You are on page 1of 11

*** ZTE EMS Client Installation Guide ***

1. Go to run & type \\10.231.12.116 as shown below

2. A password prompt will appear, provide your mobilink domain credentials in below mentioned
format

3. A network location will appear, go to ems\ZTE & copy the zipped file U31V12.13.51P10
4. Now paste the zipped file on your computers drive
5. Unzip the file using standard compression software like winzip or winrar

6. Now go to extracted folder & run setup

7. After running the setup, below mentioned screen will appear, press enter to continue

8. After pressing enter, it will start to unzip files on local disk of your system

9. After few minutes, below mentioned installation screen will appear, press next to continue

10. Accept the license agreement & click next

11. Select the options shown in below screen shot & press next (only these options should be selected)

12. The next screen will ask you to select the products for installation. Only select MOSS, GSM &
UMTS (along with their sub-options).If you need to change the installation directory please change
here or accept default & press next to continue

13. If an option as shown below appears, press YES & continue

14. Below mentioned screen will appear, press next to continue

15. Next screen will ask you to confirm the products information. Please verify that the products for
installation include all products as shown below

16. Press install to start the installation

17. Once all files are copied press next to continue

18. Select default options & press next to continue (no changes are required in this step)

19. Screen as shown below will appear & it will show you the progress

20. Click next to continue

21. Click finish to complete the installation

22. Now go to your desktop & click U31 Client shortcut. If the shortcut does not appear automatically,
go to the installation directory (C:\netnumen\ems\ums-client) & create the client shortcut manually

23. Now run the ZTE client, below mentioned login window will appear

24. Change the server address to 10.231.250.180 & login using your credentials shared by TEC-NOC
ACCESS MANAGEMENT TEAM

25. An update prompt will appear as shown below, click OK to install EMS updates

26. Client will download the updates, press OK if below mentioned warning appears

27. Client will install the updates, press YES to clear the temporary backup directory

28. Client upgrade is complete now & below mentioned dialog box will appear which shows that client
has been successfully updated, press OK

29. Now again run the ZTE EMS client from the desktop shortcut created in step 22 & login using your
credentials. Server address should be 10.231.250.180
30. ZTE EMS client will open, start using & contact TEC-NOC SYSTEM ADMINISTRATION
TEAM (noc.admin@mobilink.net) for any assistance if required.

You might also like