a) (b) (c) (d) Strain not an not A large high low flat high Q band losses active a transducer an coil gauge is transducer
(Ans)
losses response
4. In the case of an instrument reading of 8.3V with a 0 to 150 voltmeter having a guaranteed accuracy of 1% full scale reading, the percentage limiting error is (a) 1.810 % (b) 0.181 % (c) 12.45 % (Ans) (d) 0.0018% (Explanation : Limiting error at full scale = 1/100 X 150 = 1.5 volt the true reading may be (8.3 + 1.5) Volt the relative error = 1.5/100 X 8.3 = 12.45 % ) 5. (a) (b) (c) (d) 6. (a) (b) (c) (d) The parameter equivalent circuit High frequency, High frequency, Low frequency, small Low frequency, 'h' of a junction transistor large signal small signal signal operation large signal is valid for operation operation
(Ans)
operation
system is casual if the Values of input in Values of input at that Values of input at
of any time depends only on past and in the future and in the past (Ans) time and in the future None
7. From the hot metal surface electrons escape because (a) of change of state from metal to gas due to heat (b) of change of state from gas to metal (c) the energy greater than the work function (Ans) (d) the energy is greater than Fermi level
8. (a) (b) (c) (d) 9. (a) (b) (c) (d) 10. (a) (b) (c) (d)
PART
The
most
common
device
used diode
for
detection
in
radio
transistor In The a full central wave tap rectifier on the the negative high point in secondary its a circuit is Cathode anode
(Ans)
voltage
Negative feedback amplifier has a signal Amplify the noise as Reduce the Increase Not effect
noise noise
II
It is an unidirectional device that blocks the current flow from cathode to anode SCR (Ans) PCR VCR DCR
12. An ideal constant current source is connected in series with an ideal constant voltage source. Considering together the combination will be a (a) constant voltage source (b) constant current source (Ans) (c) constant voltage and a constant current source or a constant power source (d) resistance 13. A node current in (a) (b) electrons (c) electrons (d) holes only an thyristor electrons and is or holes made up of only holes
(Ans)
14. For a pulse transformer, the material used for its core and the possible turn ratio from primary to secondary are respectively (a) ferrite : 20:1 (b) laminated iron : 1:1 (c) ferrite : 1:1 (Ans) (d) powdered iron :1:1 15. (a) (b) (c) (d) A converter which can operate in both 3 pulse and 6 pulse modes is a 1 phase full converter 3 phase half wave converter 3 phase semi converter (Ans) 3 phase full converter
16. A single phase CSI has capacitor C as the load. For a constant source current, the voltage across the capacitor is (a) square wave (b) triangular wave (Ans) (c) step function (d) pulsed wave 17. A single phase full wave midpoint thyristor convertor uses a 230/200 V transformer with centre tap on the secondary side. The P.I.V per thyristor is (a) 100 V (b) 141.4V (c) 200 V (d) 282.8 V (Ans) (Explanation : For centre taped transformer in output side the PIV = 2 Vrms = 2 x 200/2 = 282.8 Volt) 18. In dc choppers for chopping period T, the output voltage can be controlled by FM by varying (a) T keeping Ton constant (Ans) (b) Ton keeping T constant (c) Toff keeping T constant (d) None of the above 19. (a) (b) (c) (d) 20. (a) (b) (c) (d) 21. (a) (b) (c) (d) In The An A Zero Very Very linearity error ideal Very power small internal large large for a digital output resistance input output input is supply consist of resistance
(Ans)
the 8421 BCD 0001 None of code the decimal 1111101 number 0010 the 125 is written
as
(Ans)
Explanation :
0101 7D above
22.
Match
the
given
feedback
circuit
with
its
proper
nomenclatures
(a) (b) (c) (d) 23. (a) (b) (c) (d) 24.
