Professional Documents
Culture Documents
INTRODUCTION: Isolators and Circulators are usually three port devices, and they are
used to force the microwave energy into one direction only. The typical junction Circulator
consists of a stripline circuit, sandwiched between two ferrite discs or triangles, an upper and
a lower ground plane, magnetically biased by permanent magnets located outside the ground
planes. In a Circulator, the magnetic field, applied through the vertical axis of the assembly,
results into a circulation of the microwave energy from one port to the other, depending on
where the energy is coming from.
Microwave energy entering the device from port J1 is directed
Port J3
to port J2. Energy entering from port J2,is directed to port J3.
Signals entering from port J3, are directed to port J1, etc. If
one of the ports is terminated into a 50 Ohms load, the device
becomes an Isolator. Signals then only can pass the unit with
low loss in one direction, and only with high loss in the reverse
direction. If e.g. port J3 is terminated into a 50 Ohms line,
microwave energy only can pass the device with low loss from
Port J1
Port J2
port J1 to port J2. An Isolator is used to "isolate" microwave
components from each other, or to protect units from receiving damages when working into
an open or short circuit. The output of an oscillator is usually protected by an isolator.
Frequency and Bandwidth: Coaxial and microstrip circulators and isolators operate either
in the bias region above resonance or below resonance. Above-resonance circuits are usually
used for smaller bandwidths and higher power designs, while below-resonance circuits achieve
wider bandwidths. Theoretically, the above-resonance circuits have no lower frequency limit.
Operating Temperature: The performance depends on the magnetic field, applied to saturate
the ferrite material. Temperature compensated magnets and ferrites need to be used where
wide temperature ranges are required. Internal heaters can be installed, where temperature
range and ferrite material do not allow other compensation.
Four Port Devices: Four Port Circulators and Isolators are used where higher directivity is
needed. An Isolator would have the ports J3 and
Port J4
Port J3
J4 terminated. In the schematic to the left,
microwave energy is forced from port J1 to J2,
or from port J3 to port J4, when crossing two
ferrite junctions. The high isolation only applies
when two ferrite junctions have been crossed, here
between ports J2 and J1 with ports J3 and J4
Port J1
Port J2 terminated with matched loads.
6
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir1.pm6
Input VSWR: The input VSWR is a function of the VSWR of the other ports. At an isolator
the higher output VSWR will cause reflected energy towards the terminated port, where it
will be attenuated by the value of the isolation, and the balance is reflected back to the input,
increasing the input VSWR.
e:\cir-is99\iso-cir1.pm6
Designing Components to
Customer Specifications!
Circulators for High Power Applications &
Smallest Devices for Employment as "Drop In".
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
18 db
20 db
20 db
20 db
20 db
20 db
20 db
20 db
0.5 dB
0.5 dB
0.5 dB
0.5 dB
0.5 dB
0.5 dB
0.5 dB
0.5 dB
VSWR
max.
Power
Fwd/Rev
1.30 : 1
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
5w /1w
5w /1w
5w /1w
5w /1w
5w /1w
5w /1w
5w /1w
5w /1w
Dimensions
(inches)
(mm)
.375x.62x.21
.375x.62x.21
.375x.62x.21
.375x.62x.21
.375x.62x.21
.375x.62x.21
.375x.62x.21
.375x.62x.21
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
9.5x15.8x5.3
Drawing
Number
101
101
101
101
101
101
101
101
Note: The models listed above are isolators. On special request certain units may be available as circulators.
VSWR
max.
