Professional Documents
Culture Documents
when the input voltage or load varies within limits. A. AC B. DC C. ripple D. differential
A. B. C. D.
3)If the reverse saturation current of a diode at 30 degree celcius is 25uA then, the reverse saturation current at 60 degree celcius will be _______uA. A. 50 B. 100 C. 150 D. 200 4) In active region, the voltage across the base and emitter of germanium transitor will be _____V. A. 0 B. 0.3 C. 0.7 D. 1.6 5) The saturation collector current of the circuit shown in the figure will be ____________mA.
APOSTROFHY
A. B. C. D.
6)In a FET amplifer if gmo = 5mS, VGS = -2.2V and Vp = -4V then the value of transconductance will be ________________mS. A. B. C. D. 1.25 2.25 3.56 5.85
7) The frequency of the RC phase shift oscillator depends on A. gain of the amplifier B. resistor in the feedback network only. C. capacitor in the feedback network only. D. both resistor and capacitor in the fedback network 8) The decimal equivalent of the hexadecimal 7AF is ____________. A. 1846 B. 1849 C. 1967 D. 2047 9) The dual of the Boolean expression [(A + B + C)D]' is ____________. A. ABCD' B. A'B'C'D' C. A'B'C'D D. A'B'C' + D'
APOSTROFHY 10)The Boolean expression implemented by the logic circuit shown in the figure is
A. B. C. D.
11) In a 8 to 3 encoder, if except MSB all other bits are zeroes, then the output of the encoder will be A. 000 B. 001 C. 100 D. 111
12) If the present state a Johnson counter is 1100, then the state of the counter after applying two clock pulses will be A. 1001 B. 0011 C. 1110 D. 1111 13)The fan in of each logic gate in a IC 7486 is _______. A. B. C. D. 2 6 10 20
14)The ____________ of the microprocessor selects, interprets and takes command over the execution of program instructions. A. ALU B. buses C. registers D. control unit
15) Which one of the following is a part of the execution unit (EU)?
16)The memory address of the next instruction that will be executed is 53200h and CS =5000 then the value of IP is _____ A. B. C. D. 3200 5300 32000 48200
17)XCHG instruction falls into the category of ________ instructions. A. B. C. D. logical arithmetic process control data movement
18)What will be the contents of register AL when the following code snippet is executed ? MOV AL, 48h NEG AL SUB AL ,3h A. B. C. D. A8h B4h B5h C7h
19)The break point interrupt is also called as _______ interrupt. A. type 1 B. type 2 C. type 3 D. type 4
20)If the starting address of 8255 is 73F0h then the address of Port C will be____________ A. 73F1 B. 73F2 C. 73F4 D. 73F8