series
(Ans)
A amplifier is phase inversion voltage gain voltages are to distortion is correct match for
transistor
P channel N P
MOSFET
(Ans)
MOSFET MOSFET
25. In case a signal band limited to fermimeter is sampled at a rate less than 2 fermimeter , the constructed signal will be (a) Distortionless (b) Small in amplitude (c) Having higher frequencies suppressed (d) Distorted (Ans) 26. (a) (b) (c) (d) 27. IC which has quad 2 input AND gates 7411 7404 7400
(Ans)
7408
Registers in which data is entered or taken out in serial form are referred as
(a) (b) (c) (d) 28. The (a) A B C (b) AB (c) (d) A + B + C 29. (i) (ii) (iii) (iv) (a) (b) (c) (d) 30. (a) (b) (c) (d) Register Routh Root Bode Nyquist 2, 1, 3
shift shift registers of be BC B the criterion plot is is in and and and 4 four are in the sense that they similar count following is in time is in time in frequency frequency domain 4 3 are are are the simplified +
register register
(Ans)
above to CA + C
(Ans)
and
counters store
are
binary shift made from an array of flip flops and gates integrated on a single chip
31. In D/A converter, the resolution required is 50 mv and the total maximum input is 10 V. The number of bits required is (a) 7 (b) 8 (Ans) (c) 9 (d) 200 32. (a) (b) (c) (d) On differentiation Unit Unit Unit unit Unit impulse function parabolic doublet ramp results in function triplet
(Ans)
function
33. ------ watt of power is received from sun per m2 surface area of a geosynchronous satellite (a) 100 (b) 500 (c) 2000 (d) 1000 (Ans) 34. (a) (b) The Increase Increases ripple factor with with in the the an load load LC filter current resistance
(c) (d) 35. (a) (b) (c) (d) 36. (a) (b) (c) (d)
Remains Has
constant the
with lowest
the value
load
current
(Ans)
In different parts of the country identical telephone numbers are distinguished by their Language digits Access digits Area codes (Ans) Central office codes Amplitude modulation is used for broadcasting because it is move noise immune than other modulation systems compared with other systems it requires less transmitting power its use avoids receiver complexity (Ans) no other modulation system can provide the necessary bandwidth for high fidelity
37. The maximum phase shift than can be provided by a lead compensator with transfer function G0(S) =1 + 6S 1 + 2S (a) 15o (b) 45o o (c) 30 (Ans) (d) 60o (Explanation : If GC(s) =1 +Tn s 1 + Td s -1 -1 then Q = tan Tn tan Td Q = tan -1 6 tan-1 2 So maximum phase shift will be Q= 30o ) 38. (a) (b) (c) (d) The correct sequence of steps required to improve system stability is Insert derivative action, use negative feedback, reduce again Reduce gain, use negative feedback, insert derivative action Reduce gain, insert derivative action, use negative feedback Use negative feedback, reduce gain, insert derivative action. (Ans)
39. Identify slope change at = 10 of the magnitude v/s frequency char acteristic of a unity feedback system with the following open-loop transfer function G (j) = 5(1+j o.w) j (1 + j0.5) [ (1+j 0.6 /50) + ( j/50)2] (a) -80 dB/dec to 60 dB/dec (Ans) (b) 40 dB/dec to 20 dB/dec (c) 20 dB/dec to 40 dB/dec (d) 40 dB/dec to 20 dB/dec (Explanation : Factor 5 1 j 1 Corner frequency --------1=2 Gain and angle 20 log5=14dB line parallel to x axis -20dB/dec passing through =1 -20dB/dec slope originates from =2
1 + j0.5 1+0 (1+j 0.6 /50) + ( j/50)2 1+j 0-1 40. In the feedback G(s) of control H system
-40 dB/dec slope originates from =7.07 +20dB/dec slope originates =10 transfer function = (s2 +2s its root is given K loci by +2) is 1 2 3
(Ans)
(a) (b) (c) (d) 41. G (a) (b) (c) (d) 42. 1. 2. 3. 4. (a) (b) (c) (d) 43. (a) (b) (c) (d) 44. (a) (b) (c) (d) 45. (a) (b) (c) In
Number
4 In (s) (s) imaginary R the + j228 +j2.28 +j1.14 +j114 a loop = 2600k(s s4 +125s3 + 5100s2 + axis intercepts of the closed transfer + 65000s root loci 25) +
Considering the following statement : In a magic tee the collinear arms are isolated from each other one of the collinear is isolated from the E-arm one of the collinear arm is isolated from the H-arm E-arm and H-arm are isolated from each other. of these statements 1 1 1 2 1965 first EARLY and and geostationary BIRD WESTAR and and 4 2 3 are 3 satellite are are correct are was (Intel launched correct correct
