You are on page 1of 5

Smart Host Microcontroller for Optimal Battery Charging in a Solar-Powered Robotic Vehicle

Abstract:
This paper focuses on the design and construction of an optimization charging system for batteries by means of tracked solar panels. Thus, the implementation of a complete Energy management system applied to a robotic exploration vehicle is put forward. The proposed system was tested on the robotic platform an unmanned exploration vehicle specialized in recognition. The interest of this robotic system lies in the design concept, based on a smart host microcontroller. On this basis, our proposal makes a twofold significant contribution. On the one hand, it presents the construction of a solar tracking mechanism aimed at increasing the rovers power regardless of its mobility. On the other hand, it proposes an alternative design of power system performance based on a pack of batteries. The aim is completing the process of charging a battery independently while the other battery provides all the energy consumed by the robotic vehicle.

Existing System:
Solar based unmanned exploration vehicles are used in some space researches. The existing exploration vehicle uses static solar panels, which cannot track maximum power from solar cells. Here we are using a solar tracking system to produce maximum power.

Proposed System:
The proposed system uses Master and Slave based Microcontrollers. The Master controller PIC16F877A senses the light intensity from two different directions using LDR (Light Dependent Resistors). The panels direction is adjusted according to the sunlight direction using a stepper motor. The exploration robot has two-fingered arm to pic and place the objects. The robot is controlled using Zigbee protocol. The Battery status will be continuously measured and sent back to the monitoring unit through Zigbee. The monitoring section consist a PC with Zigbee transceiver, VB based user interface used to control the unmanned exploration vehicle. Since we are using solar-based system, power consumption is reduced.

Block Diagram:

Robot Section:

Power supply Power supply With Battery With Battery

LDR1 LDR1 LDR2 LDR2 Battery Status Battery Status

Master Master Microcontroller Microcontroller PIC16F877A PIC16F877A LCD LCD

Slave Slave Microcontroller Microcontroller AT89C51 AT89C51

Motor Motor Driver Driver Motor Motor Driver Driver

Pick and Pick and Place Place Robot Robot Mechanism Mechanism

Motor Motor Driver Driver Power supply Power supply

Stepper Motor Stepper Motor for Solar for Solar Tracking Tracking

Control and Monitoring Section:

Power supply Power supply

Max232 Max232

PC PC

Hardware Requirements:
AT89C51 Microcontroller with Power Supply PIC16F877A Microcontroller with Power Supply 12V 1A Rechargeable Battery Solar Panel Stepper Motor Max232 Zigbee Transceiver Motor Driver Pic and Place Robot Mechanism

Software Requirements:
Embedded C Keil C Compiler MPLAB or CCS Compiler

Advantages:
Low power consumption, since we use solar energy for power supply. Maximum Power will be generated using solar tracking setup.

You might also like