You are on page 1of 9

MAINTENANCE OF MODEL BECS-07/08/18/28:

The trouble phenomenon How to check, adjust and judge Removing trouble
The error display:
MA! M"T"R "#$RTM$%
&' To check whether the power supply is lack o(
phase, i( so)
To measure the voltage o( input power
supply with voltmeter and repair the power
supply'
*' The heat relay+s protection (unction
,irstly turn o(( the machine, then check
whether the power supply is lack o( phase,
and e-amine whether the motor is
overload, (inally to turn on the machine
a(ter these checkouts'
.' The (use pipe o( .A on the main sha(t control
board is (used/
Replace the (use pipe'
0' To e-amine whether the connectors are joined
hard, i( there are some pins damaged)
To repair or replace it'
1' There are problems on the main sha(t control
board'
Replace the main sha(t board'
2' The main sha(t motor has mal(unctions' To repair or replace it'
3' The main control board have some problems' Replace the board'
The rev o( slow start is less than 45
rpm '
Adjust the potentiometer #R* clockwise on the main sha(t control board to achieve 45 rpm'
The rev o( slow start is more than 45
rpm
Adjust the potentiometer #R* anticlockwise on the main sha(t control board to achieve 45rpm '
The limit rotation speed o( 355 rpm is
less than 355 rpm'
Adjust the potentiometer #R* clockwise on the main sha(t control board to achieve 355 rpm'
The limit rotation speed o( 355 rpm
transcends 355 rpm'
Adjust the potentiometer #R* anticlockwise on the main sha(t control board to achieve 355 rpm'
!otes : 6otentiometer #R. is set as standard value be(ore the machine leaving the (actory, so the adjustment o( #R. is (orbidden'
7limbing:
&' Adjust the potentiometer #R& anticlockwise on the main sha(t control board'

*' i( the machine has trouble a(ter the above
adjustment, you should check whether the
capacitance 72 on the main sha(t control board has
problems/)
Replace capacitance 8 72 is *'*u,+s
tantalum capacitance9 '
.' To check whether the bolt connecting the sha(t
and the encoder become less crowded /)
To screw the bolt tightly at the 5 degree'
0' To see i( the mechanical transmission part is
normal/)
Adjust the drive belt or the drive chain'
1' The main sha(t control board has some
problems')
To replace the board '
2' ( the machine is still climbing a(ter the above
operation,then check to see whether the brake sheet
o( main sha(t motor is damaged'( so)
Replace the brake sheet'
3' The so(tware o( model :$7;<54 can be
audjusted')
$nter assistance mode by keyboard, change
the setting o( =;$T :R$A> 6ARA'= and
=MA! M"T"R 6ARA'=
Run over
&' The encoder has no continuous signals'
*' The cable ware or the connectors o( the encoder
have some trouble'
&' Replace the encoder'
*' Repair and adjust to make it reliable'
$rror display:
<<<<<change color overlimit
<<<<<change color overtime'
<<<<<hal( return error%
&' ( the lamp indicating hal( return is not bright on
the needle location board , measure the direct
current &*#+s switching power supply , i( it doesn+t
work:)
Replace the switching power supply'
*' To e-amine whether the connectors are joined
