Professional Documents
Culture Documents
constructive solutions
Properties
Form:
Flash point:
Colour:
Movement accommodation
factor:
Skinning time at 20oC per
50% RH:
Cure rate at 20oC
50% RH:
Advantages
Good adhesion
contaminant.
to
silicone,
PU,
Polysulphide
Application temperature:
Typical hardness
Shore A at 20oC:
Trafficking time at 20oC:
Light traffic
Heavy traffic
Modulus:
UV resistance:
Paste
> 65oC
White, Grey, Black,
Portland, Buff, Rustic
Red, Brown
Butt joint 25%
Lap joints 50%
25 minutes
24 hours 3 mm
48 hours 6 mm
72 hours 8 mm
5oC to 50oC
45
24 hours
4 days
High
Excellent
Application instructions
Preparation
Design criteria
Nitoseal MS300 may be applied between 6 mm and 20
mm wide, for trafficked joints (up to 40 mm non-trafficked).
In most cases it is recommended to form a sealing slot
with a square cross-section, subject to minimum 10 mm
depth. To ensure the sealant operates within its stated
movement accommodation capacity the sealing slot
widths should be designed in accordance with the
recommendations of BS6093.
Page 1
Nitoseal MS300
Priming
Estimating
Metres per
600 ml sachet
0.06
0.12
0.40
0.30
0.45
0.80
10.000
5.000
1.500
2.000
1.330
0.751
Precautions
Cut end off sachet and place in Fosroc GX Gun. Fit nozzle
and cut at 45o to a suitable size. Extrude the sealant firmly
into the joint. Tool flush within 5 minutes of application to
ensure good contact between the sealant and the substrate.
Cleaning
Storage
Limitations
Storage conditions
Packaging
Nitoseal MS300:
Fosroc Primer 19:
Additional information
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/Nitoseal MS300/05/A