CONTINUOUS ASSESSMENT EXAMINATION II, SEPTEMPER 2014
THIRD SEMESTER MECHANICAL
13.306 ENGINEERING DRAWING (MP)
PART A : Machine Drawing PART B : Civil Engg Drawing & Estimation (Part A and Part B are to be answered in separate answer books) Instructions: 1. Use first angle projection method. 2. Missing dimensions may be suitably assumed and note down in the answer book. Time: 4 hours
Maximum Marks: 100
PART A MACHINE DRAWING Max. Marks: 50 PART I
1. Sketch with standard dimensions (Attend any TWO questions).
a. Diamond Joint. Plate thickness: 12mm. b. Cotter Foundation bolt for bolt shank diameter of 24mm. c. Single Riveted Single Strap Butt Joint for a plate thickness of 8mm. (2 x 10 marks= 20 marks) PART II
2. From the accompanying figure (on page 2), draw the following views of the Knuckle Joint. a. Bottom Half Sectional Elevation b. Side View from Left (30 marks)