Professional Documents
Culture Documents
Trademarks
Overview
123-
3.0
1.
2.
4.0
1-
Housing notch
EU
AU
NZ
EU
AU
NZ
NZ
EU
1.0
Description
Double-button, necklace pendant transmitter
Single-button, necklace pendant transmitter
Double-button, belt-clip pendant transmitter
Single-button, belt-clip pendant transmitter
AU
Model Number
ISW-EN1233D
ISW-EN1233S
ISW-EN1235D
ISW-EN1235S
You must register the transmitter with the system in order for the
transmitter to be monitored and supervised.
When the transmitter is supervised, it sends a check-in message to
the serial receiver or network coordinator every three minutes.
Each transmitter has a unique factory-programmed identification
number. Refer to the receivers documentation for details on
registering a transmitter.
When prompted by the receiver to reset the transmitter, press the
Reset button on the transmitter. Refer to Figure 2.
Test the transmitter after it is registered with the
system.
To test the transmitter, activate each of the
conditions and ensure an appropriate response.
123-
Reset button
Frequency Band pins
Battery
5.0
5.1
5.2
2
123-
5.3
Back of housing
Belt clip
Supplied belt loop screw
6.0
Specifications
Power Requirement:
3 VDC at 60 mA
Operating Temperature:
Relative Humidity:
Up to 90% (non-condensing)
Battery Type:
3 to 5 years
Compatible Receivers:
F01U126793-01
Installation Guide
3/09
ISW-EN1233/1235
Page 2 of 2