4. REINSTALL VSV (a) Install the VSV with the bolt. Torque: 18 Nm (185 kgfcm, 13 ftlbf)
(b) Install the hose clamp to the VSV.
(c) Connect these hoses to the VSV:
EVAP hose from throttle body
EVAP hose from charcoal canister
(d) Connect the VSV connector. 5. REINSTALL VBANK COVER
EXHAUST GAS RECIRCULATION
(EGR) SYSTEM EGR SYSTEM INSPECTION (a) (b) (c) (d) (e) (f)
(g)
EG5EP01
INSPECT SYSTEM OPERATION
Remove the Vbank cover. Using SST, connect terminals TE1 and E1 of the DLC 1. SST 0984318020 Keep the engine at 3,500 rpm. Set the transmission shift lever to the N position. Remove the SST from the DLC1. SST 0984318020 Check whether the engine rpm increases 100300 rpm under the following conditions: Coolant temp. Below 53C (127F) .... No increases Above 55C (131F) .... Increases Reinstall the Vbank cover.
EG146
ENGINE
EMISSION CONTROL SYSTEMS
COMPONENTS FOR EGR VALVE
REMOVAL AND INSTALLATION EG1NB06
EGR VALVE INSPECTION
1. 2.
REMOVE VBANK COVER
DISCONNECT EGR VALVE CONNECTOR
EG5EQ01
ENGINE
3.
EMISSION CONTROL SYSTEMS
EG147
INSPECT EGR VALVE RESISTANCE
Using an ohmmeter, measure the resistance between terminal B1 and B2 and other terminals (S1, S2, S3 and S4). Resistance: At 20C (68F): 19.9 23.4 W
4. DRAIN ENGINE COOLANT
5. REMOVE EGR VALVE (a) Disconnect these hoses from EGR valve:
Water bypass hose from IAC valve
Water bypass hose from rear water bypass joint
(b) Remove the 2 nuts, EGR valve and gasket.
6. A.
INSPECT EGR VALVE
Visually inspect EGR valve Check for sticking and heavy carbon deposits. If a problem is found, replace the EGR valve assembly.
B. Inspect EGR valve operation
(a) Apply battery voltage to terminal B1 and B2, and while repeatedly grounding (*S4) (S4 and *S3) (S 3 and *S2) (S2 and *S1) (S1 and S4) in sequence, check that the valve moves toward the open position. HINT: Keep the terminal marked with an asterisk (*) grounded while proceeding to the next grounding.
EG148
ENGINE
EMISSION CONTROL SYSTEMS
(b) Apply battery voltage to terminal B1 and B2, and while
repeatedly grounding (*S1) (S1 and *S2) (S 2 and *S3) (S3 and *S4) (S4 and S1) in sequence, check that the valve moves toward the closed position. HINT:
Keep the terminal marked with an asterisk (*) grounded
while proceeding to the next grounding.
Do this operation after opening the valve by performing
step (a) on the previous page. If operation is not as specified, replace the EGR valve assembly.
7. REINSTALL EGR VALVE
(a) Place a new gasket on the EGR valve adaptor. NOTICE:
Do not touch the adaptor and EGR valve surfaces of the
gasket with your hand. Align the port holes of the gasket and adaptor. Be careful of the installation direction.