hard on the needle location board , and i( there are
some pins damaged:)
Replace the damaged ware'
.' To uncover the cover plate above the needle
location board, and to check whether the machinery
parts are normal, i( unusual:)
Repair it'
0' To rotate the color<changing motor sha(t with the
spanner, at the same time to check whether the
needle location lamps change and light, i( all do not
light, or some lamps light and others not, the
needle location board has trouble:)
Replace the needle location board'
1' ( the machine still has trouble a(ter the above<
mentioned operations, the main control board have
trouble)
Replace the main control board'
2' To check whether the power supply o( needle Repair or replace the power supply'
location board is normal or not, i( unusual:)
7hange color error'
&' To e-amine whether the connectors on the power
supply board are joined hard, i( there are some pins
damaged:)
Replace the damaged parts'
*' To see i( the (use is (used on the power supply
board / 8,& is a &1A , and ,* is 2A9:
Replace the (use'
?o change color orderly, but not
change color in reverse order'
?o the same way as above' Replace the damaged parts'
?o change color in reverse order, but
not change color orderly'
?o the same way as above' Replace the damaged parts'
?o change color orderly or in reverse
order, but every time appear the error =
change color overlimit% =
&' The diodes ?3 and ?4 in the power supply
board is damaged /
Replace the damaged parts'
All o( the embroidery heads cannot
detect the thread broken'
&' To e-amine whether the connectors on the thread
broken detect board are joined hard, i( there are
some pins damaged:
*' The thread broken detection is set in the
corresponding menu /
.' Are there signal o( enabling thread broken and
thread clamp signal / The indicating lamps are @.2
and @.1'
0' The control board has trouble'
7orrect the setting or replace the damaged
parts and mal(unction board'
1' To measure the direct current &*#+s switch
power supply in the board, i( it doesn+t work:)
Replace the power supply'
All thread broken detect lamps are
bright while the thread o( one head is
broken '
&' To check whether the direct current &*# is
normal'
*' To see i( there is short circuit o( connecting cable
between the decode board and the thread broken
detecting board /
Repair the damaged parts or power supply '
Ahen the thread o( one head is
broken, the thread broken detection+s
lamp on this head is dark, but others
are bright'
&' s there some trouble in the decode board/
*' s there some trouble in the needle location
board/
.' Are there problems in the connecting cable
between the decode board, the needle location
board and thread broken detecting board/
Repair or replace the damaged boards'
rregular thread broken detecting'
8 thread broken o( one needle position
is not detected but another is detected ,
and so causes the machine to work
abnormally'9
&' s &*#+s power supply normal/
*' s the connection good on the board/
.' The decode board is bad'
Replace the damaged parts or the decode
board'
"ne embroidery head cannot locked
hard '

