Professional Documents
Culture Documents
ACO Maripur
ACO Maripur
ACO Marine
Introduction, characteristic
Denmark Ringsted
7
1
5
4
ACO Maripur
Technological description
The ACO Maripur waste water treatment
plants were developed based on the biological waste water treatment technology in
combination with submerged micro-filtration units and were optimised for use on
ships and marine structures. The microfiltration units (2) are directly installed in
the bioreactor (1) and are equipped by
aerated elements below. All other devices
are situated outside of the bioreactor on
one wall of it.
The waste water enters the bioreactor
through inlet pipe on a top.
The aerobic degradation of water contaminants is provided by permanent aeration
through the aerated elements below microfiltration units. Due to the upward air flow
within the membrane modules, the membrane surface is permanently swept and
freed of adhering solids.
The biologically cleaned waste water is withdrawn exclusively through micro-filtration
units by the effluent pump (4). The low suction pressure of 0.10.2 bar (max. 0.4 bar)
on the trans-membrane side effectively prevents solid filter cakes from building up on
the membranes.
The surplus sludge is discharged periodically from the bioreactor by surplus sludge
pump (5)
To avoid increasing of a foam in the bioreactor is the ACO Maripur equipped by the
antifoam unit consisting of antifoam liquid
barrel (6) and dosing pump (7).
Efficiency of purification
The ACO Maripur system applies to ships
and marine structures the process of biological waste water treatment in combination
with submerged low-pressure micro-filtration membranes, which act as barriers to
the activated sludge as well as to bacteria
and viruses. Accordingly the ACO Maripur
technology purifies water - without any final
clarification - that meets the quality stan-
1. Bioreactor
2. Micro-filtration units
4. Effluent pump
7. Dosing pump
Sizing, design
The ACO Maripur was developed as
a modular system of four basic sizes for
purification of waste water from 25, 50,
100 and 200 people. However we are
ready to produce individual solutions for
any other request.
The bioreactor is produced from stainless
steel AISI 316Ti as standard. The bioreactor from other materials is as well possible
after a consultation.
The ACO Marine units are equipped by
electric components 400 460 volts,
50 or 60 Hz.
3. Blower
7
Waste water inlet
Ventilation
6
4
Biologically
treated water
2
2
5
3
Surplus sludge
Air
ACO Maripur
TECHNICAL DATA OF WWTP ACO MARIPUR
Type
Type
Type
Type
ACO Maripur 25
ACO Maripur 50
4.63
9.25
18.50
37.00
(black/grey water)
5.75
11.50
23.00
46.00
Overall Dimensions
Length [mm]
1,450
1,950
2,450
3,450
Width [mm]
1,000
1,250
1,600
2,000
Height [mm]
1,950
2,050
2,300
2,550
840
1,120
1,830
3,540
Weight
Pipe Connections
2,190
3,815
6,960
14,390
Sewage inlet
DN 65
DN 80
DN 100
DN 125
DN 40
DN 40
DN 50
DN 65
Surplus Sludge
DN 40
DN 40
DN 40
DN 40
Ventilation
DN 80
DN 100
DN 125
DN 150
BUFFER
TANK
SCREEN
SEWAGE
PUMPS
BLACK WATER
COLLECTOR
GREY WATER
ACO MARIPUR
BIOREACTOR
ACO MARIPUR
BIOREACTOR
EFFLUENT
PUMP
EFFLUENT
SLUDGE
PUMP
EFFLUENT
SLUDGE
PUMP
EFFLUENT
PUMP
CLEANING
AGENT
CLEANING
AGENT
SURPLUS WATER
TREATED WATER
ACO Maripur
subject to alterations
ACO/01/2011