Power
Fwd/Rev
18 db
0.5 dB
1.30 : 1
5w /1w
IS-078085-X6 7.8 to 8.5
20 db
0.5 dB
1.25 : 1
5w /1w
IS-117122-X6 11.7 to 12.2
20 db
0.5 dB
1.25 : 1
5w /1w
IS-127132-X6 12.7 to 13.2
20 db
0.5 dB
1.25 : 1
5w /1w
IS-140145-X6 14.0 to 14.5
18 db
0.7 dB
1.30 : 1
5w /1w
IS-177197-X6 17.7 to 19.7
18 db
0.7 dB
1.30 : 1
5w /1w
IS-212236-X6 21.2 to 23.6
17 db
0.8 dB
1.35 : 1
5w /1w
IS-240260-X6 24.0 to 26.0
Note: The models listed above are isolators. On special request certain
Note:
True surface mount
configurations are
available (zero tab offset)
Tabs are .05 long, .020
wide, and .005 thick
Dimensions
(inches)
(mm)
.250x.50x.17
.250x.50x.17
.250x.50x.17
.250x.50x.17
.250x.50x.17
.250x.50x.17
.250x.50x.17
6.4x12.7x4.3
6.4x12.7x4.3
6.4x12.7x4.3
6.4x12.7x4.3
6.4x12.7x4.3
6.4x12.7x4.3
6.4x12.7x4.3
Drawing
Number
100
100
100
100
100
100
100
units may be available as circulators.
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir1.pm6
Model
Number
Power
Fwd/Rev
Dimensions
(inches)
(mm)
Drawing
Number
23 db
0.4 dB
1.20 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
207
IS-M80M82-ZC .800 to .823
23 db
0.4 dB
1.20 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
IS-M82M84-ZC .824 to .849
207
23 db
0.4 dB
1.20 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
207
IS-M86M89-ZC .869 to .894
20 db
0.5 dB
1.25 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
207
IS-M89M96-ZC .890 to .960
23 db
0.4 dB
1.20 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
207
IS-M90M94-ZC .900 to .943
23 db
0.4 dB
1.20 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
207
IS-M93M96-ZC .935 to .960
20 db
0.3 dB
1.25 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
IS-012014-ZC 1.2 to 1.4
207
20 db
0.4 dB
1.25 : 1 200w /10w 1.0x1.0x.30 25.4x25.4x7.62
IS-014017-ZC 1.4 to 1.7
207
Note: The models listed above are isolators. To request the corresponding circulator model change the IS to CI.
Power
Fwd/Rev
Dimensions
(inches)
(mm)
Drawing
Number
23 db
0.3 dB
1.20 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-017018-ZB 1.71 to 1.85
203
20 db
0.4 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-017019-ZB 1.71 to 1.99
203
23 db
0.3 dB
1.20 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-018019-ZB 1.85 to 1.99
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-019022-ZB 1.95 to 2.20
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-020023-ZB 2.0 to 2.3
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-021024-ZB 2.1 to 2.4
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-023025-ZB 2.3 to 2.5
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-025027-ZB 2.5 to 2.7
203
20 db
0.5 dB
1.25 : 1 200w /10w .75x.75x.25 19.05x19.05x6.35
IS-027029-ZB 2.7 to 2.9
203
Note: The models listed above are isolators. To request the corresponding circulator model change the IS to CI.
Power
Fwd/Rev
Dimensions
(inches)
(mm)
Drawing
Number
e:\cir-is99\iso-cir1.pm6
18 db
0.5 dB
1.30 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-036043-ZA 3.6 to 4.3
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-044050-ZA 4.4 to 5.0
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-054059-ZA 5.4 to 5.9
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-058065-ZA 5.8 to 6.5
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-064072-ZA 6.4 to 7.2
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-071079-ZA 7.1 to 7.9
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-079085-ZA 7.9 to 8.5
201
20 db
0.5 dB
1.25 : 1 30w /10w .50x.50x.21 12.7x12.7x5.33
IS-140145-ZA 14.0 to 14.5
201
Note: The models listed above are isolators. To request the corresponding circulator model change the IS to CI.
