Professional Documents
Culture Documents
Ground Lesson 8
1. The 100 hour inspection is required to be done because
A) Its a FAA regulation on all aircraft
B) Its a Robinson requirement
C) Its required by the FAA but only for passenger operations
D) B and C
2. A list of preventative maintenance can be found in
A) The FAR/AIM
B) The POH
C) Both
D) Neither
3. Full carburetor heat reduces the hover ceiling by up to.
A) 1000 ft
B) 2000 ft
C) 3000 ft
4. The R-22 is a.
A) Low-inertia rotor system
B) High-inertia rotor system
C) No-inertia rotor system
5. The reference datum is
A) An imaginary vertical line 100 inches in front of the rotor mast
B) An imaginary horizontal line 100 inches in front of the rotor mast
C) An imaginary vertical line 150 inches in front of the rotor mast
6. Fuel weighs:
A) 5lbs per gallon
B) 6lbs per gallon
C) 6lbs per quart
7. Why is minimum gross weight important?
A) Certain weight is needed to allow landing
B) Certain weight is required for even power distribution and level pickup
C) Certain weight is required for successful autorotation
8. Is ground reference required during night flights?
A) No as long as landing lights are in working order
B) No as long as the anti-collision light is illuminated
C) Yes
9. Manifold pressure measures
A) Pressure inside the engine
B) Pressure of air being pulled into the engine
C) Pressure that fuel is sucked into the engine
10.Until what point can a student only fly in winds below 25 knots?
A) Until they pass their commercial exam
B) Until they have 200 hours of which 50 are in the R22
C) Until they have 200 hours of which 100 are in the R22
Ground Lesson 10
1. As a commercial pilot you cannot under 119:
A)
B)
C)
2. As
A)
B)
C)