Professional Documents
Culture Documents
2MC2000
2. Information on ingredients
This product is not considered to be hazardous but contains hazardous components. Composition (preparation) : Mixture of highly refined mineral base oils (PCA-content < 3 % - IP 346) and additives.
Substance name Hydroxy alkyl carboxyl ester (4-nonylphenoxy)acetic acid : : Value(s) < 0.03 < 0.03 CAS nr ----3115-49-9 EINECS nr --------EC index --------CERTIFICATE Xi; R38 Xn; R22 C; R34 R43 N; R51-53 C; R34 R43 N; R51-53 Xi; R36/38 N; R51-53 Xi; R36/38 N; R50-53 N; R51-53 N; R51-53 N; R51-53
N,N-bis(2-ethylhexyl)-((1,2,4-triazol-1- : yl)methyl)amine Amine phosphate Acylsarkosinate Sterically hindered phenol Dithiophosphoric acid ester Alkylated diphenylamines : : : : :
< 0.03
91273-04-0
401-280-0
613-072-00-9
< 0.06 < 0.015 < 0.28 < 0.14 < 0.06
---------------------
---------------------
---------------------
3. Hazards identification
Main hazards Adverse human health effects Environmental hazards Inhalation Skin contact Eye contact Ingestion Not a dangerous preparation according to 1999/45/EC. None under normal conditions. No specific risk for the environment. Not expected to present a significant inhalation hazard under anticipated conditions of normal use. : Not expected to present a significant skin hazard under anticipated conditions of normal use. : Not expected to present a significant eye contact hazard under anticipated conditions of normal use. : Not expected to present a significant ingestion hazard under anticipated conditions of normal use. : Assure fresh air breathing. Obtain medical attention if breathing difficulty persists. : Remove affected clothing and wash all exposed skin area with mild soap and water, followed by warm water rinse. Seek medical attention if irritation develops. : Rinse immediately with plenty of water. Seek medical attention if irritation develops. : DO NOT INDUCE VOMITING. Seek medical attention immediately. : If there is any suspicion of aspiration into the lungs either directly or as a result of vomiting, obtain medical advice. : : : :
2MC2000
: Do not enter fire area without proper protective equipment, including respiratory protection. : None Identified
on soil
: No special respiratory protection equipment is recommended under normal conditions of use with adequate ventilation. : Use neoprene or rubber gloves. : No special clothing/skin protection equipment is recommended under normal conditions of use. : Safety glasses. : Provide local exhaust or general room ventilation to minimize dust and/or vapour concentrations. When using, do not eat, drink or smoke. Emergency eye wash fountains and safety showers should be available in the immediate vicinity of any potential exposure. : according to TWA (TLV) ACGIH : 3 mg/m for oil mist.
2MC2000
: 0.854 to 0.861
Mutagenicity
2MC2000
: All components are in compliance with the EC Seventh amendment Directive 92/32/ EEC : In compliance ( DSL ) : Section 311 and 312 hazards classification(s) : None : In compliance : In compliance : Not classified as hazardous in accordance with OSHA 29 CFR 1910.1200
2MC2000
The contents and format of this MSDS are in accordance with EEC Commission Directive 93/112/EEC. DISCLAIMER OF LIABILITY The information in this MSDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.
End of document