Professional Documents
Culture Documents
I. INTRODUCTION
Hybrid,
Power
Filter,
3rd International Conference on Latest Computational Technologies (ICLCT'2014) March 19-20, 2014 Abu Dhabi (UAE)
Fig.3.7 Hybrid filter with a shunt passive filter and a series active
filter
Fig.3.8 A shunts passive filter and a shunt active filter and an active
filter in series with it
Fig.3.5 A shunt APLC scheme.
3rd International Conference on Latest Computational Technologies (ICLCT'2014) March 19-20, 2014 Abu Dhabi (UAE)
= 2HB
= -2HB
(4.5)
(4.6)
(4.7)
=
(4.2)
The switching logic is formulated as follows:
If >HB upper switch is OFF (S1=0) and lower switch is
ON (S4=1).
If <-HB upper switch is ON (S1=1) and lower switch is
OFF (S4=0).
The switching logic for phase b and phase c is similar as
phase a, using corresponding reference and measured currents
and hysteresis bandwidth (HB).
+
HB
=0
(4.8)
(4.9)
Chapter Summary
In this chapter the basic compensation principle is
described. That purely deepens up on the control algorithms.
For extraction of reference current the superior features of
SRF controller are described. The Hysteresis and adaptive
hysteresis current controller algorithm are explained. The
digital hysteresis current controller algorithm is also described.
(4.3)
=-
(4.4)
From Fig.4.10
3rd International Conference on Latest Computational Technologies (ICLCT'2014) March 19-20, 2014 Abu Dhabi (UAE)
TABLE 5.1
APF SYSTEM PARAMETERS USING SRF THEORY
SYSTEM PARAMETERS
VALUE
Line Voltage
415V
Supply Frequency
50HZ
Source Impedance:(Resistance Rs,
1 , 0.1 mH
Inductance
Ls)
Non-Linear load under steady
10 , 100 mH
state:(Resistance Rs, inductance Ls)
Filter Impedance:(Resistance Rs,
1 , 2.5 mH
inductance
Ls)
Dc side capacitance
800 V
Power converter
6 MOSFET/DIODE
3rd International Conference on Latest Computational Technologies (ICLCT'2014) March 19-20, 2014 Abu Dhabi (UAE)