Professional Documents
Culture Documents
Student Name: . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Student ID: . . . . . . . . . . . . . . . . . . . . . . . . . . .
Instructions:
Use the space to explain your answer and no loose papers will be allowed. Use back of
the page if you need more space.
Write your answers systematically including every steps of your calculation.
Write your final answer with specific significant digit and do not forget to write the
units.
Full points will be awarded only if all steps
and correct units are written.
Useful Equations:
(
V ,
R
3. Which circuit is represented by the frequency response curve in the given figure?
1mark
(A)High-pass filter
(B)Low-pass filter
(C)Band-stop filter
(D)Band-pass filter
(B) Frequency
(C)Voltage and Current
(D)Voltage
(E)Current
[12.5 Points]
1. By Using the following table starting from the resonant frequency [6points]
(
fo- 200=
fo- 100=
fo=
fo +100=
fo +200=
Vin
Vout
Gain
2. Plot Graph by using the table above to plot versus f on a graph paper, (i.e. f
on the X-axis, and along the Y-axis). Do not forget to put the titles and units on the
axes.
[3 points]
3. Use the above table to determine the capacitance of the unknown capacitor C,
Use the necessary formulae given on first page. Given the circuit that is used to
study the RLC circuit behavior. The value of the load resistance is 10.0 0.1 ,
while the inductance is depending on the coil geometry given value of L =
0.5mH.
[3.5 points]
[12.5 Points]
1. Set the current at the values listed in the table given below and measure the
corresponding needle deviation angle (the current values may be change if they are not
suitable for your setup). Estimate the error on and .
[5 points]
Tan( )
0.10
0.15
0.25
[4 points]
Extra Page