Professional Documents
Culture Documents
1.
NOTE: Steps 1-6 must be completed within 30 seconds. The entire procedure must be completed within five minutes.
Start with the ignition in the OFF position. Open the driver door.
2.
3.
Press the power rear window control switch vent button six times.
4.
Turn the ignition to the OFF position. The driver door must be OPEN.
5.
Press the power rear window control switch vent button six times.
6.
Turn the ignition to the ON position. The power rear window will move down-up-down-up approximately 20 mm (0.8 in). This movement indicates that the power rear window motor
has entered initialization mode.
7.
Rotate and hold the power rear window control switch to the CLOSE position until the window stalls into the upper header seal.
8.
Momentarily rotate the power rear window control switch to the OPEN position and release. The power rear window will carry out a one-touch down operation until the window stalls
at the bottom of the travel stop designed into the window regulator.
9.
Rotate and hold the power rear window control switch to the CLOSE position. Continue to hold the switch until after the window stalls into the upper header seal and carries out the
down-up movement. This down-up movement is approximately 20 mm (0.8 in). This movement indicates that the power rear window motor has been successfully initialized.
10.
Verify correct operation of the power rear window by moving the window to the fully open, vent, then fully closed positions. If the window does not operate correctly, carefully
repeat this procedure.