(Ans)
MOLNIYA When A = 0., B = 0, C=1 then in two input logic gate we get gate XOR gate AND gate NAND gate (Ans) NOR gate In is is a radio tuned above amplifies the fixed tuned to receiver the the stations output of one particular IF incoming local frequency amplifier frequency oscillator
(Ans)
(d) 46. (a) (b) (c) (d) 47. (a) (b) (c) (d) 48. (a) (b) (c) (d) 49. (a) (b) (c) (d) 50. (a) (b) (c) (d) 51. (a) (b) (c) (d) 52. (a) (b) (c) (d) 53. (a) (b) (c) (d)
can A
be
tuned
to
various
isolate
frequencies
duplexer is used to couple two antennas to a transmitter without interference isolate the antennas from the local oscillator prevent interference between two antennas connected to a receiver (Ans) use an antenna for reception or transmission without interference Boolean algebra logic is based on numbers
(Ans)
truth symbols The amplifiers following the modulated stage in a low level modulation AM system be linear amplifier harmonic generators class C power amplifiers (Ans) class B untuned amplifiers In a radar maximum pulse width sensitivity system of of maximum power repetition unambiguous range of the frequency the transmitted the radar depends on transmitter
(Ans)
pulse receiver
In composite video waveform the function of the serrations, is to equalize the charge in the integrator before the start of vertical retrace. help vertical synchronization help horizontal synchronization (Ans) simplify the generation of the vertical syncpulse. The frequency very super infrared Which wave cannot TEM Ionosphere upto from 70 layer 18 to above of earth 18kms to 500 is from km 500 situated k exist inside wave range 30MHz medium high frequency high 300 MHz is frequency
(Ans)
HE at each m
(Ans)
70
km
two cavity klystron tube velocity modulated tube frequency modulated Amplitude modulated simple
is
a
(Ans)
55. As the thermal noise get doubled due to the increase in a resistance the noise power get (a) doubled (b) quadrupted (c) unchanged (Ans) (d) halved 56. (a) (b) (c) (d) 57. (a) (b) (c) (d) 58. (a) (b) (c) (d) 59. (a) (b) (c) (d) 60. (a) (b) (c) (d)
PART
Which
one
is Reflex Magnetron
cross
field
TWT The degree Size location size and depend on thermal of of size coupling depends of holes location of or location of depends through resistance of a x 10-19 x x chip registers bits bit bit been taken hole on hole
(Ans)
not
8085 8
seven 7 8
microprocessor bit
'Satyameva
have
from
(Ans)
None
of
Which of the following countries was the first to develop a neutron bomb?
(a) (b) (c) (d) 63. (a) (b) (c) (d) 64. (a) (b) (c) (d) 65. (a) (b) (c) (d) 66. (a) (b) (c) (d) 67. (a) (b) (c) (d) 68. (a) (b) (c) (d) 69. (a) (b) (c) (d) 70. (a) (b) The 'Kathakali'
USA
(Ans)
USSR China Pakistan dance Kerala Uttar Tamil The term "Ashes" Cricket None Kailash Temple of at Ellora is Gupta Rashtrakutlas Chalukya architecture a is associated is connected with
(Ans)
Chola
When the two Houses of Parliament differ regarding a Bill then the controversy is solved by Joint sitting of the two Houses President of India Prime Minister of India (Ans) By a special committee for the purpose Which of the following is not the work of Kalidasa ? Meghdoot Raghuvansha Prakarma
(Ans)
Sariputra Ritushamhara Amir Khusro Akbar was the famous the Mahmud Shah Alauddin space great poet and Great
aesthete
of
(Ans)
With
the Era
beginnings of
of
List Book Year An though it mourns the death of Funny Newspaper someone , need not be sad poem article
(c) (d) 71. (a) (b) (c) (d) 72. (a) (b) (c) (d) 73. (a) (b) (c) (d) 74. (a) (b) (c) (d) 75. (a) (b) (c) (d) 76. (a) (b) (c) (d) 77. (a) (b) (c) (d) 78. (a) (b) (c) (d) With which Sindhu If stare is
talk
(Ans)
is
(Ans)
Tell Salk Admire He The He The He Give the work opposite unsightliness work very word hardly work is is little for works is means hard hard easy
(Ans)
pulchritude antipathy
(Ans)
Nanometre Ten
is
Rakshak Aircraft Multiple-purpose gun "Dada Best to branch Saheb Phalke film
Award"
Best Who
work
Indian know as
film
Industry
developed
of
Einstein
Archimedes
In
which
state
is U.P. W.
Kanha
Park
situated
? M.P.
(Ans)
is 24th
July August