Professional Documents
Culture Documents
BHT-212-CAA-FM-1
Section 2
NORMAL PROCEDURES
2
TABLE OF CONTENTS
Subject
Paragraph
Number
Page
Number
Introduction ............................................................................................
Flight Planning .......................................................................................
Takeoff and Landing..........................................................................
Weight and Balance...........................................................................
Preflight Check.......................................................................................
Before Exterior Check .......................................................................
Exterior Check....................................................................................
Full System Check .............................................................................
Interior and Prestart check ...................................................................
Engine Start............................................................................................
Engine 1 Start.....................................................................................
Engine 2 Start.....................................................................................
Post Start ............................................................................................
Engine Fails to Start ..........................................................................
Dry Motoring Run...............................................................................
Systems Check ......................................................................................
Preliminary Hydraulic Check ............................................................
Engine Fuel Control Check ...............................................................
Governor Check .................................................................................
Fuel Crossfeed Valve Check.............................................................
Electrical Systems Check .................................................................
Cabin Heater Check ...........................................................................
Hydraulic System Check ...................................................................
Before Takeoff........................................................................................
Power Assurance Check ...................................................................
Takeoff ....................................................................................................
In-flight Operations................................................................................
Descent and Landing.............................................................................
Engine Shutdown...................................................................................
Postflight Check.....................................................................................
2-1 ...........
2-2 ...........
2-2-A .......
2-2-B .......
2-3 ...........
2-3-A .......
2-3-B .......
2-3-C .......
2-4 ...........
2-5 ...........
2-5-A .......
2-5-B .......
2-5-C .......
2-5-D .......
2-5-E .......
2-6 ...........
2-6-A .......
2-6-B .......
2-6-C .......
2-6-D .......
2-6-E .......
2-6-F........
2-6-G .......
2-7 ...........
2-7-A .......
2-8 ...........
2-9 ...........
2-10 .........
2-11 .........
2-12 .........
2-3
2-3
2-3
2-3
2-3
2-3
2-4
2-5
2-6
2-7
2-7
2-8
2-8
2-9
2-9
2-9
2-9
2-10
2-10
2-10
2-10
2-10
2-11
2-12
2-12
2-12
2-13
2-13
2-13
2-14
BHT-212-CAA-FM-1
CAA APPROVED
LIST OF FIGURES
Subject
Exterior Check Diagram ........................................................................
Figure
Number
2-1...........
Page
Number
2-15
CAA APPROVED
BHT-212-CAA-FM-1
Section 2
NORMAL PROCEDURES
Consult applicable weight and balance
Section 55.
instructions provided in Section
2-1. INTRODUCTION
This section contains instructions and
conditions, to securing helicopter after
N++
PREFLIGHT CHECK
applicable.
2-3.
FLIGHT PLANNING
be a detailed mechanical
(JO
2-2.
NOTE
be compiled as follows:
comprehensive as conditions
0.D
-(D
00000)
and destination.
--h
-.0
industrial emissions.
CHECK
Flight planning - Completed.
Publications - Check.
Ensure helicopter has been serviced as
required.
2-3
BHT-212-CAA-FM-1
CAA APPROVED
!C1
1. FUSELAGE - FRONT
a.0
04-
Check flag.
a-.
N++
>.i
Unobstructed.
NCO
and unobstructed.
m
4. FUSELAGE - AFT
Tail rotor driveshaft covers - Secured
for flight.
-1U)
(nn-
-(x
Stowed.
,cam
L+.
4W.,
G')CC
>..
doors closed.
13)
Gam)
C-E
-.n
0.-D-
VCR
caw
7'r
(DO
CA)
Rev.1
CAA APPROVED
BHT-212-CAA-FM-1
5. FUSELAGE
SIDE
a-1
--_
f/)
C_E
CSC
Nay
('3
7. CABIN TOP
switches -OFF.
Zit
HQ.o
0c0
7C'
caps secured.
(j)
black.
samples.
O'ff'
switches - ON.
<y'
leakage where visible. Check tempplates (four places per coupling) for
CAUTION
.................
switches -OFF.
MAINTENANCE PERSONNEL
BHT-212-CAA-FM-1
CAA APPROVED
Security
and
Inverters OFF.
Generators OFF.
CAA APPROVED
BHT-212-CAA-FM-1
N=o
-.0
NOTE
d++
- Test.
NOTE
tom
Instruments - Test.
first.
cups
J>,
NOTE
070-6
WC.
- Check.
Rotor - Clear.
CAUTION
increased.
.................
PROLONGED EXPOSURE TO
AMBIENT TEMPERATURES OF 0
C (32 F) OR LESS MAY FREEZE
N++
"'Z
Oz-
O-H
OVERSPEED. IF AN OVERSPEED
HUH
NOTE
N,,
00.0
((DD
C'3
BHT-212-CAA-FM-1
CAA APPROVED
0.<
r0-r
IoM
.................
CAUTION
.................
ENSURE THAT SECOND ENGINE
HAS ENGAGED. A NON-ENGAGED
-#<
=cg
0)(00
%Z%
t>`
NOTE
off
-40
_..
C.%
Ovzm
IF SUDDEN (HARD)
..l-
ENGAGED ENGINE.
o:)
seconds.
w-ZZOZ_
MAINTENANCE ACTION IS
REQUIRED.
-,,0
pressure.
#2 starter - ON.
CAA APPROVED
7.
BHT-212-CAA-FM-1
2-5-D.
1.
2.
2-5-E.
b.
Starter OFF.
c.
2.
3.
4.
5.
6.
Starter OFF.
7.
8.
9.
PRELIMINARY HYDRAULIC
CHECK
NOTE
2.
3.
BHT-212-CAA-FM-1
CAA APPROVED
CHECK
NOTE
++C0
Oil
below 50%.
NOTE
When crossfeed valve is opening
switch.
CHECK
operation is desired.
.................
aim
-`O
ate
,.*
both engines.
-t00
91)
CAUTION
2-10
.C0
0.0
NOTE
CAA APPROVED
BHT-212-CAA-FM-1
w4)
Section V.
>,4'
NOTE
If heater is on for takeoff, refer to
appropriate performance chart in
CAUTION
ABOVE 21 C OAT.
NOTE
WARNING
CHECK
O0=ca
indication of a malfunction of a
flight control actuator.
pressure
=31
decreases.
=.E;3
Loo
V-t
encountered, it may be an
=Nn
03o00
NOTE
2-11
BHT-212-CAA-FM-1
CAA APPROVED
22F-
desired.
WARNING
2_j
020
Non a-1
WARNING
and set.
CHECK
G)=v_(ncO
c=V0
2-8. TAKEOFF
NOTE
If fast slaving is desired, setTriple
roll
tachometer - 100%.
NOTE
2-12
CAA APPROVED
BHT-212-CAA-FM-1
from
from
BHT-212-CAA-FM-1
Pilot Remain at flight controls until
rotor has come to a complete stop.
CAA APPROVED
Battery switch OFF.
Moor aft main rotor blade with tie-down
assembly by drawing blade down lightly
against static stop and tying web strap to
tailboom. Install exhaust, inlet, and pitot
covers, if required.
BHT-212-CAA-FM-1
CAA APPROVED
CAA212FM-2-1
Figure 2-1.