You are on page 1of 7

Office Copy

OBJECTIVE QUESTION PAPER


EXAMINATION
SUBJECT: BSCS (Hons.)
TITLE:
TIME ALLOWED:

FINAL 2013 SEMESTER

COURSE CODE:

CS-1103

BASIC ELECTRONICS

25 MINUTES

MAX: MARKS:

14

Q. No.1.
1

10

11

12

13

14

A diode that has a negative resistance characteristics is the


(a) Schottkey diode
(b) Tunnel diode
(c) Hot-carrier diode
(d) Laser diode
LED is a type of
(a) Bulb
(b) Diode
(c) Pot
(d) Variable capacitor
The PN junction diode is a
(a) Passive device
(b) Vacuum tube
(c) Unilateral device
(d) Bilateral device
The average value of a half-wave rectified voltage with a peak value of 200 V is
(a) 63.7 V
(b) 127.2 V
(c) 141 V
(d) 0 V
The dc of a transistor is its
(a) current gain
(b) voltage gain
(c) Power gain
(d) internal resistance.
If Ic is 50 times larger than Ib ,then dc is
(a) 0.02
(b) 100
(c) 50
(d) 500
An amplifier that operates in the linear region at all times is
(a) Class A
(b) Class AB
(c) Class B
(d) Class C
If the load resistance of a capacitor-filtered full-wave rectifier is reduced, the ripple voltage
(a)decreases
(b) increases
(c) is not affected
(d) has a different frequency
In saturation, VCE is
(a) 0.7 V
(b) equal to VCC
(c) minimum
(d) maximum
The maximum efficiency of a class A power amplifier is
(a) 50%
(b) 70%
(c) 25%
(d) 98%
The disadvantage of base bias is that
(a) it is very complex
(b) it produces low gain
(c) it produces high leakage current (d) ) it is too beta dependent
Ideally, a dc load line is a straight line drawn on the collector characteristic curves between
(a) the Q-point and cutoff
(b) the Q-point and saturation
(c) VCE (cutoff) and Ic (sat)
(d) Ib = 0 and IB = Ic> dc
In cutoff, VCE is
(a) 0 V
(b) minimum
(c) maximum
(d) equal to Vcc
A no-load condition means that
(a) the load has zero resistance
(b) the load has infinite resistance
(c) the output terminals are open (d) answers(a) and (c)
Signature:________________

Office Copy
SUBJECTIVE QUESTION PAPER
EXAMINATION

FINAL 2013 SEMESTER

COURSE CODE:

CS-1103

SUBJECT: BSCS (Hons.)


TITLE:
TIME ALLOWED:

BASIC ELECTRONICS

155 MINUTES

MAX MARKS:

56

Note: Attempt any four questions.


1- a. Discuss the Energy Diagrams of the PN Junction and Depletion Region
b. Determine the output voltage for each Zener limiting circuit in following figures.

7
7

2- a. Name two factors that determine the voltage gain of an amplifier.


b. Explain and analyze the operation of class C amplifiers

4
10

3- a. Discuss the input and output Characteristics of Common Emitter Configuration.


b. Figure shows the filtered bridge rectifier with C = 1000F and RL= 220.
Determine the following:

(i)
(ii)
(iii)

peak primary voltage, Vp(pri)


Unfiltered peak full-wave rectified voltage, Vp(sec)
peak-to-peak ripple voltage, Vr(pp) at the output
10:1

120 V rms
60 Hz

2
2
3

4- a. Determine the Q-point for the circuit in Figure and draw the dc load line. Find the
maximum peak value of base current for linear operation. Assume dc = 200.
7

b. Describe BJT switching operation.

5- a. Determine IB, IC, IE,VBE,VCE, and VCB in the circuit of Figure.


