Professional Documents
Culture Documents
INDOOR UNIT
OUTDOOR UNIT
Thank you very much for purchasing CARRIER Air Conditioner. Please read this
owners manual carefully before using your Air Conditioner.
PN PE630728
CONTENTS
TECHNICAL SPECIFICATIONS
6-7
MAINTENANCE
8-9
10-16
TROUBLESHOOTING GUIDE
17
TECHNICAL SPECIFICATIONS
IV. MAINTENANCE
10
Fan
If the system is in FAN mode, the FAN LED on the Display unit will be lit.
The system will operate as the fan only. The TEMP and TEMP buttons
are not used.
V2.3.2 Cool
If the system is set to COOL mode, the COOL LED on the Display unit will
be lit. The system will operate as the air conditioner. The compressor will
However, there is a 3-minute delay protection on the compressor each time it stops.
V2.4
Temperature setting
Temperature can be set from 18 - 30C by pressing TEMP or TEMP
button. The LCD Display will show the set temperature.
V2.5
Sweep
Press SWEEP button to turn the sweep motor ON or OFF.
11
COMPRESSOR
3.1.4
Temperature sett
ON
V3.1.5
OFF
V3.1.6 Sleep
LOW FAN
8 Min.
4 Min.
8 Min.
:
ON
OFF
12
V3.1.7
Press
V3.1.8
Press
V3.1.9 Auto Stop : The air conditioner can be programmed to turn off at a
pre-set time.
Press
13
V3.2
V3.3
V4.5
Self-Diagnostic Function
The control system comes with a self-diagnostic function.
If a malfunction is detected, the LED Display will show the following alarms:
blinking if the room sensor is open or short circuited .
blinking if the freeze sensor is open or short circuited.
14
TROUBLESHOOTING GUIDE
PROBLEM
Unit does not start
POSSIBLE CAUSES
Circuit breaker tripped
SOLUTION
Reset only once. Should
the unit trip again do not
attempt to reset it again.
Contact your Carrier
service center for
assistance.
a. Clean air filter.
b. Reset to desired
temperature.
c. Switch the setting into
cool mode
d. Press sleep button
Clean the drain pan and
drain line.
Replace controller with
new battery of the same
specs.
15