s h o w ) 3 4 5 6 LINK LINK LINK LINK 0a 0b 0c 0d INT LNK LNK ACT LNK ACT 10 9 8 7 13 14 15 16 NVRAM8 adapter is placed in slot 2 in a FAS6200 series controller (as shown). FAS6210 model does not support IOXM. Q Q Slot 3 Slot 6 Slot 5 Slot 4 Slot 13 Slot 16 Slot 14 Slot 15 Slot 7 Slot 10 Slot 9 Slot 8 S l o t
1 S l o t
1 1 S l o t
1 2 + + + + + P + + + 17.53 in. (44.52 cm) 10.2 in. (25.86 cm) A B 1 2 DC AC x2 2 K N L K N L 0a 0b e0a e0b e0c e0d K N L 0b P F A S 2 2 4 0 - 2 17.6 in. (44.7 cm) NetApp Hardware Universe Storage Controllers RC-0032-0212 Side B 02-15-2012 K N L K N L 0a 0b e0a e0b e0c e0d K N L K N L 0a 0b e0a e0b e0c e0d Depth: 24 in. (61 cm) F A S 2 2 4 0 - 4 17.7 in. (44.9 cm) 7 in. (17.8 cm) P P Expansion PCIe Gigabit Ethernet RJ45 4Gb Fibre Channel SFP Serial-Attached SCSI QSFP Serial Console RJ45 HA Interconnect IB4X Expansion PCI-X 10 Gigabit Ethernet SFP+ + 8Gb Fibre Channel SFP+ + Alternate Control Path RJ45 P Remote Management RJ45 HA Interconnect QSFP Q HA Interconnect SFP+ + 0a 0b LNK LNK 0c 0d e0b e0a c0b c0a 3 4 F A S / V 3 2 0 0
&
S A 3 2 0 ( S i n g l e
c o n t o l l e r
s h o w n ) P Slot 3 Slot 4 + + 17.61 in. (44.7 cm) F A S 2 0 4 0 P P 17.6 in. (44.7 cm) Depth: 29 in. (73.66 cm) 8 9 7 5 6 4 2 3 1 8 9 7 5 6 4 2 3 1 e0e e0f d 0 e c 0 e b 0 e a 0 e RLM 0f h 0 g 0 e 0 0b d 0 c 0 a 0 2 HI-POT 2200VDC 1 HI-POT 2200VDC REPLACE THIS ITEM WITHIN 2 MINUTES OF REMOVAL REPLACE THIS ITEM WITHIN 2 MINUTES OF REMOVAL PROPERLY SHUT DOWN SYSTEM BEFORE OPENING CHASSIS. F A S / V 6 0 0 0
a n d
S A 6 0 0 ( S i n g l e
c o n t r o l l e r
s h o w n ) S l o t
2 S l o t
9 S l o t
3 S l o t
4 S l o t
5 S l o t
6 S l o t
7 S l o t
8 17.53 in. (44.52 cm) 10.32 in. (26.21 cm) F A S / V 3 1 0 0 17.73 in. (45 cm) Please recycle after use. Feedback and questions can be sent to xdl-hardwareuniverse@netapp.com 2012 NetApp, Inc. change without notice. NetApp, the NetApp logo, Go further, faster, Data ONTAP, NOW, SnapMirror and MetroCluster are trademarks or registered trademarks of NetApp, Inc. in the United States and/or other coun- tries. All other brands or products are trademarks or registered trademarks of their respective holders and should be treated as such. RC-0032-0212 This document is subject to change without notice. ration Guide at current information. NetApp employees and partners can check the NetApp 1Stop site at netapp1stop.com should check with their account teams for updates. This po Enablement and Solutions Organization (TESO). ACP Alternate Control Path BTU British Thermal Unit Cu Copper Connector FAS Fabric-Attached Storage FCP Fibre Channel Protocol FC Fibre Channel GbE Gibabit Ethernet HA High Availability HT Hyper-Threading IB4X LUN Logical Unit Number NIC Network Interface Card NVRAM Nonvolatile RAM Op Optical Connector 1 2 System capacity is calculated using base 10 arithmetic (1TB=1,000,000,000,000 bytes) and is derived based on the type, size, and number of drives. 3 Max capacity shown can only be achieved using 3TB drives under Data ONTAP 8.0.2 or greater. 4 Maximum aggregate size is calculated using base 2 arithmetic (1TB = 2 40 bytes). 5 AC Power values shown are based on typical system values with 2 power supply units. Please refer to the Site Requirements Guide on the NOW site for worst-case values. 6 Thermal disspation values shown are based on typcial system values. Please refere to the Site Requirements Guide on the NOW site for worst-case thermal dissapation values. 7 FAS6200 embedded Fibre Channel ports and Fibre Channel ports on the vertical FC boards, all are considered as on-board ports, can be set as target or initiators and support operation at 2, 4, or 8Gb speeds. Operation at 1Gb speeds is not supported. 8 9 100 LUNs from one array using one array LUN group. Combined LUN and NetApp disk can total 240 devices. 10 NVMEM on FAS2240 leverages portion of the 6GB of controller memory, resulting in ~5.25GB memory for Data ONTAP. 11 NVMEM allocation on the FAS2040 is 512MB with Data ONTAP 8.0 and higher and 256MB with Data ONTAP 7.3.x releases. NetApp Hardware Universe Storage Controllers RC-0032-0212 Side C 02-15-2012 Expansion PCIe Gigabit Ethernet RJ45 4Gb Fibre Channel SFP Serial-Attached SCSI QSFP Serial Console RJ45 HA Interconnect IB4X Expansion PCI-X 10 Gigabit Ethernet SFP+ + 8Gb Fibre Channel SFP+ + Alternate Control Path RJ45 P Remote Management RJ45 HA Interconnect QSFP Q HA Interconnect SFP+ +