Professional Documents
Culture Documents
ELECTRIC AGITATOR
Single phase or 3-phase AC Induction motors are connected directly to the
agitator shaft. A 3-phase current motor 230/380V, IP55, ISO Cl is
supplied as standard the version. In the case of S i n g l e P h a s e
operation, the 3-phase current motor is equipped with an operating
capacitor.
Mixing equipment
The agitators are fitted with a three-blade PVDF or stainless steel
impeller which is connected to the shaft . Thus the fixed sense of rotation
is also to the right, if looked at the motor fan, in order to avoid the
propeller to be detached. The pitch of the propeller blades is left-handed
so that the media to be mixed is delivered towards the bottom.
Agitator shaft
The agitator shafts are mounted directly on the motor shaft. They are
available in stainless steel, stainless steel with PVDF coating or stainless
steel with PE coating. Standard lengths according to the following tables
are recommended, other lengths can be supplied upon request. The
length should be determined so that the distance of the mixing equipment
from the tank bottom equals the diameter of the agitator.
Technical data
Type
Nominal
power [kW]
Nominal
speed
Tank
Propeller
size
diameter [mm]
[1/min]
0.09
1380/2900
up to 300 l
100
0.12
1380/2900
up to 500 l
100
WS-018
0.18
1380/2900
from 500 l
100
WS -025
0.25
1380/2900
from 500 l
100
WS -037
0.37
1380/2900
up to 1000 l
125
WS -075
0.75
1380/2900
up to 3000 l
150
WS-09
WS-012
Accessories
Intermediate flange with V-ring as protection against escaping gases(for 0.05-0.12
kW agitators, other sizes upon request).
Hand Mixers
Hand mixers in the form of hand stirrers or vertical- motion
agitators are used in metering technology to mix a metering
solution quickly and smoothly in the chemical supply tank.
Whether a hand stirrer or agitator is selected depends on
which form of operation is preferred.
A vertical- motion agitator permits higher manual energy
input, while hand stirrer is adequate if the substances to be
mixed are soluble.
For mixing non-soluble suspensions or emulsions the use of
an electric mixer is recommended. our wide range of
agitators and our know-how in mixing processes allows us to
ensure the choice of the best agitator to match your
manufacturing process. We offer standard agitators with
customised solutions.
TANK
CAPACITY OF
60 LTRS
TANK
CAPACITY OF
500 LTRS
Installation precautions
It may be useful to provide flow breakers in the tank. The agitator must not be installed concentrically in the tank in order to minimize
funnel formation. Suction lines must be rigid. Flexible lines would wind around the agitator shaft. To make sure that metering is not
affected the funnel produced during agitation does not allow air to enter into suction line. Therefore the suction line must be installed
with the largest possible distance to the agitator. It can be useful to install the flow breaker in front of the suction line so that the
funnel flow has no effect.
Selection table
Type
0.12KW
0.12kw
0.12kw
0.12kw
0.37kw
0.12kw
800
900
1000
100-500
700
Stainless steel/PVDF
WS-50-12-S
PVDF-coated
PVDF
WS-50-12-V
Stainless steel
Stainless steel/PVDF
WS-70-12-S
PVDF-coated
PVDF
WS-70-12-V
Stainless steel
Stainless steel/PVDF
WS-80-12-S
PVDF-coated
PVDF
WS-80-12-V
Stainless steel
Stainless steel/PVDF
WS-90-12-S
PVDF-coated
PVDF
WS-90-12-V
Stainless steel
Stainless steel/PVDF
WS-10-37-S
PVDF-coated
PVDF
WS-10-37-V
Stainless steel
Stainless steel/PVDF
PVDF
WT-50-12-S
Stainless steel/PVDF
PVDF
WT-70-12-S
Stainless steel/PVDF
PVDF
WT-80-12-S
Stainless steel/PVDF
PVDF
WT-90-12-S
Stainless steel/PVDF
PVDF
WT-100-37-S
Stainless steel/PVDF
PVDF
WT-100-75-S
Stainless steel
PVDF-coated
0.12kw
800
Stainless steel
PVDF-coated
0.12kw
900
Stainless steel
PVDF-coated
0.37kw
1000
Stainless steel
PVDF-coated
0.75kw
1000
Model No
Stainless steel
PVDF-coated
0.12kw
Propeller
Stainless steel
PVDF-coated
Power
220V/1ph/50/60Hz
220V/1ph/50/60Hz
220V/1ph/50/60Hz
220V/1ph/50/60Hz
220V/1ph/50/60Hz
380V/3ph/50/60Hz
WT-50-12-V
380V/3ph/50/60Hz
WT-70-12-V
380V/3ph/50/60Hz
WT-70-12-V
380V/3ph/50/60Hz
WT-90-12-V
380V/3ph/50/60Hz
WT-100-37-V
380V/3ph/50/60Hz
WT-100-75-V
Contact:
DUBAI
SHARJAH
DAMMAM
RIYADH
JEDDAH
Subject to changes without notice.
Agi- R0- 16