You are on page 1of 3

IECEP COMPILATION ELECTRONICS

1. A type of oscillator which uses an amplifier circuit


that introduces 1800 phase shift
Ans. RC Phase Shift Oscillator
2. AC generator output is delivered via
Ans. Slip ring and brushes
3. In a series resistive circuit , the applied circuit
voltage is equal to the:
Ans. Sum of all the individual voltage drop
around the circuit
4. A typical relay has :
Ans. one set of contacts and one or more coils
5. The measure of how pure or real an inductor is.
The higher its value in an inductor, the fewer losses
there are.

Ans. Q-factor

6. It is a diagnostic application or device that a
network administrator
can purchase and install on a network workstations
or attach to the network media
to monitor and capture dat packets for subsequent
analysis

Ans. Sniffer

7. Refers to the process of shrinking the size and
power dissipation of
electronic circuits. It also involves surface mount
technology

Ans. Microminiaturization

8. If the feedback signal (voltage or current) is
applied in such a way
that it is in phase with the input signal and thus
increases. It is also known as
regenerative feedback or direct feedback

Ans. Positive Feedback

9. This can be defined as the ratio of output d.c.
power available at the
load to the power rating (Volt Ampere) of the
transformer used in the rectifier
circuit

Ans. Transformer Utilization Factor
10. The gate source of an n-channel depletion-
mode JFET are connected together. What value of
Vds will ensure that this two terminal device is
biased in the saturation region. What is the drain
current for the bias condition?

Ans. Idss
11. The performance specifications of a normally
include
a description of the voltage transfer characteristics,
noise margins, fan-out, fan-in,
propagation delay, power dissipation, and delay
power product.
Ans. Logic-gate
12. It is used in a range of applications, in
rectification, demodulation and
signal clamping.
Ans. Diode
13. When the current in the coil changes, an
electromotive force (EMF)
is induced in that coil which tends to oppose the
change in the current. This is ____
Ans. Self-inductance
14. It is the slope of transfer characteristic (Id
versus Vgs ) and is defined as the change in the
drain current corresponding to a change in the
gate-to-source voltage.

Ans. Transconductance

15. Used solely for storing and shifting data which
is in the form of 1s and or 0s.
Ans. Register
16. A starting switch that is used to de-energize the
start winding of a leruetic
compressor just like the current relay.
Ans. Hot wire relay
17. It is a non-zero level of the output voltage when
all inputs are zero?
Ans. Offset error
18. What frequency that can cause the movement
of air molecules above audio
frequency but below radio frequency.
Ans. Ultrasonic frequency
19. A mutual induction device used to measure
the absolute angular position of a
shaft.
Ans. Resolver
20. A memory that can be read by the processor,
but the processor cannot write into it such devices
are non-volatile and so are suitable for storing
programs or any noncharging data

Ans. ROM
21. The most commonly used for fieldwork to
measure the viscosity of oils, syrups,
varnish, paints and vv
Ans. Efflux Cup viscometer
22. It is used for measuring very low pressures
down to one hundred-thousandth of an
inch of mercury.
Ans. Mcleod Gauge
23. What type of Liquid cooling in which the heat
sink assembly is immersed in oil
tank?
Ans. Oil-immersed natural cooling
24. Used to reduce the amount of AC negative
feedback while maintaining DC
feedback.
Ans. Decoupling capacitor
25. A microphone which are one of the oldest and
simplest forms of sound detector
Ans. Carbon microphones
26. A device that produce a measurable response
to a change in a physical condition,
such as temperature or thermal conductivity or to a
change in a chemical
concentration.
Ans. Sensor
27. It is used to store the results of certain condition
when certain operations are
perform during execution of the program.
Ans. Status register & Flag register
28. This is a measure of smallest incremented unit
of the input signal that can be
measured by the transducer.
Ans. Resolution
29. A thyristor has the ability to provide a pulse that
is used to trigger SCRs and other
thyristors.
Ans. PUT
30. The various op-amp circuits used for generating
such signals of required frequency
and waveform.
Ans. Waveform generator & signal generator
31. The outputs of a full adder are S = 0, Co = 1. Its
inputs might be____.
Ans. A = 1, B = 0, Ci = 1.
32. A snubber network is used to reduce___.
Ans. False triggering.
33. An active bandpass filter is built from a lowpass
filter cascaded with a highpass
filter. It has a lower cutoff frequency of 200 Hz, and
a bandwidth of 800 Hz. The
cutoff points of its two filters are:
Ans. Lowpass = 200 Hz, highpass = 1 khz
34. At the cut-off point of a lowpass filter the phase
change is:
Ans. 45 degree
35. The open-loop gain of an op amp falls to 1
at___.
Ans. Transition frequency
36. What theory states that "any resistance R in a
branch of a network in which
a current I is flowing can be replaced by a voltage
equal to IR"?
Ans. Compensation Theorem
37. This diode provides fast voltage transitions by
the very sudden
disappearance of the charge carriers. After a
forward current has been
passing in the diode and the current is interrupted,
the reverse conduction
will cease very abruptly.
Ans. Step-recovery diode
38. It is the time taken by a diode to operate in the
reverse condition from
forward conduction.
Ans. Reverse recovery time
39. In a self-biased JFET, the gate is at
Ans. 0 V
40. In a push-pull amplifier, the distortion in the
output cause by the transition
of state of transistors from cut-off state to the on
state is called ____.
Ans. Crossover distortion
41. A type of circuit that consists of two matching
transistors with the collector
of one connected to the bases of both, thus
producing the same collector
current in each transistor.
Ans. Current mirror

You might also like