Professional Documents
Culture Documents
2010-E-0234
Action
Mandatory
Recommended
Not required (Information only)
Other (information )
Time frame
Immediately
(by
)
Next maintenance
Upon failure
At your convenience
Not Applicable
Other(Information )
N/A
HOURS
YES
YES
YES
NO
NO
YES
NO
NO
REV
CURRENT
ISSUED DATE
REV
NEW
ISSUED DATE
DETAILS:
<Changes from Ver.27>
1. The following problems have been corrected by changing current control for when load is put on the run motor.
- When you make a hard turn (right/left) in normal travel under the condition which driving feeling setting
(Maintenance table11- address11) is 2, the traveling motor stops and subsequently the machine itself
stops.
- You cannot make a turn (right/left) in the bedside mode.
2. The traveling stability has been improved slightly by adding control function for correcting fluctuation on the
input value of the handle position.
<Part number> FW10G7514057C (one CPU ROM + two short-circuit connectors)
<Applicable machines>
Machines for the U.S.: #06820573 or later
Machines for countries other than the U.S.: #06920584 or later
The contents described or shown in our ECN documents and/or any information provided from FUJIFILM in verbal or written communication is intended for the
addressee and/or its organization. Transfer and/or copy distribution of the information without written consent of FUJIFILM is not permitted.
PAGE 1 of 2
K12N0028-6-J
NOTE
1) Important information about SUPPLY OF THE ARTICLES:
Charge: N/A
FREE OF CHARGE
UNTIL (mmddyyyy):
WITH YOUR CHARGE
The contents described or shown in our ECN documents and/or any information provided from FUJIFILM in verbal or written communication is intended for the
addressee and/or its organization. Transfer and/or copy distribution of the information without written consent of FUJIFILM is not permitted.
PAGE 2 of 2
K12N0028-6-J