The transistor has a dc = 150.

b. Draw the symbols of following diodes also discuss their working principal.
(a)Zener diode (b) Tunnel diode (c) Varactor diode

Signature:_________________

SUBJECTIVE SOLUTION
EXAMINATION

FINAL 2013 SEMESTER

SUBJECT: B.Sc (Eco) (Hons.) COURSE CODE:


TITLE:
TIME ALLOWED:

BC-MGT-1102

BASIC MATHEMATICS

155 MINUTES

MAX MARKS:

56

Q. No.

Question

Q 1a

Discuss the Energy Diagrams of the PN Junction and Depletion 7


Region

Q1b

Determine the output voltage for each Zener limiting circuit in


following figures.
Answer: Remember, when one Zener is operating in breakdown, the
other one is forward-biased with approximately 0.7 V across it.

Q2a

Marks

Heading From
Syllabus

PN Junction

Diode
Limiter

Name two factors that determine the voltage gain of an amplifier.


4

Transistor as
Amplification

Q2b

Explain and analyze the operation of class C amplifiers

10

Power
Amplifier
Class C

Q3a

Discuss the input and output Characteristics of Common Emitter

Transistor
Configuration

Q3b

Figure shows the filtered bridge rectifier with C = 1000F and RL= 2+2+
220.
3
Determine the following:
(i)
peak primary voltage, Vp(pri)
(ii)
Unfiltered peak full-wave rectified voltage, Vp(sec)
(iii)
peak-to-peak ripple voltage, Vr(pp) at the output
Answer:
The transformer turns ratio is n = 0.1. The peak primary voltage is
Vp(pri) = 1.414Vrms = 1.414(120 V) = 170 V
The peak secondary voltage is
Vp(sec) = nVp(pri) = 0.1(170 V) = 17.0 V
The unfiltered peak full-wave rectified voltage is
Vp(rect) = Vp(sec) - 1.4 V = 17.0 V - 1.4 V = 15.6 V
The frequency of a full-wave rectified voltage is 120 Hz. The

Capacitor
Input Filter

approximate peak-to peak ripple voltage at the output is

The approximate dc value of the output voltage is determined as


follows:

The resulting ripple factor is

The percent ripple is 3.9%.


Q4a

Describe BJT switching operation

Transistors
Application

Q4b

Determine the Q-point for the circuit in Figure and draw the dc load 7
line. Find the maximum peak value of base current for linear
operation. Assume dc = 200.
Answer:
The Q-point is defined by the values of IC and VCE.

THE DC
OPERATING
POINT

The Q-point is at IC =39.6 mA and at VCE= 6.93 V.


Since IC(cutoff )= 0, collector current can occur and still maintain
linear operation of the transistor

The dc load line is graphically illustrated in Figure, showing that


before saturation is reached, IC can increase an amount ideally equal to
IC (sat) - ICQ = 60.6 mA - 39.6 mA = 21.0 mA
However, IC can decrease by 39.6 mA before cutoff (IC =0) is reached.
Therefore, the limiting excursion is 21 mA because the Q-point is
closer to saturation than to cutoff.

Q5a

Q5b

Draw the symbols of following diodes also discuss their working 7


principal.
(a)Zener diode (b) Tunnel diode (c) Varactor diode
7
Determine IB, IC,IE,VBE,VCE, and VCB in the circuit of Figure. The
transistor has a dc=150.
Answer:

From Equation 43, VBE _ 0.7 V Calculate the base, collector, and
emitter currents as follows:

IC = dcIB = (150) (430 mA) = 64.5 mA


Solve for VCE and VCB.
VCE = VCC - ICRC = 10 V - (64.5 mA) (100 ) = 10 V 6.45 V = 3.55V
VCB = VCE - VBE = 3.55 V - 0.7 V = 2.85 V

Since the collector is at a higher voltage than the base, the collectorbase junction is reverse-biased.

Other types
of Diodes
BJT Circuit
Analysis

OBJECTIVE SOLUTION
EXAMINATION
SUBJECT: BSCS (Hons.)
TITLE:
TIME ALLOWED:

FINAL 2013 SEMESTER

COURSE CODE:

CS-1103

BASIC ELECTRONICS

25 MINUTES

MAX MARKS:

Question

Answer

1
2
3
4
5
6
7
8
9
10
11
12
13
14

b
b
c
a
a
c
a
b
c
c
d
c
d
b

14

You might also like