You are on page 1of 4

TASK GROUP ENGLISH

Introduction, Parts, Maintenance, and Instruction/procedure of


Oven


BY
GROUP III
NAME :
HARDIYANTI HENDRIK
KHAIRUL UMAM
MARIA INVIOLATA VAN BON
MARIA STEFANNY E.N
MASYITHA MARDATILLAH
MUH. ARIEF. R
CLASS : IIIA


SMK - SENIOR HIGH SCHOOL OF CHEMICAL ANALYST
MAKASSAR


INTRODUCTION
Oven is a tool used for sterilization using dry air. This sterilizer used to sterilize
equipment such as glass Erlenmeyer, Petridisk (petri dish), test tubes and other
glassware. Materials such as cotton, linen and paper can also be sterilized in the oven
but in a certain temperature, the temperature is generally used on dry sterilization is
around 140-1700C for at least 2 hours. It should be noted that the duration of
sterilization depends on the number of sterilized instruments and equipment for heat
resistance.



PARTS
Function of oven parts, namely:
a. Temperature serves as a temperature regulator is in the oven.
b. Oven rack serves as a place to put the material or equipment that will be in
sterilization
c. Serves as an oven door opening and closing the oven.
d. Aluminum voil, serves as a medium that is used to wrap the tools and
materials that will be sterilized in the sterilizer, as well as maintain and
protect the existing materials in the glass reaction from being contaminated









MAINTENANCE
Maintenance and things to note
a. Glass tools neatly organized and orderly
b. If warming temperatures above 1000C, may not enter equipment / materials made
of rubber, plastic or material that is easily damaged
c. Do not dry measuring pipette and flask because the volume will change
d. Record the time and temperature / temperature every time tool run.
e. Equipment must be clean and free of dust



INSTRUCTION/PROCEDURE
How to use
a. Connect the power source
b. Enter the device to be drained, arrange them neatly and tightly close doors
c. Turn on the appliance by pressing the ON button, the pilot light will light (red and
yellow)
d. Set temperature and time desired temperatur
- When the temperature of 1700C, set a time of 1 hour
- When the temperature of 1600C, set the time 2 hours
- When the temperature of 1500C, set time 2.5 hours
- When the temperature of 1400C, set the time 3 hours
e. When the set time has been completed, the timer automatically kemali to zero
f. Let cool, then remove materials and equipment are sterilized / dried



REFERENCES
http://www.quincylab.com/labovens.html
http://en.wikipedia.org/wiki/Laboratory_oven
http://www.labsaya.com/2013/03/penggunaan-oven.html
http://fatmanuritalamanaku.blogspot.com/2012/04/teknik-laboratorium-operasional-alat.html

You might also like