ZC
ZB
ZA
Tabs are
.07 long,
.025 wide,
and
.005 thick
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
Model
Number
20 db
20 db
20 db
20 db
20 db
0.4 dB
0.4 dB
0.4 dB
0.4 dB
0.4 dB
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
1.25 : 1
75w/10w
75w/10w
75w/10w
75w/10w
75w/10w
Dimensions
(inches)
(mm)
Drawing
Number
1.25x1.25X.75 31.75x31.75x19.05
1.25x1.25X.75 31.75x31.75x19.05
1.25x1.25X.75 31.75x31.75x19.05
1.25x1.25X.75 31.75x31.75x19.05
1.25x1.25X.75 31.75x31.75x19.05
Dimensions
(inches)
(mm)
308
308
308
308
308
Drawing
Number
23 db
0.3 dB
1.15 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-017018-CS 1.7 to 1.85
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-017020-CS 1.7 to 2.0
23 db
0.3 dB
1.15 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-018020-CS 1.85 to 2.0
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-019022-CS 1.95 to 2.2
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-020023-CS 2.0 to 2.3
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-021024-CS 2.1 to 2.4
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-023027-CS 2.3 to 2.7
20 db
0.4 dB
1.25 : 1 75w/10w 1.00x1.00x.63 25.4x25.4x16.0
IS-027030-CS 2.7 to 3.0
Note: The models listed above are isolators. To request the corresponding circulator model change the
Model
Number
Dimensions
(inches)
(mm)
Drawing
Number
23 db
0.3 dB
1.15 : 1 10w /2w .75x.75x.50 19.05x19.05x12.7
IS-036043-BS 3.6 to 4.3
23 db
0.3 dB
1.15 : 1 10w /2w .75x.75x.50 19.05x19.05x12.7
IS-044050-BS 4.4 to 5.0
23 db
0.3 dB
1.15 : 1 10w /2w .75x.75x.50 19.05x19.05x12.7
IS-054059-BS 5.4 to 5.9
23 db
0.3 dB
1.15 : 1 10w /2w .75x.75x.50 19.05x19.05x12.7
IS-058065-BS 5.8 to 6.5
20 db
0.4 dB
1.25 : 1 10w /2w .75x.75x.50 19.05x19.05x12.7
IS-064085-BS 6.4 to 8.5
Note: The models listed above are isolators. To request the corresponding circulator model change the
Model
Number
Dimensions
(inches)
(mm)
305
305
305
305
305
305
305
305
IS to CI.
302
302
302
302
302
IS to CI.
Drawing
Number
301
301
301
301
301
IS to CI.
e:\cir-is99\iso-cir1.pm6
20 db
0.4 dB
1.25 : 1 5w /1w
.50x.57x.39 12.7x14.48x9.91
IS-080124-AS 8.0 to 12.4
0.5 dB
1.15 : 1 60w /1w .50x.57x.39 12.7x14.48x9.91
IS-100150-AS 10.0 to 15.0 23 db
0.3 dB
1.15 : 1 10w /1w .50x.57x.39 12.7x14.48x9.91
IS-140145-AS 14.0 to 14.5 23 db
0.5 dB
1.25 : 1 5w /1w
.50x.57x.39 12.7x14.48x9.91
IS-177197-AS 17.7 to 19.7 20 db
0.5 dB
1.25 : 1 5w /1w
.50x.57x.39 12.7x14.48x9.91
IS-212236-AS 21.2 to 23.6 20 db
Note: The models listed above are isolators. To request the corresponding circulator model change the
10
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
.17"
4.32
.070"
1.78
.125"
3.18
.25"
6.35
.250"
6.35
.380"
9.65
.50"
12.7
.12"
3.05
.04"
1.02
.087 thru
2.21
R .070"
1.78
.375"
9.53
.060"
1.52
.087 thru
2.21
.405"
10.29
.38"
9.65
.500"
12.7
.62"
15.75
R .050"
1.27
.12"
3.05
.04"
1.02
.255"
6.48
e:\cir-is99\iso-cir2.pm6
.21"
5.33
.070"
1.78
11
.380"
9.65
.21"
5.33
.070"
1.78
Tabs are .07" long, .020"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.508mm wide & .127mm
.025mm thk.
.060"
1.52
.330"
8.38
.380"
9.65
.500"
12.7
.060"
1.52
R .075"
1.91
.380"
9.65
.21"
5.33
.070"
1.78
Tabs are .07" long, .020"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.508mm wide & .127mm
.025mm thk.