&' To see i( the head solenoid is damaged/
*' To check whether the triode TR3 in the head+s
thread broken detect board is damaged/
.' To check the machine installation between the
head solenoid and the needle drive die<block has
troubleBC
Replace the damaged parts or the decode
board'
All heads+ solenoid cannot lock the
heads completely'
&' The direct current *0#+s voltage is normal/ Repair or adjust the power suppply'
*' Aith the voltmeter, you measure the voltage o(
the diode ?&. on the solenoid drive circuit o( the
thread broken detecting board' The value should be
4# while the head is locked and the head switch is
at down position'
Repair or adjust the potentiometer'
The system reports the error: =stepping
motor error= or can not move the
(rame while press moving keys'
&' The stepping motor driver is over(lowing'8 the
showing lamp is bright9'
*' The power supply o( the stepping motor driver is
not normal, and the (use is (used'
.' The stepping motor drivers is connecting cable
wrongly'
0' The main control board has some trouble'
1' Mechanical mal(unction e-ists'
;olve the breakdowns, or replace the parts'

The stepping motor occurs unusual
voice while moving the (rame, or the
stepping motor lose some steps, or the
embroidery happens distortion '
&' The cables between the stepping motor driver
and the stepping motors are connected wrongly '
*' The stepping motor driver is lack o( phase '
.' Mechanical mal(unction e-ists'
;olve the problem or replace the stepping
motor drivers'
The (loppy disk driver is lightening all
the time a(ter the machine is turned
on'
&' The (loppy disk driver+s signal cable 8 .0 pins9 is
plugged conversely'
*' The (loppy disk driver is bad'
6lug the signal cable correctly or replace
the disk driver'
7annot read the pattern (rom the
(loppy disk or read in error' B
&' The type o( pattern cannot identi(ied by the
machine'
*' The (loppy disk has some errors'
Replace the (loppy disk'
.' The signal cable 8 .0 pins 9 or the power wire is
damaged'
Replace the signal cable or the power wire'
0' The (loppy disk driver is damaged' Replace the (loppy disk driver'
1' The main control board has some trouble' Replace the board'
The memory design is lost a(ter power
o(('
&' To con(irm that the battery voltage on control
board cannot be lower than .'2#'
*' The circuit o( the main control board e-ists some
trouble'
Replace the battery or the board'
Thread<trimming has no action'
&'Measure the ?7 voltage between the *,.
terminals o( 7D. in the power supply board with
the multimeter' The normal value is E5#, i(
abnormal)
)Replace the power supply board'
)The capacitance 7&80355u9 and
resistance8&5FG9 connected with 7D. have
loose weld or damage' Aeld again or
replace the damaged parts'
*' Trim tread by hand, and see i( the lamp o(
@..8HI9 in the main control board is light or not' (
not, the board has some trouble8no signal output9'
Replace the main control board'
.' To see i( the position o( the tray o( solenoid is
suitable'
Adjust to make it at the suitable position'
0' To see i( the solenoid is normal'( not, Replace the tread trimming solenoid'
1' To see i( the connected parts are normal or not' (
not,
Replace the connectors'
2' Measure the triode o( M2 with multimeter to see
i( it is normal or not' ( not,
Replace the triode'
Thread<holding has no action'
&'Measure the A7 voltage between the 0,1
terminals o( 7D2 in the power supply board with
the multimeter' The normal value is 2.#, i(
abnormal)
)7heck the power supply voltage'
)7heck i( there are some loose
connection'
)Replace the trans(ormer'
*' Measure the ?7 voltage between the *,.
terminals o( 7D. in the power supply board with
the multimeter' The normal value is E5#, i(
abnormal)
)7heck i( the connectors are loose or not'
)Replace the power supply board'
.' To see i( the connectors between the tread
holding solenoid and the power supply board is
loose or not'
Repair and adjust to make it connect well'
0' Measure the resistance between the thread
holding solenoid and the machine (rame to see i(
there is short circuit8 the resistance is 59'
7heck every tread holding solenoid in turn
and replace the damaged' The normal value
is more than &5FG'
1' To see i( there is thread holding signal output
(rom the main control board, the lamp o( @.*8>I9
is light or not' ( not, the main control board has
some trouble8no signal output9'
Replace the main control board'
2' To see i( the connection between the power
supply board and the main control board is reliable
or not'
Repair and adjust to make it reliable'
3 Measure the triode o( M1 with multimeter to see
i( it is normal, i( not )
Replace the triode'
Tread catching has no action'
The measure o( checking and solving is the same as above' The resistance value o( the parallel
connection o( the thread catching solenoids is more than 1FG' The indicator o( thread catching
solenoid is @.08JI9' The triodes in the power supply board are M&,M*,M. and M0'
@7? has no display'

&' To see the output steady<voltage o( 1# is right or
not'
*' Measure the power supply o( A7 **5# is right
or not'
)7heck i( there is loose connection'
)Replace the steady<voltage power supply'
)7heck the power supply'
.' T" check the connection between the 1# steady<
voltage power supply output ware and the @7?
control board to see i( it is reliable or not'
Repair and adjust to make it reliable'
0' T" check the connection between the $35E
board and the @7? control board to see i( it is
reliable or not'
Repair and adjust to make it reliable'
1' The @7? screen has no background light'
)Replace the @7? screen lamp'
)7heck and repair the connection between
the two terminals and the inverter to make
it reliable'
)Replace the damaged inverter board'
2' To check i( the $35E board is normal or not' Replace the damaged board'
3' To check i( the @7? control board is normal or
not'
Replace the damaged board'
4' 7heck to see i( the connection between the two
terminals o( the 056 cable in the @7? control
board is reliable or not' ( not,
Repair and adjust to make it reliable'
?isplay stripes on the screen

