Professional Documents
Culture Documents
constructive solutions
Properties
:
:
:
:
:
Typical result
2300 kg/m
< 600 microstrain
> 40 N/mm2 at 3 days
> 45 N/mm2 at 7 days
> 55 N/mm2 at 28 days
5,000 - 10,000 ohm-cm
< 0.1% by weight of
cement
< 4% by weight of
cement
< 3.5 kg/m
Advantages
eMortar FC200, in addition to controlled electrical resistivity,
features Dimensional Stability Technology (DST) - a new
materials technology which controls the rate of drying
shrinkage such that, when used correctly :
i. The dimensions of the installation/repair remain stable;
and thus
ii. Eliminating structure failure, due to installation shrinkage
cracking.
iii. Ensures even current distribution when used with CP
systems as cracking is eliminated.
Design criteria
Attention to the basic design criteria given below should
ensure that the full benefits of DST technology are gained in
use:
Description
eMortar FC200 is supplied as a ready to use blend of dry
powders and selected aggregates, which requires only the
addition of clean water to produce a highly consistent, fluid
microconcrete suitable for all electrochemical system
installation and structural repairs.
Page 1
eMortar FC200
Estimating
Supply
eMortar FC200
Fire
20 kg bags
Yield
eMortar FC200 :
9.7 litres/20 kg bag (approx)
Note : Allowance should be made for wastage when
estimating quantities required.
Limitations
Additional Information
Storage
Shelf life
eMortar FC200 has a shelf life of 12 months if kept in a dry
environment, in its original packing. If stored in conditions of
high temperature and/or humidity, the shelf life may be
reduced to as little as 4 months.
Precautions
During use, avoid inhalation of the dust and contact with the
skin or eyes. Wear suitable protective clothing eye
protection, gloves and respiratory equipment (particularly in
confined spaces).
The use of barrier creams to provide additional skin
protection is also advised. In case of contact with the skin,
rinse with plenty of clean water, then cleanse thoroughly
with soap and water.
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/eMortar FC200/05/A