Professional Documents
Culture Documents
Gas pressure low fault is related to which part in Linac? Gun, Waveguide (has
filled SF6 gas), Magnetron, Accelerating tube, etc.
waveguide: most everything else is vaccuum, sf6 acts as insulator so no arcing in waveguide
Multi detector CT, when cone beam increases size, whats true: Collimator
decreases, scatter photon increases, etc
Scatter Increases
both true, collimator opening must increase to expose more detectors,
scattered photons increase due to larger fluence/area, but your mA decreases
(larger area) so image quality decreases
If the high voltage power source is pushing too much, what is the most likely
observed result on the accelerator
HVOC. (UDR) Dose rate
too fast of pulses=higher rep rate, too high voltage = higher gun voltage and
high klystron voltage = more e- to accel and either (not sure) higher energy
waveguide or maybe no waveguide due to loss of harmonics (Ghz change)
If the collimator rotation is off 1.2mm, the couch rotation is off 1.4mm and the
gantry rotation is off 1.5, according to AAPM what is the overall uncertainty?
[(1.2)^2+(1.4)^2+(1.5)^2]^0.5
I should know this. its either the sqrt of the sum of the sqrs or the largest
number is the radius of the sphere, ill check the mobius manual or a winstonlutz algorithm spec
To increase the energy in the accelerator, what you do? Increase the current in
the magnetron, or Increase the voltage in the magnetron, Increase the current
in the Thyratron, or, increase the current to the Gun
(Magnetron current), increase current in mag increases energy of wave which
increases energy of electrons..