&' 7heck to see i( the connection between the (lat
cable in the operation bo- and the @7? screen is
reliable or not'i( not,
Repair and adjust to make it reliable'
*' 7heck to see i( the @7? screen is damaged or
not' i( so,
Replace the damaged screen'
. 7heck to see i( the connection between the two
terminals o( the 056 cable in the @7? control
board is reliable or not' ( not,
Repair and adjust to make it reliable'
0' 7heck to see i( the @7? control board is Replace the damaged board'
damaged or not' i( so,
@7? screen glittering' The measure o( checking and solving is the same as above'
The (rame can not be locked'
&' 7heck the two terminals o( the stepping power
supply to see i( it is &55# or not' ( not,
)7heck the (use o( the stepping power
supply'
*' Measure the voltage between the & terminal and
* terminal o( the 46 plug in the stepping motor
driver to see i( it is ?7 &05#K
Mearurethe voltage between the . terminal and 3
terminal to see i( it is A7 4#K
Mearurethe voltage between the 0 terminal and 4
terminal to see i( it is A7 &1#' ( not
)7heck the (use in the power supply board
in the stepping moter driver'
)Replace the power supply board in the
stepping motor driver'
,rame moves not continuously
&L7heck the connection between the ware o( I
and M to see i( it is reliable' ( not,
Repair and adjust to make it reliable'
*' 7heck to see i( the stepping motor driver and
stepping motor are damaged'
)Replace the damaged driver'
)Replace the damaged motor'
?esign out o( shape
&' 7heck the design to see i( it out o( shape at the
same place, and check the round o( the design to
see i( it is right, to see i( it is problem o( the design
itsel('
)Reread another design'
*' 7heck to see i( it is the cause o( the .06 cable
ware o( the (loppy disk driver or the connection o(
the two terminals o( the connector'
Repair and adjust to make it reliable'
.'To see i( the design can return to the origin or not
a(ter it out o( shape:
( so, it may be the problem o( the design'
( not,the stepping motor driver may be damaged,
or the stepping signal mat be inter(ered'
)Reread another design and check again'
)Replace the damaged driver and motor'
)To (ind the inter(erence sources'
0' N?oes the (rame move steady/ Are there pauses
when the (rame moves continuously/
Replace the damaged driver and motor'
1' ?esign out o( shape has no rule,the (orward trail
does not accord with the backward trail'
Replace the encoder'
2' Ahen power o((, do you (eel it is loose and very
heavy when you push the (rame/
7heck the relevant machine transmission
parts, (or e-ample the (rame drive belt'
Some malfunc!on" an# $e %emo&!n' me$o#"
of $%ea# (%ea) #eec!on
&' ?o not detect when thread is brokenK
&'&' ,irstly check the computer+s parameters to see i( the thread break detecting (unction is set
&'*' All heads do not detect even i( the thread break detecting (unction is set'
7heck the indicator lamps on main control boardK the lamps are: ?*E, ?.5 o( :$7;<E&K ?&2, ?&4 o( :$7;<E1K @.1, @.2 o( :$7;<53K
IHA, ?IO? o( :$7;<54K IHA, ?IO? o( :$7;<&4P*4' Ahen the machine runs normally, the indicator lamps o( ?*E, ?&2, @.1, IHA,
?IO? will glint, ?.5, ?&4, @.2 will be light' Ahen the states o( the lamps are wrong, then change the main control board cause it has
some trouble'
&'.' Ahen the states o( indicator lamps are right, check the 7D5&4 o( :$7;<E&PE1, A4 o( :$7;<53, 7D54&* o( :$7;<54' 7heck the
wires between the 7D14&* and the outlet 87D& o( three<position thread break detecting board, 7D5&& o( two<position thread break
detecting board9 on the thread break detecting board o( the last head to see i( the connection is good, i( it is wrong, that shows the signals
have not transmit to the board, repair the connection wires to make it good'
*' "ne head does not detect, but others are normal'
*'&' The thread break detecting board o( this head has some trouble, change it'
*'*' 7heck the outlet 87D& o( three<position thread break detecting board, 7D5&& o( two<position thread break detecting board9 to see i( it
connects well'
.' Alarm wrong 8when the machine runs just (or a while, all the indicator lamps on the thread break detecting boards are light9'
The decode board is destroyed' The types o( the decode board are: ?IMM:, $,&50, $,&&E'
0' All thread broken detecting lamps are bright while the thread o( one head is broken'
0'&' To check whether the direct current &*# is normal' 8 t may be occurred when it is below &5#, then change the power supply9
0'*' The thread break detecting board may be destroyed' 7heck the signal wires one by one on the detecting board until (ind the destroyed
board and change it'
0'.' 7heck as &'. to see i( the signal wires are short'
1' All thread broken detecting lamps are bright while the thread o( one head is broken and mending'
1'&' 7heck the indicator lamps, ?.2 o( :$7;<E&, ?*& o( :$7;<E1, @.3 o( :$7;<53, ,;A o( :$7;<54P&4P*4' Ahen the machine is
mending, all the lamps are light, i( not, the main control board is destroyed, change it'
1'*' 7heck as &'. to see i( the signal wires are open or do not connect well'
2' Alarm wrong when it has (unction o( bottom tread break detecting' ( one needle position o( one head do not action and alarm o(ten,
(irstly, check the wheel o( this needle position to see i( it runs normally, i( it runs normally, get rid o( the connecting wires between the
bottom thread break detecting board and the thread break detecting board to see i( the trouble phenomenon still e-ists, i( not, change the
bottom tread bread detecting board'

You might also like