.060"
1.52
.330"
8.38
.380"
9.65
.500"
12.7
.060"
1.52
Flush
Termination
R .075"
1.91
.125"
3.18
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
.505"
12.83
.570"
14.48
.750"
19.05
.090"
2.29
R .100"
2.54
12
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
.101 thru
2.57
.25"
6.35
.570"
14.48
.25"
6.35
.125"
3.18
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
.505"
12.83
.570"
14.48
.750"
19.05
.090"
2.29
Flush
Termination
R .100"
2.54
.750"
19.05
.101 thru
2.57
.570"
14.48
.125"
3.18
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
.505"
12.83
.570"
14.48
.750"
19.05
.090"
2.29
R .06"
1.52
.750"
19.05
.101 thru
2.57
.570"
14.48
.125"
3.18
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
e:\cir-is99\iso-cir2.pm6
R .06"
1.52
.505"
12.83
.570"
14.48
.750"
19.05
.090"
2.29
Flush
Termination
13
.30"
7.62
.820"
20.83
.150"
3.81
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
.695"
17.65
1.00"
25.4
.820"
20.83
.090"
2.29
R .100"
2.54
.30"
7.62
.820"
20.83
.150"
3.81
Tabs are .07" long, .025"
wide & .005" .001" thk.
Tabs are 1.78mm long,
.635mm wide & .127mm
.025mm thk.
.090"
2.29
.695"
17.65
.820"
20.83
1.00"
25.4
.090"
2.29
Flush
Termination
R .100"
2.54
.50"
12.7
.340"
8.64
.39"
9.91
.375"
9.53
0.10" deep
2.54 far side
SMA
Female
14
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
Marking
near side
.57"
14.48
SMA
Female
SMA
Female
.19"
4.83
.08"
2.03
.50"
12.7
.39"
9.91
.08"
2.03
.340"
8.64
.19"
4.83
.57"
14.48
SMA
Female
.375"
9.53
SMA
Female
0.10" deep
2.54 far side
.17"
4.32
Marking
near side
Termination
.38"
9.65
.50"
12.7
.09"
2.29
.570"
14.48
.75"
19.05
SMA
Female
.500"
12.7
SMA
Female
.25"
6.35
0.13" deep
3.30 far side
.17"
4.32
Marking
near side
Termination
.38"
9.65
.51"
12.95
.50"
12.7
.09"
2.29
.570"
14.48
.25"
6.35
0.13" deep
3.30 far side
IN
OUT
.500"
12.7
SMA
Male
e:\cir-is99\iso-cir2.pm6
Marking
near side
.75"
19.05
SMA
Female
.17"
4.32
Termination
15
1.00"
25.4
.38"
9.65
.13"
3.30
.750"
19.05
SMA
Female
SMA
Female
OUT
IN
1.00"
25.4
0.16" deep
4.06 far side
.625"
15.88
.125"
3.18
Marking
near side
SMA
Female
.38"
9.65
.63"
16.0
1.00"
25.4
.750"
19.05
.13"
3.30
SMA
Female
0.16" deep
4.06 far side
.625"
15.88
1.00"
25.4
SMA
Female
.125"
3.18
.17"
4.32
Marking
near side
16
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
Termination
1.00"
25.4
.38"
9.65
.13"
3.30
.750"
19.05
SMA
Female
SMA
Female
OUT
IN
1.00"
25.4
0.13" deep
3.30 far side
.582"
14.78
.168"
4.27
.17"
4.32
Marking
near side
Termination
SMA
Female
.75"
19.05
.13"
3.30
0.2" deep
5.1 far side
SMA
Female
.875"
22.23
1.25"
31.75
1.00"
25.4
1.25"
31.75
.38"
9.65
.125"
3.18
Marking
near side
e:\cir-is99\iso-cir2.pm6
SMA
Female
17
.13"
3.30
.875"
22.23
0.20" deep
5.1 far side
SMA
Female
1.25"
31.75
SMA
Female
.75"
19.05
1.25"
31.75
1.00"
25.4
.38"
9.65
.125"
3.18
Marking
near side
.17"
4.32
Termination
.80"
20.32
1.610"
40.89
.38"
9.65
.24"
6.1
1.125"
28.58
IN
Marking
near side
OUT
.250"
6.35
SMA
Female
18
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
0.18" deep
4.57 far side
1.60"
40.64
1.070"
27.18
SMA
Female
SMA
Female
1.610"
40.89
.38"
9.65
.24"
