You are on page 1of 2

Hi dear Friends...

First of all a VERY HAPPY NEW YEAR 2 all the people of this group.

'Essar Steel' visited our campus some days back, I don't have papers with me, but
there is no need to worry. Paper asked was very simple, there are two papers, first one will
be apti., and the second one will be subjective. The apti paper was simple, little bit of
common sense will do the trick. The questions were based on the 'gears' like there would
be two or more gears given of different diameter and no. of teeths, and it is asked that
which one will have higer rpm. Just refrest your fundas of Mechenics of first year, on
Inertia and mass. Don't mug up the formule just go through it qualitatively. The question
on gears were a bit tricky and needs time to think, actually print quality of paper is poor,
so the time consumed on understanding the figure will comparatively takes the toll, so be
prepared for that.

Then the subjective test for every branch is taken, I am in tronics, so I don't have
much ideas about trical papers, but I asked some of my batchmates, they said that the
questions were very easy and that it was mostly from the electrical machines part.
Transformer, PTs, CTs, Power X'mission etc. Paper is quite easy. Ya one more thing there
is portion in the subjective test composed of fill in the blanks and formule. When you
receive the paper attempt those first, then go for the multiple choice.

The time given will be ample and there is no neg. markings. so attempt all the
questions. I was able to finish the papers before time. They short listed 7 from my branch,
12 from trical...and mech, 13 from chem. we then had a GD on simple topics, after GD
they listed out 3 from EC, 5 from EE, Mech, Chem. Then the interview was held, composed
of simple technical and mostly HR.Chemical's requirements are not there in the company,
but if the closed down refienery some how again starts to function, then they wil call them
up. Finally they took 1 from EC, 2 from EE, 3 from Chem & Mech.

It is offering around 12-13k pm, accomod. etc.Keep your self calm and give your
best.

Wishing you all Good Luck....

Cheers.....

Sumit

Sumit K. Jha, B.Tech (EC), IV year., Room no. DF-1, Hall-5 (Gandhi Bhavan), NIT-Surat-395007 INDIA. Ph. +91-261-
3210275.

"Hope for the Best, Expect the worst, Life is a play &
We're unrehearsed "
hi subash
I am deepak from rec surat
I have few hints about essar paper .yaar i an sending u the\se
in u'r campus sanmar visited it is comming to our college on 11 jan
so
please immediately mail me the details any u having or some of u'r
friends may be having .
two section one 25min tech paper 40 questions
second fig questins same as L&T paper ditto copied
but 40 in no 30 min
some questions
melting pt of iron
steam turbine feed heater
drill mat composition
Ach welding
WEIR used Ans in flow measurement
possions ratio
gear strength
pig iron mfg process
gear materials
gear mech which is used to hold the gear
RATCHET MEch is ans
babbit metal composition
seamless tubing prep
Revise PN Rao
REPLY SOON
bye with luv deepak

You might also like