You are on page 1of 4

EiTEX-BDU

Mid-Term Exam QP

I Semester

EiTEX
BAHIR DAR UNIVERSITY
ETHIOPIAN INSTITUTE OF TEXTILE AND FASHION TECHNOLOGY
Name ________________________________
Program______________________

ID____________________________

Batch first

MID TERM EXAMINATION (40%)-II Year M.Ed (Textile Technology)


Course Name & Course Code: Textile Technology Management (Teng 7071)
Examination Date & Time:

22.12.2015 (Tuesday) 09.00 am.

Examination Room:

B191- Room No: 30

Allocated Time:

1:30 hours (90 minutes)

General Instruction
1.
2.
3.
4.
5.
6.

Write your ID No. on every page


Attempt all the questions and problems(bonus is optional)
Use only the answer paper/question paper to answer all the questions
Do not mix up different parts of questions
Figures to the right indicate full marks.
Must write the answers in sequential order and assume suitable data.

PART- A

Write very

short answers

10 X 1= 10

1. What is meant by an integrated draw frame?

2. What are the two characterizing features of ring spinning?


3. What is the purpose of combing?
4. What is meant by roller drafting?

II Year M.Ed (Textile Technology)

Textile Technology Management

1/4

EiTEX-BDU

Mid-Term Exam QP

I Semester

5. What is meant by an objectionable fault?


6. What is meant by slashing?
7. What is meant by tying-in?
8. What is meant by yarn clearing?
9. What are the principles of electronic yarn clearing?
10. What is meant by the term pre-wetting?
PART- B

Write answers in

detail for any the FIVE questions

5 X 2 = 10

11. What are the modifications of ring spinning?


12. Explain the principle of twist insertion of the open end spinning system?
13. Give the reasons for the success of ring spinning technology?
14. What are the systems used for the identification of foreign fibres?
15. What are the commonly used winding machines in the textile industry?
16. What is meant by headstock? Where will you find them in the textile industry?
17. How will you evaluate the quality of the sized yarns?
PART- C Write answers in

depth and detail for any THREE questions

3X3=9

16. Write down the names of various non-conventional spinning systems.


17. Explain the principle of air jet spinning and compare it with ring and rotor
spinning yarns.
18. Write notes on the process control parameters of sizing.
19. Compare direct warping and sectional warping
20. Write short notes on auto-levelers.
PART- D

Identify the machine/diagram and label the parts of the diagram given here

below. Also, write

explanation about the process and the machine (21, 22, 23

=2 , 4, 5= 11)

II Year M.Ed (Textile Technology)

Textile Technology Management

2/4

EiTEX-BDU

Mid-Term Exam QP

I Semester

21

22

II Year M.Ed (Textile Technology)

Textile Technology Management

3/4

EiTEX-BDU

Mid-Term Exam QP

I Semester

23

II Year M.Ed (Textile Technology)

Textile Technology Management

4/4

You might also like