6.1
1.125"
28.58
SMA
Female
SMA
Female
IN
OUT
1.60"
40.64
0.18" deep
4.57 far side
1.070"
27.18
.250"
6.35
Marking
near side
.17"
4.32
Termination
2.75"
69.85
2.250"
57.15
SMA
Female
.25"
6.35
SMA
Female
0.22" deep
5.59 far side
1.970"
50.04
1.00"
25.4
Marking
near side
.280"
7.11
e:\cir-is99\iso-cir2.pm6
1.38"
35.05
.50"
12.7
2.75"
69.85
.38"
9.65
.17"
4.32
Termination
19
Bandwidth
10 %
Isolation min.
20 dB
VSWR max.
1.25 dB
1.2 dB
Temperature
-10...+60C
Power max.
50 W
Connectors
Dimensions
mm
67 x 53 x 28
inches
Dimensions shown are inches over millimeters. All the products of Spectrum Elektrotechnik GmbH are designed and manufactured in accordance
to MIL-I-45208A. Each unit is individually tested to verify conformance with all the specifications. Specific test data are available upon request.
For more information please contact our sales or engineering department, or our representatives, as listed in the end of this Handbook.
20
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
Frequency MHz
3 - Port - Circulator
Frequency GHz
1.0 - 2.0
Bandwidth
20 %
Isolation min.
19 dB
VSWR max.
1.25 dB
0.3 dB
Connectors
e:\cir-is99\iso-cir2.pm6
Dimensions
77 x 88 x 32
inches
Dimensions shown are inches over millimeters. All the products of Spectrum Elektrotechnik GmbH are designed and manufactured in accordance
to MIL-I-45208A. Each unit is individually tested to verify conformance with all the specifications. Specific test data are available upon request.
For more information please contact our sales or engineering department, or our representatives, as listed in the end of this Handbook.
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
21
4 - Port - Circulator
Frequency GHz
1.0 - 2.0
Bandwidth
20 %
Isolation min.
19 dB
VSWR max.
1.25 dB
0.3 dB
Dimensions
140 x 88 x 32
inches
Dimensions shown are inches over millimeters. All the products of Spectrum Elektrotechnik GmbH are designed and manufactured in accordance
to MIL-I-45208A. Each unit is individually tested to verify conformance with all the specifications. Specific test data are available upon request.
For more information please contact our sales or engineering department, or our representatives, as listed in the end of this Handbook.
22
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
e:\cir-is99\iso-cir2.pm6
Connectors
3 - Port - Isolator
Frequency GHz
1.0 - 2.0
Bandwidth
20 %
Isolation min.
19 dB
VSWR max.
1.25 dB
0.3 dB
Connectors
e:\cir-is99\iso-cir2.pm6
Dimensions
140 x 160 x 32
inches
Dimensions shown are inches over millimeters. All the products of Spectrum Elektrotechnik GmbH are designed and manufactured in accordance
to MIL-I-45208A. Each unit is individually tested to verify conformance with all the specifications. Specific test data are available upon request.
For more information please contact our sales or engineering department, or our representatives, as listed in the end of this Handbook.
Spectrum Elektrotechnik GmbH P.O. Box 45 05 33, 80905 Munich, Germany Tel. (89) 354 804-0, Fax (89) 354 804-90 (Country Code: 49)
23
Int
d?
e
t
s
to
ere
efer ook
r
e
b
s
Plea 8 Handnts
'9
e
The ompon
C