You are on page 1of 2

3D Profiler

3D Profiler Release Report


Version 12.4 (Hotfix 3)
28/01/2009
Issues Fixed in Hotfix 3
Rafters and Purlins Object
Rafter and purlin end cuts fail
The lower end cut is not actually controlling the lower end cut of the rafter, it is controlling the purlin right end cut.
Extruded Profiles
Mirrored Profiles get Edge Visibility Wrong
When you 'mirror' a profile, the edge visibility doesn't get flipped.
Version 12.3 (Hotfix 2)
18/11/2008
Issues Fixed in Hotfix 2
Rafters and Purlins Object
Purlins are misplaced on Curved Rafters
Purlin placement should always be on top of the rafters.
Extruded Profiles
3D Profiler -- edit mode does not work
Add-on 3D Profiler edit mode does not seem to be working.

Can Alt-Click Extruded Profiles


In the Library Browser you can now ctrl-alt-click one extruded profile to another. For example you can ctrl-alt-click the
settings of an Extruded Interior Trim to a Extruded Steel section. The path is transferred but not the profile of course.

Curved profiles are too slow in 3D


Create a curved profile then wrap it around a curved path. The resulting form takes ages to generate a 3D model due to
the large number of polygons.

Version 12.2 (Hotfix 1)


09/09/2008
Issues Fixed in Hotfix 1
Attributes are not being Applied
Choose a Different Profile
If you selected a new profile type, any subsequent change (eg. a change of material, pen, etc) would get lost. You would have
to open the settings dialog again to make these changes. Now you can choose a different profile and change material and
pens in one shot.

Extrude Along Selected Elements missing attributes


If you draw a poly-line and run the Extrude Along Selected Elements tool, a settings dialog appears. You can change the
attributes (i.e. materials, cut pens..etc). If you do so, these settings were not being applied to the resulting model.

Extruded Purlin Ends Display in the 2D Symbol


The 2D symbol for this object only appeared as a series of parallel lines in Outline View, Hidden Line and Shaded
View.

General Extrusion Missing Last Edge

2008 Cadimage Solutions Ltd.

Page: 1

Design Suite
When you place the Generic Extrusion, the last edge was missing from its path.
Profiler Beam
Beam Depth did not Match the Profile
If you change the profile dimensions, the beam dimensions did not adjust to match.

Beam was Missing in 3D


If you placed a marquee around a beam and viewed in 3D, the beam was missing from the 3D view.

Pitch Angle
If you set a small pitch angle (less than 2) it snapped back to horizontal (0).

Changing Edit Mode Very Slow


This process has been changed to be a lot faster

Version 12.1
07/07/2008

3D Profiler has been upgraded to work in ArchiCAD 12, maintaining the current functionality.

Profile Manager portion of 3D Profiler has been separated into a separate tool so that the Profiler
Technology can be incorporated into other tools

04/08/08: Cannot Register Profile Manager This Issue has now been resolved, Profile Manager is now
registered by the tool it belongs to.

Page: 2

Design Suite
Printed: 2009-01-28

2008 Cadimage Tools Ltd.

You might also like