Professional Documents
Culture Documents
Mock Test
1)
How will you calculate the flight time, as per the aircraft rule?
1) Flight time means the total flight time from the moment the aircraft leaves
from the ground till it makes a touch-down at its destination.
2) Flight time means total flight time from the moment the aircraft first moves
under its own power of take off until the moment it comes to rest at the end of
flight
3) It means block to block time or chock to chock time, which is a measure
from the time the aircraft moves from the loading point until it stops at the
unloading point.
4) Answers (b) & (c) both are correct.
2)
All aeroplanes with valid C of A operated on long range over water flights:1) Shall be equipped with at least one ELT and it should be operated
automatically
2) Shall be equipped with at least two ELTs, one of which shall be automatic.
3) Shall be equipped with three ELTs, if the aeroplane carries more than 250
passengers
4) All the above are correct
3)
4)
C of A of an a/c requires the mandatory things for all flights :1) Owners nameplate, no smoking instruction, weight schedule, first aid kit
2) Owners nameplate, weight schedule and safety harness
3) Owners nameplate, no smoking instruction, cockpit checklist
6)
7)
8)
9)
For issuing of C of A the DGCA has to ensure that the a/c or rotorcraft manufactured
or imported from foreign countries should meet the approved airworthiness standards
according to:1) FAR 23 & FAR 25
2) BCAR 23 & JAR 25
3) FAR 27 & FAR 29
4) All the above answer are correct
10)
All a/c registered in India posses current and valid C of A before it is flown is
requirement as per:-
1)
2)
3)
4)
IAR 50
IAR 50 A
IAR -30
IAR -15
11)
Airworthiness Directive (A.D) means:1) An instruction issued by an airworthiness authority which requires a
modification
2) An airworthiness authority makes an instruction which amends an approved
documents
3) An instruction issued by an airworthiness authority to keep the a/c an a/c
components in an airworthy condition
4) All the above are correct
12)
Noise standards acceptable in India for issuance of Indian C of A are :1) Same as required for issuance of UK C of A
2) Same as required for issuance of US C of A
3) Same as required for issuance of ICAO rules
4) Same as required in JAR 31
13)
If the airworthiness officer completes the final inspection of the aircraft and its
documents after the expiry of the C of A then the validity of the next C of A will
1) Start from the expiry of the last C of A
2) Start from the date of inspection
3) Start from the date of submitting the application
4) All the above are correct
14)
15)
2) The detailed maintenance records to show that all requirements for signing of
a maintenance release this records shall be preserved fro a minimum period
of one year after the signing of the maintenance release
3) The records of appropriate details of modifications and repairs to the
aircrafts and its major components shall be preserved for a minimum period
of 6 months after the unit has been permanently withdrawn from service
4) Answers a) and b) both are correct
16)
An a/c not fitted with navigation lights, can not be flown :1) Without permission from DGCA
2) Without written permission from Control Tower
3) During night hours
4) Either during day or night hours
17)
Rules 5 of the IAR 1937 requires that:1) Any person who is the higher authority of DGCA India shall fly or assist in
flying any a/c which has been registered in India
2) No person shall fly or assist in flying any a/c unless it has been registered
and bears its nationality and registration mark and the name and residence
of the own affixed or painted there on in accordance with rules 37
3) No person shall fly or assist in flying any a/c unless it is registered and
registration mark affixed there on in accordance with rules 39
4) All answers are in correct
18)
To ensure a safe operation in flight of an a/c, the flight crew takes some necessary action
& performs through a list containing items of inspection. This is the
1) Safety list for safe operation of an aircraft
2) Cockpit checklist readily accessible to the flight crew in flight
3) Check list of check cockpit instruments
4) Emergency checklist to be referred at the time of emergency only
19)
20)
An IFR flight when flying over high terrain or in mountainous regions shall maintain at
least
1) 2000 ft above the highest obstacle located within 8 km
2) 2000 ft above the highest obstacle located within 5 km
3) 1000 ft above the highest obstacle located within 8 km
4) None of the above are correct
21)
22)
An aircraft which is being exported to India via fly should:1) Display foreign nationality and registration marking
2) Display Indian nationality and registration marking
3) Have ferry flight authorization
4) None of the above are correct
23)
Arms down with palms towards ground, then either right or left hand waved up
indicates that :1) Slow down motor on right side
2) Slow down motor on left side
3) Slow down motor on indicated side
4) Answers (b) and (c) are both correct
24) Certificate of manufacture is issued by
1) Licensed person
2) An authorized person
3) QCM
4) 2 or 3
32) The divider card and tab in the section ( of flight manual) dealing with
emergency procedure should be in ______ colour
a. Blue
b. Green
c. Red
d. Purple
33) Which is / are, among the following, failure preventive process
a. Hard time
b. Or condition
c. Condition monitoring
d. Both 1 and 2
a.
b.
c.
d.
