Professional Documents
Culture Documents
POWER ELECTRONICS
LABORATORY
Experiment: 1
Section: ____ Group: ____
Date: ______
1.
2.
Group Members
3.
4.
5.
Result
Discussion
Total
:
:
:
:
Page 1
2. Calculate Vave and Vrms for Vout in Figure 1-3. [18 marks]
Page 2
EXPERIMENTAL
OBJECTIVE:
1. To observe and describe the time profile of the DC output voltage and current and
diode voltage for a single phase and three phase diode rectifier.
2. To perform solve mathematical problems based on the time profile obtained.
3. To gain the fundamental knowledge of power diode rectifier and simulate various
loads using SIMULINK@MATLAB
EQUIPMENTS:
Quantity
1
6
1
As required
As required
As required
As required
As required
Designation
Main isolating transformer
Silicon diode
Load Power electronics
Voltmeter/Ammeter
Oscilloscope
Isolating Amplifier
Probes
Safety connecting Cable, plug
Model
725 73K
735 02
735 09
727 10
735 26
500 851
3. Measure and record the parameters in Table 1. Note: Measure the I o,peak from the oscilloscope.
Switch off the supply.
6. Repeat procedure 3.
PART 3: 3-PHASE FULLWAVE RECTIFIER
Page 3
Part 1
Part 2
Part 3
Is,rms
Page 4
DISCUSSION:
1. Based upon results obtained in the experiment (Table 1), calculate all the parameters in
Table 2. Show the steps to calculate the performance parameters for Part 1 only.
Table 2: Performance Parameters for Part 1, 2 and 3 [20 marks]
Performance Parameters
Part 1
Part 2
Vac
Form Factor, FF
Ripple Factor, RF
Diode rating
Pdc
Pac
Efficiency,
Page 5
Part 3
2.
What can you conclude about each performance parameter in Table 2? [2x7 marks]