Professional Documents
Culture Documents
11
Customer
Project No.
SPL No.
Manufacturer
Equip. Name
Ref. Drawings & Documents
Testing/Inspection Date
GENERAL DATA
LOCATION
MANUFACTURER
PO NUMBER
SERIAL No.
Type
PROTECTION LEVEL
INPUT POWER
INPUT CURRENT
OUTPUT VOLTAGE
OUTPUT CURRENT
BATTERY TYPE
BATTERY MANUFACTURER
NO. OF CELLS/BANK
BATTERY
CAPACITY/CELL
VOLTAGE/CELL
RECOMMENDED
CHARGING CURRENT
MAXIMUM ELECTROLITE
TEMPERATURE
NUMBER OF BANKS
MODE OF CHARGING
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer
QCF-E-10
11
INSPECTION
ACCEPTAB
LE
TYPE
Yes
COMMENTS
No
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer
INITIAL
S
QCF-E-10
11
ELECTRICAL TESTS
ACCEPTA
BLE
Yes No
Type
COMMENTS
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer
INITIA
LS
QCF-E-10
11
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer
QCF-E-10
11
Notes:
1. Bolt torque levels shall be in accordance with manufacturers published data. In the absence of
manufacturers published data, NETA table 100.12 shall be used
2. Micro-ohm or DC millivolt drop values shall not exceed the high levels as indicated in the manufacturers
published data. In the absence of manufacturers published data, investigate values that deviate from similar
connections by more than 50% of the lowest value.
3. Float and equalize voltage settings shall be in accordance with the battery manufacturers published data
4. Current limit shall be within the manufacturers recommended maximum
5. Results of load sharing between parallel chargers shall be in accordance with system design specifications
6. Results of alarm operations shall be in accordance with manufacturers published data and system design
7. Input and output voltage shall be in accordance with manufacturers published data
8. Charger shall be capable to operate at specified full load
9. Cell voltages shall be within 0.05 volt of each other or as per the manufacturers published data
10. Cell internal ohmic (resistance, impedance or conductance) shall not vary by more than 25% between
identical cells that are fully charged
11. Voltage measured from positive to ground or negative to ground shall be similar in magnitude
Additional Comments:
i. `
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer
QCF-E-10
11
Connection
:
:
:
:
:
L+ To L-
L+ To PE
L- To PE
Witness
Name :
Signature:
Date:
Consortium
MAN Diesel &Turbo / Semco Maritime AS
Employer / Engineer