40) For experimental / Amateur built aircraft the flight test area will be assigned
by
a. RAO
b. Aerodrome officer
c. Airport Authority of India
d. Air Traffic Controller
41) Over hauling agency shall preserve engine overhaul record, particularly of
failed engines at least for
a. One year
b. Two year
c. Five year
d. Ten year
42) The fuel from the barrels should not be drawn for sampling from a depth
lower than _________ from the barrel bottom
a. 2 inch
b. 3 inch
c. 4 inch
d. 6 inch
43) Large aircraft means an aircraft, classified as an aero plane with maximum
Take off mess of
a. Less than 5700 kg, or multiengine helicopter
b. More than 5700 kg or single engine helicopter
c. Less than 5700 kg or single engine helicopter
d. More than 5700 kg or multi engine helicopter
44) Corrective maintenance as a result of Pilot Defect Report (PDR) is
a. Schedule maintenance
b. Un schedule maintenance
c. Hard time maintenance
d. On condition maintenance
45) An AME after releasing the aircraft, invoking the MEL, shall
a. Inform the pilot of the same aircraft
b. Make a mention of it in the technical log
c. Placard the inoperative system suitably
d. Do all actions mentioned above
a.
b.
c.
d.
FAA TSO C 91 a
FAA TSO C 119
TSO C 51 a
TSO C 84
56) The AMO shall retain the record of certifying staff / support staff after have
ceased employment for
a. Not exceeding one year
b. At least two year
c. Not exceeding two year
d. At least one year
57) State Government aircraft can be registered in
a. Normal category
b. Normal category passenger
c. Category A
d. Category B
58) Inspection schedules will be prepared by QCM of the organization in case of
a. Schedule operator with less than 3 yrs of experience
b. Schedule operator with 3 yrs of experience
c. As in 1 and shall be approved by RAO
d. As in 2 and shall be approved by RAO
71) The responsibility of recording the results of Test Flight lies entirely with
1) PIC (Pilot in-command)
2) Co-pilot
3) Flight engineer
4) AME
72) Reweighing of an aircraft having AUW less than 2000 kg
1) In every C of A renewal
2) In every three years
3) Need not be reweighed on routine basis
4) In every overhaul
73) The First Aid Kit container carried on aircraft shall be of
1) White background with red cross
2) Red background with white cross
3) Green background with white cross
4) White background with green cross
74) Document to be carried by all aircraft on all flight is / are
1) C of R & C of A
2) JLB & MEL
3) Operations manual and as mentioned in (a)
4) All of the above are correct
75) Airborne communication system includes
1) VHF, HF, CVR, FDR Audio equipment
2) VHF, HF, VLF/ Omega ADF, audio equipment
3) VHF, HF, CVR, audio equipment
4) VHF, HF, VOR, ILS, audio equipment
76) For taxing an aircraft, a person having AME cat C license should possess
1) RT license if required
2) Qualified to use radio communications
3) As (1) & (2) and should know layout of aerodrome
4) None of the above is required
77) Recent experience means experience acquired in the preceding
1) 24 months
2) 12 months
3) 6 months
4) 3 months
78) Grant of Open AME licences contained in
1) CAR sec 2, series L part VII
2) CAR sec 2, series L part VI
3) CAR sec2, series L part V
4) CAR sec 2, series L part IV
79) Installation of ignition apparatus installed on light aircraft may be done by
1) Cat C license holder
2) Cat X (Electrical system) licence holder
3) Either (1) or (2)
4) None of the above
80) AMEs shall submit their license for renewal at least
1) 7 days before expiring
2) 15 days before expiring
3) 30 days before expiring
4) None is correct
81) Approval for persons engaged in overhaul and major repair is valid for
1) 3 months
2) 6 months
3) 12 months
4) 24 months
82) Application for grant of Authorization to an AME/ Approved person is
forwarded to
1) QCM
2) RAO / Sub RAO
3) DGCA
4) Chief Engineer
83) The licence of AMEs who are working abroad will be renewed
1) By the Airworthiness authority of the country where they are working
2) By the Airworthiness authority of the country where they are working in
consultation with the DGCA Hqrs
1)
2)
3)
4)
100) Rubber seals which have been stored for more than four years should be
checked for deterioration by stretching the seal to
1) 10% of their internal diameter and seeing for crack under X 10 magnification
2) 10% of their external diameter and seeing for crack under X 10 magnification
3) 10% of their external diameter and seeing for crack under X 10 magnification