Professional Documents
Culture Documents
au
PH: 1300-362-393(AUSTRALIA)
GORILLA LADDERS
Code: PLAT-01
the palm buttons fully inward, as indicated in Figure 4. Pull the two halves apart until
the pins on both hinges snap into place and securely lock, (refer to figure 19).
Configurations
1.
Adjustable hinges
2.
Locking pins
3.
4.
5.
Trestle Mode
6.
7.
Additional accessory
8.
Height Adjustment:
Adjust the height of one side of the ladder by pulling the locating pins out of the rung
holes on one sliding section of the ladder. Rest both locking tabs on the side of the
outer ladder (refer to figure 6). Firmly grasp the inner ladder section and carefully
adjust the outer side rail to your desired height. Securely lock both locating pins into
the rung holes (refer to figure 7).
The ladder is properly aligned when the ladder steps are level
as shown by figure 20.
For storage and/or transport, reverse the instructions above.
Never use the ladder in a stairway if steps are not /eve/. This
Page 7.
1. Configurations
6. Trestle Mode
Set-up:
Completely remove the outer rail section on each half
of the ladder. After removing the outer rails, open the
inner ladder assembly to the stepladder (A-frame)
position by pressing the palm buttons fully inward.
Rotate the ladder out until the hinges engage.
); i,
Note: This Is the first of the two trestles needed to use the
II I
r:
jjl
HAZZARDS EXIST.
Page 1.
Page 6.
2. Adjustable Hinges
From the stored position (refer to figure 9), unlock both adjustable hinges by pressing
the palm buttons fully inward, as indicated in Figure 4. Pull the two halves apart until
the pins on both hinges snap into place and securely lock, (refer to figure 12 and 13).
The ladder has two adjustable hinges which allows the user to set-up the ladder in
3 different positions; Storage (figure 1.), A-frame (figure 2.), Extension (figure 3.).
1. TO UNLOCK
Height Adjustment:
To adjust the height of the ladder when it is in the step ladder mode, pull the locating
pins out of the rung holes on one sliding section of the ladder to unlock. Rest
both locking tabs on the side of the outer ladder (refer to figure 6). Firmly grasp the
inner ladder section and carefully adjust the outer side rail to your desired height.
Securely lock both locating pins into the rung holes (refer to figure 7). Repeat the
proces to adjust the same height on the other half of the ladder.
Indicator
Indicator
Showing
NOT Showing
Note: If there is any pressure on the hinge pins, the hinge will be difficult to unlock. To relieve any
pressure, jiggle one half of the ladder to take the stress off the hinge pins and align holes on the
hinge. The hinge pins move freely in and out when stress is relieved.
Note: Do not foce the hinge with any tools. Permanent damage to the hinge mechanism can occur.
Only light pressure is required to unlock when holes are properly aligned.
Page 5.
Page 2.
3. Locating Pins
Set-up:
pressing the palm buttons fully inward, as indicated in figure 5. Pull the two halves
apart until the pins on both hinges snap into place and securely lock (refer to figure
10.). Push the palm buttons fully inward again and rotate one-half of the ladder to
its extension mode until the hinges snap into place and lock securely, (refer to
From the stored position (refer to figure 9), unlock both adjustable hinges by
figure 11.).
Fleight Adjustment:
If more height is desired, unlock the locating pins and extend the upper section of
the outer ladder out until you reach the desired height. Securely lock the locating
pins into the rung holes.
Page 3.
Page 4.